2006 MERCURY MILAN Complaints

DRIVER'S SIDE DOOR HANDLE BROKE IN THE PROCESS I DISLOCATED MY FINGER. DOOR WILL NOT LOCK FROM INSIDE OR OUTSIDE. ONLY WAY OUT IS TO EITHER OPEN THE WINDOW (WHICH IS NEARLY IMPOSSIBLE IN MICHIGAN WINTERS) OR PULL THE LOCK OPEN FURTHER AT THE SAME TIME THAT I PULL THE DOOR HANDLE. I HAVE BROKEN COUNTLESS FINGERNAILS ON MY LEFT HAND BECAUSE OF THIS. THE DOOR PIECES ARE SO FLIMSY, YOU CAN TELL THAT THEY ARE MADE OUT OF VERY, VERY CHEAP PLASTIC. RECALL? NOT ONLY IS THIS A NUISANCE, BUT IT IS A VERY HIGH SECURITY ISSUE IF NEEDING TO GET OUT OF THE CAR IN A HURRY. *TR

TL* THE CONTACT OWNS A 2006 MERCURY MILAN. THE CONTACT STATED THAT WHILE DECELERATING FROM 30 MPH, THE TRANSMISSION KNOCKED AND SLIPPED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST. THE TEST RESULTS SHOWED A DEFECT VALVE BODY ON THE TRANSMISSION. THE DEALER REPLACED THE VALVE BODY. 44,000.

TL* THE CONTACT OWNS A 2006 MERCURY MILAN. THE CONTACT STATED THAT THE REAR PASSENGER SIDE WINDOW FELL INTO THE DOOR PANEL AND FAILED TO CLOSE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY WERE TOLD THAT THE WINDOW WOULD NEED A NEW MOTOR. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE WINDOW ALSO FAILED. THE DEALER STATED THAT MOTOR WOULD HAVE TO BE REPLACED AS WELL. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 65,000. *TR

TL* THE CONTACT OWNS A 2006 MERCURY MILAN EQUIPPED WITH FUTURE TOURING VR 545 TREAD DEPTH TIRES, SIZE 225/50/R17. THE CONTACT STATED THAT WHILE DRIVING IN INCLEMENT WEATHER AND TRYING TO ACCELERATE, THE TIRES SPUN OUT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE TIRES WERE PERFORMING TO STANDARDS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 40,000. UPDATED 4/1/13 *CN UPDATED 4/5/13 *CN THE CONSUMER STATED HE PURCHASED FOUR TIRES, AND PRESENTLY THEY HAVE 70% TREAD LEFT. THE CONSUMER STATED WHEN HE ATTEMPTED TO DRIVE IN RAINY WEATHER, HE FELT THE WHEELS SPIN, AND IT WAS DIFFICULT TO DRIVE.

PULLED INTO A PARKING LOT WITH MY SON IN THE FRONT PASSENGER SEAT. SHUT OFF THE ENGINE AND ATTEMPTED TO PULL THE DRIVER DOOR HANDLE TO EXIT THE VEHICLE. IT (THE HANDLE) BROKE IN HALF AND WAS UNABLE TO EXIT THE VEHICLE QUICKLY OR SAFELY. I BEGAN TO PANIC AS I FELT TRAPPED. SO I ROLLED DOWN THE POWER WINDOW FOR AIR AND TO CALM DOWN. BEFORE I WAS ABLE TO THINK CLEARLY AND TRY OPENING THE DOOR WITH THE EXTERIOR HANDLE FROM THE INSIDE, I EXITED THE VEHICLE THROUGH THE DRIVER WINDOW. THIS IS CLEARLY A SAFETY ISSUE AS THE HANDLES ARE A CHRONIC PROBLEM ON ALL 4 INTERIOR DOORS. SOMEONE WILL NEED TO EXIT THEIR VEHICLE QUICKLY. IF THIS HAPPENS THEY ARE SLOWED DOWN IF NOT TRAPPED INSIDE. HOW MANY COMPLAINTS WILL IT TAKE TO MAKE THIS A RECALL ISSUE? FORD HAS MADE NO EFFORT TO CORRECT THIS PROBLEM AND RE INSTALLS THE SAME DEFECTIVE DOOR HANDLES AT THE DEALERS. THIS SHOWS A LACK OF DUE DILIGENCE ON FORD MOTOR COMPANIES PART. MANY FORD FUSION & MERCURY MILAN OWNERS HAVE HAD THE SAME PROBLEM HAPPEN ON THE REPLACEMENT HANDLES ALSO. *TR

MY DRIVER'S SIDE INSIDE DOOR HANDLE BROKE. I WAS TRYING TO GET OUT OF THE CAR AFTER PARKING IT BUT COULDN'T. I HAD TO ROLL DOWN THE WINDOW AND OPEN THE DOOR USING THE OUTSIDE DOOR HANDLE. THIS IS A REAL SAFETY PROBLEM AND SINCE THIS ISN'T AN ISOLATED EVENT, (NOTICE THE NUMBER OF COMPLAINTS AND THE NUMBER OF MULTIPLE REPAIRS/REPLACEMENTS) FORD SHOULD REPLACE THEM OR UPGRADE THEM TO SOMETHING MORE RELIABLE. AT SOME POINT SOMEONE WILL BE INJURED OR WORSE BECAUSE THEY WEREN'T ABLE TO EXIT THEIR CAR QUICKLY. *TR

