1994 MERCURY SABLE Complaints

TL* THE CONTACT OWNS A 1994 MERCURY SABLE. WHILE DRIVING VARIOUS SPEEDS OR IDLING, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

NEED PROOF OF TOTAL RECALL OF THIS VEHICLE BY FORD MOTOR COMPANY. I HAVE A LIST OF COMPLAINTS, I NEED PROOF OF THE TOTAL RECALL OF THIS VEHICLE. VIN # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MANUFACTURER WILL NOT HONOR RECALL: SEVERE CORROSION OF THE REAR LOWER RETAINING PLATES FOR THE SUBFRAME ASSEMBLY SUPPORTING THE ENGINE AND TRANSMISSION. RISK IS DETACHMENT OF BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME. EXISTING RECALL 98V-323 ADDRESSED THIS PROBLEM IN CERTAIN VEHICLES. MY VEHICLE WAS OF THE YEAR, MAKE, AND MODEL COVERED BY THE RECALL, AND HAS THIS PROBLEM, BUT FORD IS CLAIMING THAT MY VIN# DOES NOT MAKE ME ELIGIBLE FOR THE RECALL. *TR

TL*THE CONTACT OWNS A 1994 MERCURY SABLE. THE CONTACT DROVE OVER A POTHOLE AND THE FRONT STRUT BROKE ON BOTH SIDES. THE VEHICLE WAS TOWED TO A MECHANIC WHO STATED THAT THERE WAS A RELATED RECALL 94E036000 (SUSPENSION: FRONT: SHOCK ABSORBER). THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 139,500. UPDATED 07/08/11*LJ THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE FRONT STRUT HAD BROKEN IN HALF. THE REMAINING STRUTS CONTAINED STRESS CRACKS. UPDATED 07/20/11

TRAVELED APPROXIMATELY 120 MILES FROM HOME. UPON ARRIVING AT THE DESTINATION, I NOTICED THE RIGHT REAR TIRE WAS EXTREMELY LOW WITH AS ESTIMATED 10 P.S.I. AIR PRESSURE REMAINING. KNOWING THAT I HAD TWO PREVIOUS TIRE BLOWOUTS ON THIS VEHICLE DUE TO CRACKED VALVE STEMS AND OCCURRING WITHIN THE PREVIOUS 4 MONTHS, I MOVED THE VALVE STEM SLIGHTLY BACK AND FORTH AND NOTICED AIR ESCAPING FROM THE AREA WHERE THE STEM SEATS AGAINST THE ALUMINUM WHEEL. I PUT SOME SOAP BUBBLES AROUND THE STEM AND CONFIRMED THAT AIR WAS ESCAPING FROM A CRACK IN THE VALVE STEM. REFERENCE ODI #'S 10254187 AND 10254189 AS A REFERENCE ON THE PREVIOUS TWO VALVE STEM ISSUES ON SAME VEHICLE. SPARE INSTALLED. VISITED THE TIRE DEALERSHIP WHERE THE FOUR NEW REPLACEMENT TIRES WERE INSTALLED 2 YEARS, 8 MONTHS AND 26,068 MILES PRIOR. NO PUNCTURES, TEARS OR CUTS WERE FOUND ANYWHERE ON THE TIRE TREAD OR SIDEWALL. THE ONLY KNOWN CAUSE OF THE LOW TIRE WAS A CRACKED VALVE STEM IN THE AREA WHERE THE STEM SEATS AGAINST THE ALUMINUM WHEEL ALLOWING AIR TO EXHAUST QUICKLY FROM THE TIRE ONCE THE CRACK PROPAGATED TO INSIDE. A NEW VALVE STEM WAS INSTALLED. THE LEFT REAR TIRE VALVE STEM WAS ALSO REPLACED AT THIS TIME TO AVOID A FUTURE PROBLEM. CRACKED VALVE STEM INFORMATION; TR 413, EHA GERMANY. *TR

