2005 MINI COOPER Complaints

THE OCCUPANCY SENSOR HAS FAILED. THIS CAUSES THE AIRBAGS TO BE UNARMED WHILE THE VEHICLE IS IN USE. I HAVE CONTACTED MINI ABOUT THE PROBLEM. THEY COVERED THE REPAIR ON CERTAIN VEHICLES, BUT NOT MINE. THIS IS A SAFETY ISSUE, AND IT SHOULD BE COVERED ON ALL VEHICLES THAT IT HAS OCCURRED ON, REGARDLESS OF MILEAGE. THE REPAIR IS VERY EXPENSIVE, AND SHOULD BE COVERED. *TR

RIGHT INSIDE DOOR RELEASE FAILED SO THAT PASSENGER COULD NOT OPEN DOOR FROM INSIDE. PASSENGER WOULD BE TRAPPED INSIDE VEHICLE IN AN EMERGENCY. MINI DEALER REPAIRED BY REPLACING ROTARY LATCH LOCK AT COST OF $447. *TR

ELECTRIC POWER STEERING PUMP FAILED WHILE DRIVING, MAKING THE CAR UNDRIVEABLE. *TR

POWER STEERING PUMP STARTED WORKING INTERMITTENTLY, THEN FAILED. CONTACTED LOCAL MINI DEALER (MIDWESTERN AUTO GROUP), WHO ADVISED THAT I BRING IT IN TO "CONFIRM" AT THE DIAGNOSTIC COST OF $140. WHEN I INQUIRED AS TO WHY I SHOULD PAY A DIAGNOSTIC FEE WHEN I HAD I IDENTIFIED THE PROBLEM, MAG SERVICE MANAGER STATED AT THAT TIME THAT A FULL/PARTIAL REPAIR BY MINI USA WAS "HIGHLY LIKELY" IF I BROUGHT THE VEHICLE IN FOR DEALER SERVICE AND PAID THE FEE. AFTER NEARLY A MONTH OF BACK-AND-FORTH BETWEEN MINI USA, MAG, AND MYSELF NEITHER MINI USA NOR MAG WOULD OFFER ANY REPAIR ASSISTANCE. NEITHER MINI USA NOR MAG WOULD ACKNOWLEDGE THE NHTSA INVESTIGATION, THE RECALL IN CANADA, OR THE NUMEROUS ONLINE COMPLAINTS ABOUT THIS WELL-DOCUMENTED ISSUE. BOTTOM LINE: I EXPERIENCED A "SHAKE DOWN" FROM MAG AND MINI USA IN AN ATTEMPT TO CORRECT A KNOWN SAFETY ISSUE. DEPLORABLE PRACTICE. *TR

WHILE PROCEEDING DOWN A NORMAL DRY ROAD I MANUALLY SHIFTED THE TRANSMISSION (USING MANUAL MODE ON THE CVT AUTOMATIC TRANSMISSION) FROM 3RD GEAR TO 4TH GEAR. THE SHIFT NORMALLY WOULD BE SMOOTH HOWEVER ON THIS OCCURRENCE THE ENGINE IDLED EXTREMELY HIGH AND THE GEAR KICKED IN AFTER A COUPLE OF SECONDS WITH A LOUD BANGING SOUND WHEN THE GEAR FINALLY TOOK HOLD. THE CAR BEHAVED ITSELF FOR A WHILE BUT THIS EVENT STARTED HAPPENING MORE AND MORE UNTIL IT BECAME A REGULAR OCCURRENCE. MOST OF THE TIME THERE WAS NO LOUD NOISE BUT THE 4TH GEAR WOULD NOT CATCH AND I ADJUSTED MY DRIVING SO THAT I WOULD SHIFT FROM 3RD GEAR TO 5TH GEAR AS QUICKLY AS POSSIBLE TO AVOID THE OVER REVVING. I BROUGHT THE CAR IN TO A LOCAL TRANSMISSION SHOP. THEY LOOKED IT OVER AND ADVISED ME THAT THERE WAS NO WAY OF REPAIRING THE TRANSMISSION AND THAT I WOULD HAVE TO REPLACE IT ENTIRELY. I AM CURRENTLY WORKING TO LOCATE A NEW TRANSMISSION AS DURING THE LAST OCCURRENCE (JULY 21, 2012) THE CAR DID NOT GO INTO 4TH GEAR AND I WAS STUCK ON A HIGHWAY WITHOUT BEING ABLE TO MOVE, I.E. THE CAR WOULD NOT GO INTO ANY GEAR. AFTER PULLING OVER TO SAFETY I WAS ABLE TO PUT THE CAR UP TO 3RD GEAR AND RETURN HOME. THE CAR IS CURRENTLY UNUSABLE. I AM NOT WORKING WITH THE MANUFACTURER / DEALER AS PREVIOUS EXPERIENCE HAS SHOWN ME THAT THEY ARE EXTREMELY EXPENSIVE AND FINANCIAL GAIN IS THERE PRIMARY OBJECTIVE. IN ADDITION ALL THE INTERNET BLOGS THAT I HAVE REVIEWED, AND JOINED / COMMENTED ON HAS SHOWN ME THAT BMW / MINI DOES NOT WORK WITH THEIR CUSTOMERS TO RECTIFY THIS BAD, UNSAFE PRODUCT. I AM HOPING THAT BMW / MINI WILL WORK WITH THEIR CUSTOMERS WHO ARE STUCK WITH HIS BAD PRODUCT AND I AM ON A LIST TO SUPPORT A CLASS ACTION SUIT AGAINST THEM. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT POWER STEERING FAILED. IN ADDITION, THE VEHICLE WAS UNABLE TO BE STARTED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO ADVISED THAT THE FAILURE CAUSED DAMAGE TO THE ELECTRICAL SYSTEM, WHICH HAD BECOME INOPERABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 105,916 AND THE CURRENT MILEAGE WAS 105,960.