THE PLASTIC INTERIOR DOOR HANDLES BROKE WITHOUT EVEN TOUCHING THEM. BOTH FRONT HANDLES BROKE WITHIN A WEEK OF EACH OTHER. I DIDN'T KNOW THE FRONT PASSENGER SIDE WAS BROKEN UNTIL MY WIFE ASKED ME TO GET OUT OF THE CAR TO LET HER OUT ON HER SIDE. AND THEN APPROXIMATELY A WEEK LATER THE DRIVER'S SIDE INTERIOR HANDLE BROKE ALSO. NOW NEITHER DOOR CAN BE OPENED FROM THE INSIDE. THE WINDOW NEEDS TO BE ROLLED DOWN AND THE OUTSIDE HANDLE NEEDS TO BE USED. WHEN WE BOUGHT THE CAR (USED) THE REAR DRIVER'S SIDE INTERIOR HANDLE PLASTIC WAS BROKEN AND WE KNEW THIS. EVEN BROKEN YOU CAN STILL USE IT TO OPEN THE REAR DOOR. I WAS IN THE DRIVERS SEAT WHEN THE DRIVER'S INTERIOR HANDLE BROKE. I WAS PARKED, AND I HEARD A CLICK BEFORE I TRIED OPENING MY DOOR FROM THE INSIDE AND THE DOOR WOULD NOT OPEN. THERE IS DEFINITELY A BIG PROBLEM WITH THESE CHEAP PLASTIC DOOR HANDLES THAT FORD MOTOR COMPANY NEEDS TO ADDRESS. THREE OUT OF FOUR INTERIOR HANDLES ARE BROKEN. IT IS TRULY A SAFETY ISSUE IF YOU CANNOT EXIT YOUR CAR USING THE INTERIOR DOOR HANDLES. *TR

MY POWER STEERING FAILED AS I WAS PULLING OUT OF A PARKING SPACE. I HEARD A FAINT NOISE LIKE A MARBLE DROPPING ONTO A SURFACE AND ROLLING AS I STARTED THE CAR. I QUICKLY REALIZED I WAS NOT ABLE TO STEER THE CAR. I HAD THE CAR TOWED TO MY MECHANIC. HE INFORMED ME THAT THE BOLT ON THE IDLER PULLEY BROKE, AND PART OF THIS BOLT FELL INTO THE ENGINE. WHEN I ASKED HIM HOW THIS COULD HAPPEN, HE INFORMED ME THAT HE BELIEVED IT WAS DUE TO THE FAULTY DESIGN - PLACING TOO MUCH PRESSURE ON THIS BOLT, CAUSING IT TO EVENTUALLY BREAK IN TWO. THEY HAD TO TAKE THE ALTERNATOR OFF TO RECOVER THE PIECE OF THE BOLT THAT FELL INTO THE ENGINE. THE IDLER PULLEY WAS THEN REPLACED. I BELIEVE THAT IF THIS HAD HAPPENED WHILE I WAS DRIVING, ESPECIALLY AT A HIGH SPEED, IT WOULD HAVE CAUSED A VERY SERIOUS IF NOT FATAL ACCIDENT. *TR

I HAVE A 2006 MERCURY MILAN AND I HAVE HAD TO REPLACE THE DRIVER'S DOOR HANDLE TWICE. ONCE WAS UNDER WARRANTY DUE TO THE "CHROME" PEELING OFF. THE SECOND TIME IT WAS REPLACED THE DOOR HANDLE BROKE AND I ENDED UP PAYING $54 FOR A NEW PLASTIC HANDLE. I HAVE ALSO HAD THE PASSENGER SIDE DOOR HANDLE TO BREAK IN THE SAME SPOT AND HAD TO REPLACE IT AND THAT COST ME $35 AT THE TIME DUE TO ME WORKING FOR A LOCAL FORD COMPANY. I STRONGLY FEEL THAT THIS IS A SAFETY HAZARD BECAUSE IF THE VEHICLE CAUGHT ON FIRE OR YOU HAD AN ACCIDENT AND THE HANDLE HAPPENS TO BREAK AT THE SAME TIME YOU WOULD HAVE TO ROLL THE WINDOW DOWN TO OPEN THE HANDLE FROM THE OUTSIDE OR CRAWL TO THE PASSENGER SIDE TO GET OUT. ANYONE OF LARGER SIZE WOULD HAVE TROUBLE CRAWLING TO THE PASSENGER SIDE TO GET OUT OF THE VEHICLE. I ALSO FEEL THAT FORD SHOULD HAVE TO RECALL THESE HANDLES AND PUT SOMETHING WITH HIGHER QUALITY IN THAT WILL NOT BREAK. I PERSONALLY FORESEE THIS BEING A LAWSUIT WAITING TO HAPPEN. *TR

VEHICLE AUTOMATIC TRANSMISSION WILL ATTEMPT TO DOWNSHIFT TO LOWER GEAR ON AN UPWARD HILL OR GRADE. WITHOUT WARNING, TRANSMISSION DISENGAGES, SLIPS, AND SUDDENLY JERKS INTO GEAR CAUSING THE VEHICLE TO LUNGE FORWARD, SOMETIMES FORCEFUL ENOUGH TO POSSIBLY LOSE CONTROL. MANY OTHER FORD VEHICLE MODELS WERE ALSO AFFECTED. FORD ISSUED A TECHNICAL SERVICE BULLETIN #08-24-1 IN 2008 ABOUT THE KNOWN PROBLEM, BUT WILL DO NOTHING ABOUT IT AFTER WARRANTY EXPIRATION. *TT