2002 MINI COOPER Complaints

WINDSHIELD CRACKED FROM THE LOWER DRIVER'S SIDE AFTER TURNING THE HEATER ON WHILE VEHICLE WAS WARMING UP PARKED ON THE DRIVEWAY. DEALER REFUSED TO REPLACE IT UNDER WARRANTY. *LA

AIR BAG WARNING LIGHT CAME ON AND STAYED ON, WHICH INDICATED THAT AIR BAGS WERE INOPERATIVE. DEALERSHIP SERVICED THE VEHICLE, BUT THE PROBLEM RECURRED WITHIN 2000 MILES.*AK

-STALLING WHEN CHANGING FROM REVERSE TO DRIVE. HAS ALSO STALLED ONCE ON THE INTERSTATE. -RPM'S KEEP REVVING BETWEEN 3000 & 5000 WHEN I HIT 55-60 MPH. ONCE I PASS 60 MPH THE RPM'S DECREASE TO A REASONABLE LEVEL. THIS HAPPENS EVERYDAY WITHOUT FAIL. *LA

LARGE CRACK OCCURED IN THE WINDSHIELD. DEALER CLAIMED IT WAS CAUSED BY A STONE, AND NOT COVERED, AND INHERENT WITH THE DESIGN OF THE CAR (A MORE UPRIGHT WINDSHIELD THAN MANY OTHER CARS). I HAVE HEARD OF NUMEROUS SIMILAR HAPPENINGS.

WINDSHIELDS ARE FAILING ALL OVER THE COUNTRY ON MINI COOPER AUTOMOBILES. I AM CURRENTLY ON MY 3RD WINDSHIELD IN AS MANY MONTHS - STRESS CRACKS APPEARED FROM THE ROOF PILLARS IN BOTH CASES. WE NEED A RESOLUTION TO THIS - EITHER BETTER GLASS OR STRUCTURAL IMPROVEMENTS.*AK

INTERMITTENT COMPLETE LOSS OF POWER FOR 2-3 SECONDS WHEN STARTING FROM STANDSTILL.OCCURS UNDER VARIOUS CLIMATIC CONDITIONS AND EITHER WITH COLD OR WARM ENGINE.EXTREMELY DANGEROUS WHEN MERGING INTO TRAFFIC FROM A SIDE STREET OR INTERSECTION.*AK

MY 2002 MINI COOPER S HAS SOME ENGINE MANAGEMENT ISSUES THAT HAVE RESULTED IN SEVERAL CLOSE CALLS IN TRAFFIC SITUATIONS THAT I FEEL ARE UNSAFE, AND HAVE YET TO BE RESOLVED OR DEFINITELY ADDRESSED BY THE MANUFACTURER. THE MOST SEVERE ISSUE IS A TOTAL LOSS OF ENGINE POWER AFTER ACCELERATION ON CLEAN DRY PAVEMENT. LOSS OF POWER IS USUALLY IN 1ST GEAR AN CAN LAST SEVERAL SECONDS. I BELEIVE THIS TO BE A PROBLEM NOT UNIQUE TO MY VEHICLE.*AK

THERE IS A COMPLETE POWER FAILURE AT VARIOUS SPEEDS INCLUDING 55 MPH. THIS DEFECT OR CONDITION CAN RESULT IN SERIOUS INJURY OR DEATH. WHEN IT HAPPENED ON RT. 66 IN ARLINGTON VA AT 9:30 PM, IT CAUSED A NEAR-COLLISION WITH SEVERAL OTHER VEHICLES TRAVELING ON THE ROAD. THERE WAS NO WARNING LIGHT, NOISE, OR OTHER INDICATION THAT THE ENGINE WAS ABOUT TO TURN OFF.*AK

WINDSHIELD CREAKING, CRACKLING. REPLACED TWICE BY DEALER DUE TO WIND LEAKAGE. WINDSHIELD IS TOO THIN AND PITS WAY TOO EASILY. WIFE IS AFRAID OF SAFETY BECAUSE OF THE NOTORIOUSLY HIGH INCIDENCE OF SPONTANEOUS CRACKING WINDSHIELDS. MINI USA CONTINUES TO DENY ANY PROBLEMS, BUT INFORMAL SURVEYS OF DEALERS INDICATE THOUSANDS OF REPLACEMENTS ALREADY, AND THE CAR HAS ONLY BEEN ON SALE FOR 16 MONTHS. GLASS IS TOO THIN AND BRITTLE. GOVERNMENT NEEDS TO INTERCEDE AND FORCE MINI USA TO REPLACE WITH THICKER, SAFE WINDSHIELDS.*AK

WHILE DRIVING THE SIDE AIR BAGS DEPLOYED. THE VEHICLE WAS TOWED TO THE DEALERSHIP. BMW OF NORTH AMERICA REPURCHASED THE VEHICLE. *AK *CB *NLM