2010 MERCURY MILAN HYBRID Complaints

WAS DRIVING DOWN THE INTERSTATE AT 65 MPH, VEHICLE SUDDENLY LOST ACCELERATION AND ENGINE AND THROTTLE/POWER TRAIN INDICATOR LIGHTS ILLUMINATED ON THE DASH. HAD TO PULL OFF ON THE SIDE OF THE HIGHWAY. I TURNED OFF THE VEHICLE AND TURNED IT BACK ON, I WAS ABLE TO DRIVE THE VEHICLE HOME AT 40 MPH, BUT THE INDICATOR LIGHTS REMAINED ON.

TL* THE CONTACT OWNS A 2010 MERCURY MILAN HYBRID. WHILE DRIVING AT 50 MPH, THERE WAS A SUDDEN LOSS OF ACCELERATION. IN ADDITION, THE CHECK ENGINE AND MAINTENANCE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

I WAS DRIVING BETWEEN 35-40 MPH WHEN ALL OF A SUDDEN I LOST POWER. ALTHOUGH I SUBSEQUENTLY HAD THE ACCELERATOR TO THE FLOOR, THE VEHICLE REDUCED ITS SPEED DRASTICALLY AND COULD NOT EXCEED ABOUT 10 MPH. I PULLED OVER AND THE WRENCH INDICATOR LIGHT CAME ON. I WAS ABLE TO DRIVE TO A PARKING LOT AT VERY LOW SPEED AND TURNED THE VEHICLE OFF. WHEN I TURNED IT BACK ON, IT WAS RESPONSIVE FOR ABOUT TWO BLOCKS AND THE SAME SYMPTOMS REAPPEARED. THIS TIME THE WRENCH LIGHT AND CHECK ENGINE LIGHT CAME ON. FORTUNATELY, I WAS A FEW BLOCKS FROM A FORD DEALER. I VERY CAREFULLY WAS ABLE TO DRIVE AT A VERY SLOW UNRESPONSIVE SPEED TO THE DEALER.THEY REPLACED THE THROTTLE BODY BUT FORD INFORMS ME IT DOES NOT FALL UNDER THEIR CUST. SATISFACTION #13N03 EXTENDED WARRANTY PROGRAM. ALTHOUGH IT IS THE SAME SYMPTOMS, SAME YEAR, SAME MODEL, SAME DIAGNOSTIC CODE, SAME FAILURE AND SAME PART FIX AS THE VIN'S THAT ARE COVERED IN THIS PROGRAM. FORD CANNOT TELL ME (OR SHOULD I SAY 'WILL' NOT TELL ME) WHY MY VIN IS NOT COVERED IN THEIR 'SATISFACTION' PROGRAM. THIS WAS A $400 REPAIR.

MY 2010 MERCURY MILAN HYBRID WAS PURCHASED AS CERTIFIED PRE-OWNED IN MARCH 2013 IN FLORIDA. SINCE IT WAS CERTIFIED PRE-OWNED AND IT WAS ALSO NOT REQUIRED BY FLORIDA TO HAVE ANY SAFETY INSPECTION, I NEVER PAID ANY ATTENTION TO ANY LIGHTS. IN APRIL 2015, I TOOK MY CAR FOR A SAFETY INSPECTION, WHICH IS A REQUIREMENT FOR A CAR TO BE REGISTERED IN VIRGINIA, SINCE I MOVED BACK TO VIRGINIA. THE CAR DID NOT PASS THE VA SAFETY INSPECTION BECAUSE THE DRIVER'S SIDE REAR BRAKE LIGHT WAS ON ALL THE TIME. (I FOUND THERE WERE NUMEROUS POSTS ON THE INTERNET DESCRIBING THIS PROBLEM -- BRAKE LIGHTS STAYING ON). THE ENTIRE LIGHT ASSEMBLY CAN ONLY BE BOUGHT FROM THE DEALERSHIP. I HAVE TO PAY FOR IT SINCE I WAS TOLD BY THE DEALERSHIP THE ASSEMBLY WAS NO LONGER COVERED BY THE WARRANTY. THE ASSEMBLY REPLACEMENT WAS $365.54 (AFTER TAX). I LIKE TO LODGE A COMPLAINT AGAINST THE FORD COMPANY ABOUT A RECALL ON THIS INFERIOR LIGHT ASSEMBLIES, AND MONETARY SUPPORT FROM FORD ON THIS ISSUE. I FEEL FORD SHOULD CORRECT THE PROBLEM AND RECALL THE ASSEMBLIES.

