2002 MINI COOPER Complaints

DT: CALLER BURNED VERY BADLY HER LEG BECAUSE THE TAIL PIPE STUCK OUT TOO FAR. TAIL PIPE DID NOT HAVE A GUARD OVER IT. THEY WERE LOCATED IN THE MIDDLE OF THE VEHICLE IN THE BACK INSTEAD ON THE SIDE OF THE BACK. DEALER SAID TO CALL MANUFACTURER, AND THE MANUFACTURER WAS NOT VERY NICE . MANUFACTURER SAID THERE WAS NOTHING WRONG WITH THE VEHICLE. CALLER SHOWED A REPRESENTATIVE THE PROBLEM AND HE WANTED HER TO TELL THEM HOW TO FIX IT. THEY TOLD CALLER TO LEAVE GROCERIES IN THE VEHICLE UNTIL IT COOLED OFF.*AK

DT: THE CONTACT OWNED A 2002 BMW MINI COOPER S. THE CONTACT COMPLAINED STEERING FAILURE. THE STEERING WAS NOT OPERATING. . COULD DRIVE BUT COULD NOT STEER BECAUSE THERE WAS NO POWER STEERING. THE STEERING SYSTEM WAS BROKE A COUPLE OF MONTHS AGO , AND THEY REPAIRED IT. CURRENTLY, THE DEALERSHIP WILL NOT REPAIR CAR ANYMORE EVEN THOUGH IT WAS UNDER WARRANTY. THE STEERING BECAME VERY HEAVY, HAD TO MUSCLE THE STEERING IN ORDER TO TURN THE CAR. WHILE DRIVING ON THE HIGHWAY ALL OF A SUDDEN COULD NOT STEER THE CAR, AND IT WAS VERY DANGEROUS. DID HAVE ONE STEERING FAILURE BEFORE, AND HAD TO REPLACE THE ENTIRE STEERING MECHANISM. CURRENTLY, HE COULD NOT STEER UNDER NORMAL ROAD CONDITIONS. *AK

2002 MINI COOPER S HAS HAD A SECOND AIRBAG SYSTEM FAILURE. WHEN ELECTRONICS ASSOCIATED WITH THE AIRBAG SYSTEM DETECT A FAILURE, THE AIRBAG SYSTEM IS DISABLED UNTIL TAKEN TO THE DEALER TO HAVE FIXED. LOOKING UNDER THE SEATS TO SEE WHAT THE ISSUE COULD BE, DISCOVERED THE "FIX" PERFORMED BY THE DEALER TO FIX THE PROBLEM THE FIRST TIME THE PROBLEM OCCURRED. THE INTIAL FIX WAS TO COMPRESS THE PLUG TOGETHER WITH "WIRETIES" - NOT TO REPLACE THE PLUGS WITH A BETTER DESIGN. BOTH THE WORKMANSHIP OF THE REPAIR OF THE AIRBAG SYSTEM AND THE SYSTEM ITSELF ARE FAULTY.

DT: THE CONTACT NOTICED THAT IF USING THE REMOTE TO LOCK THE DOORS AND IF ANYONE WAS INSIDE THE VEHICLE THEY WERE UNABLE TO GET OUT OF THE VEHICLE. THE HANDLES NOR THE DOOR LOCK WILL UNLOCK THE DOOR. CONSUMER HAS TO USE THE REMOTE. THE CONTACT FELT THAT THIS WAS SOME TYPE OF COMPUTER DEFECT. HE TOOK THE VEHICLE TO THE DEALER AND DEMONSTRATED TO THEM THE PROBLEM, AND THEY AGREED WITH THE CONSUMER THAT THIS WAS A SAFETY DEFECT. DEALERSHIP CONTACTED THE MANUFACTURER, AND THEY SAID THAT THERE WAS NOTHING THEY COULD DO ABOUT THIS WAS JUST THE WAY THE CAR WAS MANUFACTURED. *AK *TT *SC *JB

8" CRACK IN FRONT WINDSHIELD. CRACK IS LOCATED ON LOWER RIGHT HAND (PASSENGER) SIDE OF VEHICLE THAT STARTS BELOW THE WINDSHIELD SEAL. THE GOES UP 3" THEN CURVES LEFT AND TRAVELS FOR 5". CRACK APPEARED AFTER THE CAR WAS PARKED IN A SECURE GARAGE FOR 3 DAYS, AND HAS GROWN ABOUT 1" A WEEK.

