2002 MINI COOPER Complaints

2002 MINI COOPER, POWER STEERING PUMP SHORTED OUT CAUSING A SMALL FIRE WHICH DESTROYED THE PUMP,FAN,WIRING HARNESS,POWER STEERING LINE. CAR HAD LESS THAN 50,000 MILES ON IT. COST OF REPAIR OVER 1200 DOLLARS. *TR

2002 MINI COOPER. POWER STEERING QUIT (MY WIFE DRIVING AND BY HERSELF) IN A TURN WITH ONCOMING TRAFFIC. NO INJURIES BUT VERY CLOSE. *TR

TL*THE CONTACT OWNS A 2002 MINI COOPER. THE VEHICLE SHUT OFF WHILE DRIVING APPROXIMATELY 25 MPH. THERE WERE NO WARNINGS PRIOR TO THE TRANSMISSION FAILURE. THE CONTACT FEELS THAT THIS IS A SERIOUS SAFETY ISSUE BECAUSE A CRASH COULD HAVE OCCURRED. THE FAILURE MILEAGE WAS 63,000.

I HAVE A 2002 MINI COOPER, I PURCHASED NEW. I HAVE HAD AN ONGOING PROBLEM SINCE IT WAS UNDER WARRANTY. MY AIR BAG WARNING LIGHT COMES ON. I HAVE HAD IT BACK TO THE DEALER AT LEAST 20+ TIMES FOR THE SAME PROBLEM. THEY STILL CAN NOT SEEM TO GET A PERMANENT FIX FOR THIS(NEXT APPOINTMENT JULY 9, 2009). *TR

I DROVE MY 2002 MINI COOPER APPROXIMATELY 6 MILES TO DROP OFF A FRIEND WHO WAS VISITING FROM OUT OF TOWN. I WAS HELPING MY FRIEND REMOVE HIS SUITCASE AND STANDING TO THE PASSENGER SIDE REAR OF THE CAR WHEN MY LEG MADE CONTACT WITH THE TAILPIPE CAUSING ABOUT A 2 INCH CRESCENT SHAPED BURN. THE TAILPIPE WAS HOT ENOUGH THAT MY SKIN STUCK TO THE PIPE - IT IS A PRETTY NASTY SECOND DEGREE BURN. *TR

2002 MINI COOPER POWER STEERING HYDRAULIC ASSIST FAILS WITHOUT WARNING MAKING CAR DIFFICULT TO STEER. FAILURE IS INTERMITTENT AND MAY OCCUR ON THE HIGHWAY OR ON SURFACE ROADS. IN EITHER CASE THERE IS ABSOLUTELY NO WARNING. *TR

TRANSMISSION WHINING NOISE EVENTUALLY LEADING TO TRANSMISSION FAILURE. MINI IS AWARE OF THIS PROBLEM WITH CVT TRANSMISSIONS AND REFUSES TO ADMIT FAULT. VERY COMMON PROBLEM OCCURRING IN MOST 2002 VEHICLES WITH ONLY 40,000-60,000 MILES ON THEM. COST IS 7000 TO REPLACE. MINI DOES NOT OFFER REPAIR ON THIS PART. *TR

TRANSMISSION BEARINGS FAILURE AFTER 82,000 MILES. NO BEARINGS KIT REPLACEMENT OFFERED. *TR

DRIVER'S SIDE AUTOMATIC WINDOW DOES NOT WORK; WILL BE REPLACING WINDOW MOTOR. *TR

PURCHASED A USED 2002 MINI COOPER ABOUT 3 1/2 YRS AGO W/ ABOUT 12K MILES. AT AROUND 15-17K MILES THE TRANSMISSION BASICALLY EXPLODED WHILE I WAS ON THE HIGHWAY. I WAS TOLD THAT THERE WAS A CRACK IN THE TRANSMISSION. MINI REPLACED IT WITH I'M GUESSING A REBUILT TRANSMISSION. AT THE TIME OF THE REPAIR I ASKED THEM IF THEY WERE PUTTING IN A NEW CLUTCH AND THEY SAID NO, WHICH I FOUND STRANGE. NOW AT 60K MILES THE CLUTCH IS BASICALLY DONE. WHEN THE CAR IS COLD IT SHIFTS PRETTY NORMALLY, BUT AFTER 15-25 MINUTES OF DRIVING THE FIRST TWO GEARS BECOME HARD TO ENGAGE AND THEY SLIP. THIS IS NOT MY FIRST FIVE SPEED AND I'M SHOCKED THAT THIS CLUTCH IS DONE AFTER SUCH LITTLE MILEAGE. SHOULD THEY HAVE REPLACED THE CLUTCH WHEN THEY REPLACED THE TRANSMISSION? I'M NOT A MECHANIC BUT TO LOSE A CLUTCH AT 60K MILES DOESN'T MAKE ANY SENSE. MY DRIVING HABITS ARE PRETTY NORMAL. I'M NOT LIGHTING UP THE TIRES AT TRAFFIC LIGHTS OR RACING PEOPLE. THIS IS AN EVERYDAY CAR MOSTLY USED ON THE HIGHWAY. I'M BRINGING THE CAR IN TO HAVE IT LOOKED AT THE MINI SERVICE CENTER IN FREEPORT NY ON 12/29/08. ALSO HAD A PROBLEM WITH OVERHEATING ABOUT 4 MONTHS AFTER CAR WAS PURCHASED. AND AIR BAG LIGHT STAYS LIT. HAVE HAD THIS PROBLEM CORRECTED ONCE OR TWICE. BUT THE LIGHT STILL STAYS LIT. *TR