MY 2010 MERCURY MILAN HYBRID WAS PURCHASED NEW IN JUNE, 2010. IN FEBRUARY, 2013, THE REAR, PASSENGER SIDE TAIL LIGHT WENT OUT. I TRIED TO BUY A REPLACEMENT BULB AT AN AUTO PARTS STORE ONLY TO DISCOVER THERE WAS NO REPLACEMENT PART NUMBER IN THEIR BOOKS FOR MY CAR. ON FEBRUARY 8, 2013, THE DEALERSHIP TOLD ME THE ENTIRE REAR LIGHT ASSEMBLY HAD TO BE REPLACED BECAUSE IT WAS A SEALED SYSTEM. I WAS FORTUNATE THAT THE WORK COULD BE DONE UNDER WARRANTY AT THAT TIME. THEN IN JAN., 2015, A DRIVER WHO HAD BEEN BEHIND ME, KINDLY TOLD ME THAT THE DRIVER'S SIDE REAR BRAKE LIGHT WAS ON ALL THE TIME. THERE ARE NUMEROUS POSTS ON THE INTERNET DESCRIBING BOTH PROBLEMS (BULB BURN OUT AND BRAKE LIGHTS STAYING ON). AGAIN, THE ENTIRE LIGHT ASSEMBLY HAD TO BE REPLACED BY THE DEALERSHIP, THIS TIME AT MY EXPENSE. THE REPLACEMENT COST WAS $547.59. ON JANUARY 29, 2015, I PHONED FORD MOTOR COMPANY TO LODGE A COMPLAINT AND INQUIRE ABOUT A RECALL ON THESE INFERIOR LIGHT ASSEMBLIES, OR MONETARY SUPPORT FROM FORD ON THIS ISSUE. I WAS TOLD ALL COMPLAINTS TO THE MFG. ARE RECORDED AND TRACKED, BUT THE CUSTOMER SERVICE REP. WAS NOT AWARE OF THE PROBLEM. SHE COULD DO NOTHING FOR ME RETROACTIVELY AND SUGGESTED I CALL THE DEALERSHIP'S SERVICE MANAGER TO SEE IF HE/SHE HAD ANY PROGRAMS IN PLACE TO HELP. (WOULDN'T THOSE PROGRAMS COME FROM THE MFG.??) I ASKED IF THE PART HAD BEEN REDESIGNED AND WAS TOLD THE DEALERSHIP'S SERVICE MANAGER WOULD HAVE THAT INFORMATION ALSO. I THEN SPOKE TO THE DEALERSHIP'S SERVICE MANAGER WHO TOLD ME THE PART NUMBER FOR THE ASSEMBLY HAS NOT CHANGED, INDICATING THE PROBLEMS HAVE NOT BEEN ADDRESSED. IT IS TOTALLY UNREASONABLE TO HAVE TO PAY ALMOST $550. TO CHANGE A FAILED TAIL LIGHT BULB, ESPECIALLY WHEN THE REPLACEMENT ASSEMBLIES HAVE THE SAME FLAW AND POTENTIAL TO FAIL AGAIN. I FEEL FORD SHOULD CORRECT THE PROBLEM AND RECALL THE ASSEMBLIES. *TR

TL* THE CONTACT OWNS A 2010 MERCURY MILAN HYBRID. THE CONTACT STATED THAT THE PLASTIC ENGINE COVER RUBBED A HOLE THROUGH THE HIGH VOLTAGE WIRING. THE VEHICLE WAS TAKEN TO A DEALER FOR AN UNRELATED ISSUE. THE TECHNICIAN MADE THE CONTACT AWARE OF THE EXPOSED HIGH VOLTAGE WIRING. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 63,000. THE VIN WAS UNAVAILABLE.

WHILE DRIVING APPROXIMATELY 40 MPH, THE DASHBOARD SHOWED A MESSAGE THAT THE POWER STEERING SYSTEM NEEDED TO BE SERVICED AND THE POWER STEERING SUDDENLY STOPPED WORKING MAKING IT EXTREMELY DIFFICULT TO STEER THE VEHICLE. *TR

WAS ALERTED THAT MY LEFT REAR PASSENGER TAIL LIGHT ON MY 2010 MERCURY MILAN HYBRID WAS ABNORMALLY BRIGHT AND THAT BRAKE LIGHT DID NOT CHANGE ILLUMINATION LEVEL. TOOK CAR TO DEALERSHIP AND WAS INFORMED THAT ENTIRE ASSEMBLY WAS FAULTY AND WOULD NEED TO BE REPLACED FOR $600. I HAVE AN EXTENDED WARRANTY, PREMIUMCARE ECP, AND WAS TOLD THAT THIS WAS NOT A WARRANTY ELIGIBLE ITEM AND IS INSTEAD CONSIDERED CONSUMABLE BECAUSE THERE ARE LEDS INVOLVED. THERE ARE NO BULBS BURNED OUT, THEY ARE HIGHLY ILLUMINATED ALL THE TIME DUE TO A MANUFACTURING DEFECT. THIS IS A SAFETY ISSUE, NOT A CONVENIENCE ISSUE. *TR

WHILE DRIVING FELLOW MOTORIST ADVISED MY LEFT REAR LIGHT NOT OPERATING. VISIT TO DEALER CONFIRMED AND PRICE TO REPAIR $400 PLUS LABOR. THAT SEEMS A BIT HIGH TO REPLACE A LIGHT BULB! FORGET IT I WILL DRIVE UNTIL TICKETED. HOWEVER JUST BEFORE MY 3 YR WARRANTY WAS UP IT HAPPENED BUT ON THE RIGHT REAR EXTERIOR. THAT INCIDENT WAS AT NO CHARGE AT THE DEALERSHIP. WHY BOTH IN SUCH A SHORT PERIOD OF TIME WITH SUCH A NEW CAR? *TR

REAR LED TAILLIGHT MALFUNCTIONS. COST TO REPLACE IS NEARLY $400.00. THIS SEEMS A VERY HEIGHT COST TO MAINTAIN A NECESSARY AND LEGALLY REQUIRED PIECE OF SAFETY EQUIPMENT. *TR