TRAVELING AT APPROXIMATELY 65 MPH WHEN RIGHT FRONT TIRE NEAR INSTANTLY DEFLATED CAUSING TOTAL TIRE FAILURE BEFORE THE VEHICLE COULD BE PULLED TO SIDE OF ROAD. TIRE SIDEWALL WAS TOTALLY DESTROYED. SPARE INSTALLED. VISITED THE TIRE DEALERSHIP WHERE THE FOUR NEW REPLACEMENT TIRES WERE INSTALLED 2 YEARS, 5 MONTHS AND 23,911 MILES PRIOR. NO PUNCTURES, TEARS OR CUTS WERE FOUND ANYWHERE ON THE TIRE TREAD OR SIDEWALL. THE ONLY KNOWN CAUSE OF THE TIRE FAILURE WAS A CRACKED (CUT) VALVE STEM (AS DOCUMENTED BY DEALERSHIP) IN THE AREA WHERE THE STEM SEATS AGAINST THE ALUMINUM WHEEL ALLOWING AIR TO EXHAUST QUICKLY FROM THE TIRE ONCE THE CRACK PROPAGATED TO INSIDE. A NEW TIRE WAS INSTALLED ALONG WITH A NEW VALVE STEM. CRACKED VALVE STEM INFORMATION; TR 413, EHA GERMANY. THIS WAS THE SECOND TIME (WITHIN 900 MILES) THAT A TIRE BLOWOUT OCCURRED DUE TO WHAT APPEARS TO BE A BAD VALVE STEM. CRACKED VALVE STEM WAS SAVED FOR REFERENCE. *TR

TRAVELING AT APPROXIMATELY 65MPH WHEN LEFT FRONT TIRE NEAR INSTANTLY DEFLATED CAUSING TOTAL TIRE FAILURE BEFORE THE VEHICLE COULD BE PULLED TO SIDE OF ROAD. TIRE SIDEWALL WAS TOTALLY DESTROYED. SPARE INSTALLED. VISITED THE TIRE DEALERSHIP WHERE THE FOUR NEW REPLACEMENT TIRES WERE INSTALLED 2 YEARS, 4 MONTHS AND 23,032 MILES PRIOR. NO PUNCTURES, TEARS OR CUTS WERE FOUND ANYWHERE ON THE TIRE TREAD OR SIDEWALL. THE ONLY KNOWN CAUSE OF THE TIRE FAILURE WAS A CRACKED VALVE STEM IN THE AREA WHERE THE STEM SEATS AGAINST THE ALUMINUM WHEEL ALLOWING AIR TO EXHAUST QUICKLY FROM THE TIRE ONCE THE CRACK PROPAGATED TO INSIDE. A NEW TIRE WAS INSTALLED ALONG WITH A NEW VALVE STEM. CRACKED VALVE STEM INFORMATION; TR 413, EHA GERMANY. *TR

TL*THE CONTACT OWNS A 1994 MERCURY SABLE. THE CONTACT STATED THAT HER HEADLIGHTS WOULD FAIL INTERMITTENTLY AND THEN ILLUMINATE AGAIN. SHE NOTICED THAT THE FAILURE OCCURRED IN BRIEF INTERVALS AND SHE SMELLED A BURNING ODOR. THE DEALER INSTALLED A NEW HEADLIGHT SWITCH AND, CONSEQUENTLY, THE DASHBOARD SWITCH MELTED. THE DEALER STATED THAT NOTHING COULD BE DONE. FORD STATED THAT HER VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 98V009000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE FAILURE MILEAGE WAS APPROXIMATELY 98,000.

TL* - THE CONTACT HAS A 1994 MERCURY SABLE. THE CONTACT STATED THAT HE PURCHASED A VEHICLE ON THE AFTERNOON OF 03/16/2007, AND THE FOLLOWING MORNING 03/17/2007 THE VEHICLE WOULD NOT WORK, AND TRANSMISSION FLUID WAS POURING OUT OF THE VEHICLE. THE CONTACT STATED THAT HE COULD POUR IT IN THE TOP AND WATCH IT COME OUT OF THE BOTTOM. THE CONTACT WAS TOLD BY THE DEALER THAT THEY WOULD COME AND GET THE VEHICLE REPAIR IT AND CHARGE HIM FOR IT. THE CURRENT AND FAILURE MILEAGE WERE BOTH 131,368 MILES.

DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE ENGINE STALLS WITHOUT WARNING. THIS OCCURS MORE OFTEN IN WARMER WEATHER. THE VEHICLE RESTARTS ONLY AFTER COOLING OFF FOR AT LEAST 30 MINUTES. IT HAS BEEN INSPECTED ON SEVERAL OCCASIONS; HOWEVER THE PROBLEM COULD NOT BE DUPLICATED. AFTER RESEARCHING THE PROBLEMS WITH THIS VEHICLE THE CONTACT BELIEVES THE PFI IGNITION MODULE IS OVER HEATING, CAUSING THE STALLING.