EARLIER IN THE DAY I TOOK THE CAR ON A DAY TRIP TO LAKE TAHOE DRIVING A COMBINATION OF INTERSTATE AND MOUNTAIN PASS ROAD. 3 HOURS LATER, MY WIFE HAD TAKEN THE CAR TO RUN AN ERRAND AND CAME HOME AND PARKED THE CAR IN THE GARAGE COMPLETELY OFF AND LOCKED. 10-15 MINUTES LATER WE HEAR THE CAR ALARM GOING OFF. WE OPENED THE DOOR TO THE GARAGE AND SAW WHITE SMOKE COMING FROM THE ENGINE COMPARTMENT. THERE WAS HIGH PITCHED WINING ALSO. WHEN I OPENED UP THE DOOR THE PUT IN NEUTRAL, THE LIGHTS ON THE INSTRUMENT PANELS WERE ALL ON WITH NO KEYS IN THE IGNITION. OPENED THE GARAGE AND MOVED THE CAR TO THE DRIVEWAY AND AWAY FROM THE HOUSE. CALLED THE FIRE DEPARTMENT AND I USED AN EXTINGUISHER UNDERNEATH WHERE ORANGE GLOW WAS VISIBLE. THE GLOW OF THE FLAMES WERE TOWARD THE BACK PART OF THE ENGINE COMPARTMENT AND LOW. SAW NO VISIBLE FLAMES IN THE MAIN COMPARTMENT WHEN THE HOOD WAS POPPED OPEN WHEN FIRE DEPARTMENT SHOWED UP THEY USED A GARDEN HOSE TO COOL ENGINE COMPARTMENT AND SUGGESTED TO DISCONNECT THE BATTERY WHICH I DID. I HAD THE CAR TOWED TO THE MINI DEALER IN RENO, NV. *TR UPDATED 8/8/12 *CN THE CONSUMER STATED THE PARTS THAT SEEMED TO HAVE CAUSED AND WERE DAMAGED IN THE INCIDENT WERE THE POWER STEERING PUMP, POWER STEERING COOLING FAN, AND ELECTRICAL HARNESS ALL IN THE ENGINE COMPARTMENT OF A 2005 MINI COOPER S. UPDATED 08/14/2012 *JS

I WAS DRIVING MY 2005 MINI COOPER AND WHEN I SLOWED DOWN TO MAKE A LEFT AND ENTER A SHOPPING CENTER, THE STEERING WHEEL WAS REALLY HARD, THERE WAS ONCOMING TRAFFIC AND I FELT VERY UNSECURE AND IN DANGER. I TOOK MY CAR TO AN AUTO PARTS SHOP AND CHECKED THE POWER STEERING FLUID AND IT WAS OK. I TURNED THE ENGINE ON AND DROVE AWAY AND THE POWER STEERING WHEEL WAS OK. 3 DAYS LATER I NOTICED A BUZZING SOUND FROM THE ENGINE, IT WOULD NOT STOP EVEN WHEN I TURNED THE ENGINE OFF AND REMOVED THE KEYS. I TOOK IT TO THE MECHANIC AND I WAS INFORMED THAT THE POWER STEERING PUMP FAILED. I AM RELUCTANT TO ENTER THE FREEWAY, I FEEL THE CAR MIGHT FAIL AND I CAN GET INTO AN ACCIDENT. *TR

DEFECTIVE CVT TRANSMISSION! THE DEALERSHIP SAID THAT IT WAS NO FAULT OF OURS THAT WE NEEDED A NEW TRANSMISSION, BUT DUE TO THE WAY THIS TRANSMISSION WAS DESIGNED!!!!!!!! *TR

INTERMITTENTLY AND RARELY, WHEN THE CAR FIRST STARTS, THE POWER STEERING DOES NOT WORK. IT IS VERY DIFFICULT TO MOVE THE STEERING WHEEL AT ALL, AND THERE IS NO APPARENT EFFECT ON THE WHEELS OF THE CAR. EACH TIME THIS HAS HAPPENED, I HAVE IMMEDIATELY TURNED OFF THE CAR AND RESTARTED. RESTARTING THE IGNITION HAS BEEN ENOUGH TO REGAIN THE POWER STEERING. AFTER THIS HAPPENED BETWEEN 5 AND 10 TIMES OVER THE PAST YEAR, I REALIZED IT WAS A PATTERN AND DECIDED TO LODGE A COMPLAINT. I ALSO REALIZED THAT THE LOUDER-THAN-ORDINARY STEERING FAN NOISE MIGHT BE ANOTHER SYMPTOM OF PROBLEMS WITH THE POWER STEERING. IN MID-SEPTEMBER 2011, THE CAR BATTERY DIED. THE STEERING FAN WAS VERY LOUD. I NOW WONDER IF THE BATTERY FAILURE WAS DUE TO THE STEERING FAN, ALTHOUGH NO ONE AT THE DEALERSHIP COMMENTED ON THE VERY LOUD FAN THAT WAS EXTREMELY NOTICEABLE WHEN THEY RESTARTED THE CAR. *TR