2019 MERCEDES-BENZ SPRINTER 3500 Complaints

Description of Incident:The electronic ignition module suffered a sudden failure due to unsealed manufacturer water intrusion, leaving the vehicle completely stranded with an immediate safety hazard. Component failed & available for inspection: Electronic Ignition Switch (EIS) module / Ignition Control Module. Yes, it is available for inspection. Safety risk: The sudden failure causes an immediate safety hazard by leaving the vehicle completely stranded with no way to shift the transmission into neutral to pull it out of harm's way. Confirmed by dealer/independent center: NO, the vehicle has not been towed to a shop yet due to the high cost of repairs. Inspected by manufacturer/police/insurance: NO Warning lamps or symptoms prior: There were no warning messages. The ignition system simply went completely dead without warning.

Hello, I recently took the vehicle to the official Mercedes Benz dealership for recalls and they have completed all of them , Also have proof of correction document I can send it over, please update the system Thanks

The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA Campaign Number: 22V796000 (POWER TRAIN), and the vehicle was taken to a local dealer, where the vehicle was repaired under recall, and the contact was informed that the knock sensor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 98,000.

The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated that while driving at an undisclosed speed, the passenger’s side bunk window detached and fell off. The contact stated that the window was a frameless window and was sealed with adhesive. The contact researched and discovered an unknown recall; however, the contact VIN was not associated with the recall. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 9,100.

At high elevations, at some times soon after a cold start the throttle becomes completely unresponsive. This is not a low power issue due to altitude--even putting the throttle pedal to the floor, the RPMs remain at idle and do not move at all. After I power down and restart, it worked briefly and then again became unresponsive. Once the engine is warm, the problem has not appeared. This put me in an unsafe situation on two occasions: 1) Pulling out of a parking lot onto a 2 lane snow covered highway, the throttle became completely unresponsive while I was sitting across both lanes of traffic, leaving me exposed to a collision. I had to shut off and restart the engine to get moving. Elevation 10,700 feet. 2) In a parking lot, moving to get out of the way of a snowplow. I had to restart the vehicle 5 times before I was able to get out of the snowplow's way. Elevation 9,700.

Function goes off intermittently sometimes for a week at a time Also signals brake problems on dash

The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated that the passenger seat failed to move forward or backward electrically. The vehicle was taken to the dealer who stated that the wiring had wrapped around the seat track and fractured. The contact was informed that the failure was common. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 14,000. The consumer requested that their vehicle be added to NHTSA recall 21V-410 and any other applicable recalls.

After MB performed required "Campaign" #2021070027 related to transmission, CDI, VGS and SCR (emissions controls), transmission now shift erratically and sometimes unpredictably, engine in now running a higher RPMs, oil pressure is higher and fuel economy (as measured by manual calculations) has decreased by not less than 15%. Vehicle was originally taken to MB dealer related to a repeated (3 times) intermittent/unexpected power loss and dash warning. Loss of power could lead to loss of control, especially at highway speeds. The vehicle was inspected and above noted campaign was applied. Mileage on the vehicle is currently 15000. Events took place between 12k and 14.5k. Degrade of fuel economy as well as other operations degradations took place after a service visit at 14.5k.

EIS controle module failed and Sprinter won't restart. Happened on the freeway when I was driving

The contact owned a 2019 Mercedes-Benz Sprinter 3500. The contact stated while driving at 50 MPH with his wife in the front passenger seat and six passengers in the rear seats, the vehicle began to stall. There were no warning lights illuminated. The contact heard an abnormal sound coming from the engine and noticed smoke coming out of the hood and inside the cabin of the vehicle. The contact veered to the side of the road and turned off the vehicle. Both the contact and his wife exited the vehicle. The contact stated while he was contacting road side assistance, his wife noticed smoke and flame coming out of the front passenger's side Whewell of the vehicle. All the passengers exited the vehicle. The contact extinguished the fire with a fire extinguisher; however, the fire restarted and increased significantly. The contact stated that the fire burned the front end of the vehicle. There were no injuries sustained. The fire was extinguished by the fire department. A fire department report was filed. A police report was filed. The vehicle was towed to a tow lot where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 21,000.