THE AIR BAG SYSTEM WARNING LIGHT HAS BEEN ON 8 TIMES IN 3 YEARS OF OWNERSHIP. (THE INCIDENT DATE I REPORT BELOW IS SIMPLY THE MOST RECENT OCCURENCE) EACH TIME REQUIRES A TRIP TO THE DEALER TO RESET THE SYSTEM. WHEN THE WARNING LIGHT IS ON THE VEHICLE'S AIRBAG SYSTEM IS DE-CTIVATED, AND THEREFORE THE SYSTEM RESET IS AN URGENT SAFETY ISSUE. OVER THE COURSE OF 3 YEARS, THE DEALER HAS REPLACED NUMEROUS SENSORS, WIRING HARNESS PIECES, AND SEVERAL OF THE AIRBAG UNITS (ESP. THE SEAT AIRBAGS). THIS IS REPORTED TO BE ONE OF THE MOST COMMON MINI COOPER FAILURES AND HAS PLAGUED THESE CARS FOR ALL MODEL YEARS IN PRODUCTION. THIS IS AN URGENT SAFETY DEFECT AND IT IS IMPORTANT THAT THE NHSTA TAKE ACTION! (SORRY I DON'T KNOW MY VIN BY MEMORY AND CAN'T ACCESS MY REGISTRATION AT THE MOMENT...IF YOU REALLY NEED THIS, SIMPLY EMAIL ME AND I'LL GLADLY PROVIDE). *AK

2002 MINI COOPER [XXX]. CAR HAS BEEN TO THE DEALER AT LEAST FOUR TIMES TO ADDRESS THE AIR BAG LIGHT BEING LIT, IN 44,000 MILES. VARIOUS HARNESSES HAVE BEEN REPLACED THREE TIMES AND THE AIR BAG SENSOR ONCE. NOW, AT 44,500 MILES, THE AIR BAG LIGHT IS ON AGAIN FOR A FIFTH TIME. I'VE BEEN TOLD BY THE DEALER THE AIR BAGS WILL NOT FUNCTION WITH THE LIGHT LIT. I SUGGEST THAT MINIUSA BE FORCED TO ISSUE A RECALL ON THIS VEHICLE TO CORRECT THE PROBLEM ONCE AND FOR ALL AS IT IS A MAJOR SAFETY CONCERN WHICH THEY DO NOT APPEAR TO HAVE FULLY ISOLATED.*AK *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

WENT OUT TO DINNER WITH MY PARENTS - GONE APPROXIMATELY 2 HOURS - CAME BACK TO FIND THE CAR COMPLETELY BURNED. FIRE DEPARTMENT WAS CALLED BY A NEIGHBOR. THERE WAS NO INDICATION AT ALL THAT THERE WAS ANYTHING WRONG WHEN WE PARKED THE CAR. HAVE FOUND OTHER CASES (VIA THE INTERNET) IN THE UK THAT THIS HAS HAPPENED. *JB

AIR BAG FAILURE LIGHT. 2ND TIME IN 2 YEARS. WIRING HARNESS CONNECTOR SEPARATED WHEN THE DRIVER SIDE SEAT MOVES ALL THE WAY BACKWARD. DEALER INSTALLED LONGER HARNESS.

WHILE DRIVING ON THE HIGHWAY BETWEEN 50-55 MPH, PUT VEHICLE IN NEUTRAL GEAR TO COAST BEFORE SLOWING DOWN, WENT TO GEAR DOWN , AND VEHICLE WILL BRAKE BUT NOT CHANGE GEARS. THIS COULD RESULT IN AN ACCIDENT. THIS FAILURE OCCURRED DUE TO THE DEFECT DESCRIBED IN RECALL 02V201000 CONCERNING TRANSMISSION SHIFT CABLE. BUT, THE CONSUMER WASN'T INFORMED NOR NOTIFIED OF THE RECALL UNTIL RECENTLY.*AK