2011 MINI COOPER Complaints

2011 MINI COUNTRYMAN S ALL4 MANUAL TRANSMISSION AFTER REPEATED INCIDENTS OF THE CLUTCH "SMOKING" UNDER HEAVY USE, AND REPORTING SAID INCIDENTS TO THE DEALER, AND HAVING THE DEALER INSPECT THE CAR AND CLAIM ALL WAS FINE, THE CLUTCH FINALLY WORE DOWN SUFFICIENTLY AND REQUIRED REPLACEMENT AT ONLY 4965 MILES. WE ARE VERY EXPERIENCED DRIVERS OF MANUAL TRANSMISSIONS AND DID NOT ABUSE THE CLUTCH IN ANY WAY. MINI USA COMPLETED THE REPAIR UNDER WARRANTY AS A GOODWILL MEASURE. THERE ARE NUMEROUS ACCOUNTS OF PREMATURE CLUTCH WEAR/FAILURE ON MINI ENTHUSIAST WEB SITES AND EVEN NATIONAL AUTOMOBILE PUBLICATIONS EXPERIENCED SAME (AUTOMOBILE MAGAZINE'S LONG TERM TEST CAR HAD CLUTCH FAILURE AT 15K MILES). *TT

TL* THE CONTACT OWNS A 2011 MINI COOPER COUNTRYMAN. THE CONTACT STATED THAT SHE PLACED A CUP IN THE CUP HOLDER AND SOMETHING PUNCTURED A HOLE IN THE CUP, CAUSING LIQUID TO LEAK. A FEW DAYS LATER, THE VEHICLE WOULD NOT SHIFT OUT OF PARK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT THEY NEEDED TO REPLACE THE SHIFT ASSEMBLY. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGE WAS 7,000.

TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT WHILE ATTEMPTING TO REVERSE FROM A RESIDENTIAL GARAGE, BLACK SMOKE EMITTED FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO PUT THE FIRE OUT UNDER THE HOOD WITH A GARDEN HOSE. THE FIRE DEPARTMENT WAS NOT CONTACTED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 3,000.

AS I WAS ACCELERATING WHILE MERGING ONTO A HIGHWAY, AT APPROXIMATELY 55-60 MPH, IT FELT AS IF THE CAR LOST ALL POWER FROM THE DRIVE TRAIN. THE POWER REENGAGED ABOUT A SECOND LATER, AND OVER THE NEXT 5-10 SECONDS THE CAR LOST POWER/REENGAGED TWO MORE TIMES. NO WARNING LIGHTS WERE TRIGGERED ON THE DASH. I'VE TAKEN THE CAR INTO DEALERSHIP AND REFERENCED SERVICE BULLETIN NUMBER SIM12-02-11/NHTSA ITEM NUMBER 10040855. DEALER REPORTS THAT BECAUSE IT CANNOT REPLICATE THE ISSUE AND THERE ARE NO REPORTED FAULT CODES, IT APPEARS THAT THERE IS NOTHING WRONG WITH MY CAR, THEREFORE IT CANNOT CONFIRM IF I'M ON MOST RECENT SOFTWARE OR PERFORM SOFTWARE UPDATE TO FIX ERROR REFERENCED IN THE SERVICE BULLETIN. *TR

TL* THE CONTACT OWNS A 2011 MINI COOPER CONVERTIBLE. THE CONTACT STATED THAT THE FRONT DRIVER SIDE DOOR WOULD NOT UNLOCK WHEN USING THE KEY FOB. IN ORDER TO ENTER THE VEHICLE, THE CONTACT HAD TO USE THE FRONT PASSENGER DOOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT NO FAILURE WAS PRESENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 19,000.

ON 12/2/11 THERMOSTAT HOUSING SENSOR FAILED AND REPLACE ON 1/18/12 SECOND ONE FAILED. ON 2/27/12 NOTICED OIL LEAK. INFORMED THAT THE SOLENOID LEAKING TO ENGINE IS CURRENTLY BEING REPLACED. *TR

I TOOK THE CAR TO THE DEALER ON 12/15/11 BECAUSE THE PASSANGER AIRBAG OFF LIGHT TURNED ON WHEN A PASSANGER WAS SEATED. THE LIGHT TURNED ON AGAIN JAN 7, 2012. HERE ARE THE DEALER'S NOTES FROM THE 12/15/11 VISIT: SEAT MAT SENSOR OC3 RECODING CHECK FAULT MEMORY NO RELEATING FAULT STORED. COMPLETED TEST PLAN B6577 ACM4. CHECK CONNECTOR TO SENSOR OK. TEST PLAN CONCUDED TO RECODE OC3. UPDATED VEHICLE. D6577 0000 57 310. RETEST OK. AT THE SAME TIME THE CAR ALSO ALERTED TO A TIRE INFLATION ISSUE. HERE ARE THE DEALER'S NOTES REGARDING THIS ISSUE (ALSO 12/15/11): PSI: TIRE INFLATION CHECK SET TIRES TO 33PSI *TT

TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT THE GEAR LINK BECAME STUCK AS THE CONTACT WAS ATTEMPTING TO REVERSE FROM A DRIVEWAY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS ADVISED THAT COFFEE HAD LEAKED INTO THE GEAR SHIFTER AND CAUSED THE FAILURE. THE DEALER STATED ADVISED THAT BECAUSE THE CUP HOLDER WAS ABOVE THE GEAR SHIFTER, THE DESIGN WOULD ALLOW ANY SPILLED LIQUID TO EASILY ENTER THE SHIFTER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 5,000. UPDATED 03/23/12*LJ THE CONSUMER STATED THE COFFEE HOLDER SITS RIGHT OVER THE AREA WHERE THE DEALER SATED COFFEE RUINED THE TRANSMISSION COMPONENT. IT IS NOT SEALED AND THE PLACEMENT OF A LIQUID HOLDER OVER A VULNERABLE EXPENSIVE PIECE OF ELECTRICAL EQUIPMENT WITHOUT ADEQUATE PROTECTION IS A NEGLIGENT DESIGN. UPDATED EVOQ 04/18/12

I PARKED MY MINI CLUBMAN S AND WENT INSIDE A FAST FOOD RESTAURANT FOR ONLY 10 MINUTES, WHEN I RETURNED TO MY MINI, I WAS SHOCKED TO SEE SMOKE COMING FROM UNDER THE HOOD. I RELEASED THE HOOD LATCH AND TRIED WITHOUT SUCCESS TO OPEN THE HOOD. A NEARBY WITNESS CALLED OUT TO ME AS HE RAN TO ASSIST WITH AN EXTINGUISHER REALIZING MY CAR WAS ON FIRE. I IMMEDIATELY CALLED 911 AND STOOD HELPLESSLY WATCHING AS MY 4-MONTH OLD CAR WAS ENGULFED IN FLAMES WITHIN MINUTES. THERE WERE NO PREVIOUS WARNINGS DISPLAYED...IF MY DOG, WHO TRAVELS WITH ME QUITE OFTEN HAD BEEN IN THE CAR AS I WENT INSIDE, I CANNOT IMAGINE HOW I WOULD BE FEELING RIGHT NOW...LOSING THE CAR WAS DIFFICULT, AND NOW, I REALIZE HOW FORTUNATE I WAS NOT TO LOSE MORE, CONSIDERING THE FACT I PARKED THE MINI IN MY GARAGE EVERY NIGHT AS I RETURNED HOME FROM WORK. THE FIRE IS CURRENTLY UNDER INVESTIGATION, SO I CANNOT NAME THE FAILED COMPONENTS AS REQUESTED ABOVE, BUT I WILL UPDATE THIS INFORMATION ONCE THE INVESTIGATION IS COMPLETE. *TR

I WAS DRIVING ABOUT 25MPH WHEN I SAW SMOKE COMING FROM UNDER THE HOOD. I PULLED OVER AND POPPED THE HOOD AND FOUND FLAMES IN THE ENGINE BAY. I DIDN'T HAVE AN EXTINGUISHER IN THE CAR AND THERE WASN'T A HOSE IN SIGHT, SO IT BURNED FOR A FEW MINS BEFORE A BYSTANDER STOPPED AND GAVE ME AN EXTINGUISHER. THE FIRE DEPARTMENT CAME SHORTLY AFTER AND DOUSED THE STILL SMOLDERING ENGINE COMPARTMENT WITH WATER. THERE WERE NO WARNING LIGHTS ON IN THE DASHBOARD BEFORE, DURING OR AFTER THIS FIRE. MY COUNTRYMAN, BUILT IN APRIL 2011 AND PURCHASED IN MAY, HAS ABOUT 5700 MILES ON IT AND HAS OTHERWISE HAD NO PROBLEMS. MY RESEARCH ONLINE INDICATES THAT OTHER MINI MODELS (COOPER S, CLUBMAN) HAVE HAD SIMILAR PROBLEMS, AND THAT THE NHTSA IS INVESTIGATING SOME OF THESE. PLEASE CONSIDER ADDING THE COUNTRYMAN TO YOUR INVESTIGATION OF MINI SPONTANEOUS ENGINE FIRES. *TR