1992 MERCURY TRACER Complaints

AFTER 27 YEARS THE RUBBER FUEL FILLER PIPE ON THE CAR CRACKED AND BEGAN LEAKING FUEL. THE FUEL FILLER PIPE WAS REPLACED WITH A NEW FUEL FILLER PIPE FROM FORD MOTORCRAFT, PART #KFL-22, FOCZ-9324-AA. THE NEW FUEL FILLER PIPE LASTED ONLY 6 MONTHS BEFORE CRACKING AND SPILLING GAS ON MY DRIVEWAY CREATING A HAZARDOUS SITUATION. THE CAR WAS REPAIRED WITH A NEW THIRD PARTY [NOT FORD] FUEL FILLER PIPE. I'M BRINGING THIS TO YOUR ATTENTION BECAUSE NUMEROUS AUTO REPAIR WEB SITES HAVE HUNDREDS OF COMPLAINTS REGARDING DEFECTIVE REPLACEMENT FORD FUEL FILLER PIPES [ALL FORD MODELS]. FUEL FILLER PIPES SHOULD LAST MORE THEN 6 MONTHS. FORD'S REPLACEMENT FUEL FILLER PIPES ARE DEFECTIVE AND SHOULD BE RECALLED FOR REPLACEMENT BY FORD TO PREVENT A VERY HAZARDOUS SITUATION SHOULD A VEHICLE BE PARKED IN A GARAGE, I.E., NEAR A WATER HEATER OR OTHER IGNITION SOURCE, CREATING A LIFE-THREATENING SITUATION. THE LEAK FROM THE FUEL FILLER PIPE OCCURS WHETHER OR NOT THE VEHICLE IS PARKED OR MOVING WHEN THE FUEL TANK IS MORE THEN 3/4'S FULL. THE PIPE DETERIORATES FROM THE OUTSIDE WITH CRACKS RUNNING THE LENGTH OF THE PIPE. THE NYLON WEBBING ON THE INSIDE OF THE PIPE DOES NOT PREVENT IT FROM LEAKING. THE ATTACHED PHOTO SHOWS THE DEFECTIVE PIPE, BUT THE HUNDREDS OF HAIRLINE CRACKS IN THE PIPE CANNOT BE SEEN IN THE PHOTO BECAUSE OF PHOTO RESOLUTION. THE PIPE HAS ONLY BEEN IN USE ON THE CAR FOR JUST SIX MONTHS. I USE 91 OCTANE GASOLINE IN THE CAR. *TR

ON MY DAUGHTERS 1992 MERCURY TRACER, THE IGNITION SWITCH ENGAGED THE ENGINE STARTER AND BEGAN SMOKING WITHOUT THE KEY IN THE IGNITION AND WHEN NO-ONE WAS IN THE CAR. I AM NOW FACED WITH $800.00 IN REPAIR BILLS FOR A DEFECTIVE FORD MOTOR COMPANY PART THAT COULD HAVE CAUSED A SERIOUS INJURY OR DEATH. *LA

TREAD SEPARATION DISCOVERED ACCIDENTALLY PER INSPECTION FOR DRIVEABIITY CONCERN. *AK (DOT NUMBER: W2R4 TIRESIZE: P195/60R14)

THE SHOULDER HARNESS PULLED FROM TRACK ON IMPACT , THE DRIVER'S HEAD STRUCK THE WINDSHEILD AND RECEVIED CONTUSIONS TO NECK AND HEAD FROM THE LOOSE END OF THE HARNESS

STARTER SHORTED OUT, CAUSING A FIRE IN THE ENGINE COMPARTMENT. DEALER HAS NOT BEEN CONTACTED. *AK

EXHAUST VALVE BROKE EVERY YEAR, CAUSING REAR END TO OVERHEAT AND BURN THE TRUNK. PLEASE PROVIDE FURTHER INFORMATION. *AK

TRANSMISSION FAILED TO ENGAGE INTO APPROPIATE GEAR AND "SLIPPED" INTO NEUTRAL ALMOST CAUSING AN ACCIDENT.

THERE WAS A GAS SMELL AROUND THE CAR AND IN THE GARAGE, DEALER CONTACTED AND STATED A HOLE FOUND IN THE GAS TANK. REPAIR WORK DONE AT CONSUMER'S EXPENSE. *AK

INTERMITTENTLY WHILE DRIVING THE ELECTRIC SHOULDER STRAP MOVES UP AND DOWN CONSTANTLY . ALSO GETS STUCK AND RELEASES AND REPAIRS ISELF. NOW, SHOULDER STRAP MAKES WEIRD NOISES AND IS STUCK IN THE MIDDLE. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK

SEAT BELT HARNESS DOES NOT SLIDE ON TRACK. LEFT FRONT IS FROZEN 1/2 WAY IN POSITION. *AK