2006 MINI COOPER Complaints

CAR LOST POWER AND STARTED RUNNING AND IDLING VERY ROUGH. SERVICE SHOP DISCOVERED THAT THE NYLON CAPS FOR THE HYDRAULIC LASH VALVES HAD DETERIORATED AND CRACKED AND IN SOME CASES HAD FALLEN COMPLETELY OFF HAVING A NEGATIVE AFFECT ON THE ENGINE COMPRESSION. THE ORIGINAL CAPS ARE BRIGHT YELLOW AND AFTER USE AND HEAT THEY TURN ORANGE/BROWN. INTERNET RESEARCH SHOWS SOME MINI'S HAVE STEEL LASH CAPS. SEEMS THAT A ENGINE COMPONENT SUSCEPTIBLE TO HEAT DAMAGE SHOULD NOT BE MADE OF NYLON/PLASTIC. THE CAR HAS A TOTAL OF 18 OF THESE LASH CAPS AND AT LEAST 12 ARE CLEARLY CRACKED. THERE ARE CURRENTLY NO REPLACEMENT PARTS AVAILABLE FROM MINI OR IN THE AFTERMARKET. MINI'S ONLY SOLUTION IS TO REPLACE THE ENTIRE ROCKER ARMS WHICH IS A VERY COSTLY REPAIR WHEN THE ONLY FAILURE IS SMALL NYLON CAPS. *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING APPROXIMATELY 45 MPH, THE RPM READINGS INCREASED AS THE VEHICLE JERKED FORWARD ABNORMALLY. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

DRIVING ON THE FREEWAY WHEN I FELT THE CAR JERK FORWARD AND THEN IT FELT AS IF THE AUTOMATIC TRANSMISSION WAS SLIPPING IN AND OUT OF GEARS. MANAGED TO PULL OFF THE FREEWAY AND DRIVE TO THE LOCAL MINI DEALERSHIP, WHICH WAS LUCKILY ABOUT A MILE DOWN THE ROAD. WAS TOLD BY DEALERSHIP THE PROBLEM WAS TRANSMISSION FAILURE AND WAS QUOTED $9,000 REPAIR COST. WHEN I ASKED THE MECHANIC WHY THE TRANSMISSION HAD FAILED THIS EARLY, TOLD ME THEY HAD NO IDEA. HOWEVER, WHEN I ASKED ANOTHER EMPLOYEE HOW MANY OTHER CARS HAD THEY SEEN WITH TRANSMISSION PROBLEMS, HE RELUCTANTLY ADMITTED "QUITE A FEW". *TR

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE POWER STEERING FAILED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT WAS EXITING THE HIGHWAY WHEN THE POWER STEERING FAILED AND CAUSED AND INCREASE IN STEERING EFFORTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION WHERE THEY ADVISED THE CONTACT THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE AND THAT THEY WERE AWARE OF THE FAILURE THAT EXISTED WITH THE STEERING. THE FAILURE MILEAGE WAS 100,000.

2006 MINI CVT TRANSMISSION MADE A WEIRD NOISES AND STOPPED MOVING, JUST PRIOR TO THIS THERE WAS HESITATION IN ACCELERATION AND VERY LOUD NOISE FROM THE TRANSMISSION. *TR

WAS DRIVING ON HIGHWAY AT APP. 60 MPH, DOWNSHIFTED TO PASS AND EML LIGHT CAME ON AND POWER TO CAR WAS GREATLY REDUCED. FOUND OUT IT WAS A BROKEN CRANKSHAFT VIBRATION DAMPENER. NOTIFIED DEALER AND WAS TOLD THAT THERE WAS NO WARRANTY OR RECALL ON THIS ISSUE. QUITE EXPENSIVE TO REPAIR ALSO. CONTACTED MINI OF USA AND WAS TOLD THAT IT HAD TO BE DIAGNOSED BY A MINI DEALER FOR ANY POSSIBLE ASSISTANCE, BUT WAS NOT GUARANTEED THAT ASSISTANCE WOULD BE PROVIDED. *TR

THE PASSENGER SEAT OCCUPANCY SENSOR IS WEAK AND PRONE TO FAILURE. MINI DOES NOT COVER REPLACEMENT AND CHARGES $1200-$2000 TO REPLACE THE PART LEADING MANY OWNERS, INCLUDING MYSELF TO DRIVE THE CAR IN AN UNSAFE CONDITION (LOW SPEED OR NON DEPLOYING AIRBAGS). *TR

THE PASSENGER AIRBAG WARNING LIGHT INDICATES THERE IS A PROBLEM WITH THE PASSENGER AIRBAG SYSTEM. THE LIGHT ILLUMINATES CONTINUOUSLY WHETHER A PASSENGER IS IN THE SEAT OR NOT INDICATING THAT THE AIRBAG IS TURNED OFF FOR THE PASSENGER. MINI COOPER DENIES ANY PROBLEM WITH THEIR SAFETY AIRBAG SYSTEM, YET THERE ARE MANY PEOPLE COMPLAINING ABOUT HAVING THE SAME ISSUES. THE PROBLEM OCCURRED SHORTLY AFTER THE WARRANTY RAN OUT. *TR

LOUD AND PERSISTENT WHINNING NOISE FROM POWER STEERING PUMP, INTERMITTENT POWER STEERING FAILURE. HAD PAST PROBLEMS WITH THE POWER STEERING FAN (JUNE 2011). *TR

I WAS SLOWING DOWN TO MAKE A LEFT HAND TURN AND ALL OF THE SUDDEN THE POWER STEERING WENT OUT ON IT. BEING A FRONT WHEEL DRIVE CAR MADE IT EXTREMELY DIFFICULT TO TURN. HAD SOMEONE WITH LESS ARM STRENGTH BEEN IN THE DRIVER'S SEAT THEY COULD HAVE HIT ONCOMING TRAFFIC HEAD ON AND KILLED SOMEONE. *TR