2006 MINI COOPER Complaints

THE CAR IS A 2006 MINI COOPER S COUPE. THE CAR HAS LESS THAN 57,000 MILES. THE AIRBAG SENSOR LIGHT REMAINS ON EVEN WITH A PASSENGER IN THE SEAT WHICH SHOWS THE AIRBAG IS NOT EMPLOYED. THE DEALER COST TO REPAIR WAS $900 AS QUOTED ON 1/3/11. THE AIRBAG LIGHT GOES ON AND OFF RANDOMLY. IT IS NOT CLEAR THAT THE AIRBAG WOULD FUNCTION IN THE EVENT OF AN ACCIDENT. *TR

PASSENGER AIRBAG FAILURE SENSOR SHOW FAILURE. HAVE HAD IT "REPAIRED" 3 TIMES. SENSOR SHOWS PROBLEM WITHIN 3 WEEKS OF REPAIR EACH TIME. DOES THE PASSENGER AIRBAG WORK? *LN

TL*THE CONTACT OWNS A 2006 MINI COOPER S. WHILE DRIVING APPROXIMATELY 7 MPH THE LOW OIL PRESSURE SENSOR ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS STOPPED AND THE CONTACT ADDED OIL TO THE ENGINE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND WHILE DRIVING APPROXIMATELY 75 MPH THE VEHICLE STALLED. THE VEHICLE COASTED TO A STOP AND UPON RESTART THE CONTACT WAS ABLE TO GET THE VEHICLE TO AUTHORIZED DEALER. THE AUTHORIZED DEALER TOLD THE CONTACT THAT THERE WAS A SMALL LEAK WITHIN THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 74,500.

POWER STEERING FAN ABOUT TO FAIL, WAS ADVISED TO REPLACE TO PREVENT POWER STEERING PUMP FAILURE. INDEPENDENT MECHANIC MADE THE ASSESSMENT AND ADVISED THE REPAIR. THIS IS KNOWN ISSUE IN 2004-2006+ MINIS AND AM REPORTING TO MAKE SURE THERE ARE ENOUGH DATA POINTS AND CONSUMER REPORTS OF THE INCIDENCE. *TR

2006 MINI COOPER, FAULTY WIRING ON PASSENGER SEAT MATE SENSOR, THE WIRING HARNESS THAT COMES OUT OF THE FLOOR AND CONNECTS TO THE SENSOR MATE IN THE SEAT IS TO SHORT AND BECOMES DAMAGED WHEN YOU SLIDE THE SEAT BACK. THIS CAUSES AN ERROR IN THE AIR BAG SYSTEM MAKING IT THINKS THERE IS A SMALL CHILD OR NO ONE IN THE SEAT AND TURN THE PASSENGER AIR BAG OFF. THIS IS A PROBLEM WHEN THERE IS AN ADULT IN THE SEAT, THE AIR BAG SYSTEM WILL NOT PROTECT THEM. THIS NEEDS TO BE A RECALL, BEING THAT THE REPAIR CAN COST UP TO $1000.00 IF THE SEAT MAT SENSOR IS DAMAGED. THE COST MAY CAUSE OWNERS NOT TO REPAIR IT. THIS IS A DESIGN FLAW AND THE MANUFACTURE SHOULD FIX THIS PROBLEM BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED FROM THIS. *TR

THE PASSENGER SEAT AIRBAG WEIGHT SENSOR HAS GONE BAD AND AS A RESULT, HAS RENDERED THE ENTIRE AIRBAG SYSTEM INOPERABLE. THE VEHICLE IS OUT OF WARRANTY BY 4K MILES AND THE LOCAL DEALER AND MINI USA HAVE BECOME NON-RESPONSIVE ABOUT FIXING AN OBVIOUS DESIGN DEFECT. THE REPLACEMENT PART PLUS LABOR AND FACTORY RESETTING WERE QUOTED AT $1900. SEARCHING OTHER ONLINE POSTINGS REVEALS THAT THIS IS A KNOWN PROBLEM NOT ONLY FOR MINI COOPERS BUT FOR PARENT COMPANY BMWS AS WELL. *TR

I OWN A 2006 MINI COOPER AND RECENTLY, AT 62,000 MILES HAD AN ISSUE WITH THE CYLINDERS LOSING COMPRESSION. I WAS TOLD IT WAS DUE TO CARBON BUILD-UP WHICH "PITTED" THE VALVES AS A RESULT OF ETHANOL IN GASOLINE. I WAS ALSO TOLD THAT THIS IS BECOMING A FREQUENT PROBLEM WITH MINI COOPERS BECAUSE THE CAR CAN NOT HANDLE THE GASOLINE WITH ETHANOL, AS THEY ARE INTENDED TO BE RUN ON PURE GAS. SO DUE TO THE ETHANOL MIXTURE, THIS IS GOING TO BE AN ISSUE. SHOULDN'T THESE CARS SOLD HERE IN THE UNITED STATES BE ABLE TO RUN ON THE GASOLINE THAT IS AVAILABLE HERE? I HAVE USED HIGH-OCTANE PREMIUM GAS ONLY IN MY CAR. I WAS TOLD THAT I HAD DONE NOTHING WRONG, YET WAS STILL FINANCIALLY RESPONSIBLE FOR THE ENTIRE REPAIR. I HAVE AN EXTENDED WARRANTY ON THE VEHICLE PURCHASED THROUGH THE DEALER AND HAVE FOLLOWED THE MINI MANUAL IN TERMS OF FUEL TO USE. THEY TOLD ME THEY ARE SEEING THIS PROBLEM MORE AND MORE FREQUENTLY IN THE MINI. IT SOUNDS TO ME LIKE THIS IS A VEHICLE PROBLEM AND PERHAPS DESERVES A RECALL. IS THIS SOMETHING YOU CAN HELP ME WITH? THEY CLEANED, MACHINED AND TESTED THE CYLINDERS AND REPLACED THE VALVES AT A COST TO ME OF $4800. THANK YOU. *TR

MY 2006 MINI COOPER S HAS A DEFECTIVE PASSENGER SEAT AIR BAG SENSOR, THAT I WAS QUOTED 16,000$TO REPLACE IT. THIS IS THE EXACT SAME PART THAT BMW RECALLED IN 2008. BMW RECALLED AROUND 150,000 VEHICLES IN NORTH AMERICA TO FIX A POSSIBLE DEFECT THAT MAY KEEP THE FRONT PASSENGER AIRBAG FROM OPENING IN A CRASH, THE RECALLED CARS INCLUDE 2006 3-SERIES, 2004-06 5-SERIES AND 2004-06 X3 VEHICLES. MINI USES THIS SAME RECALLED PART(MINI BEING MADE BY BMW), YET HAS NOT RECALLED THE PART. I KNOW MANY PEOPLE THAT HAVE HAD THIS PART REPLACED AT THERE OWN EXPENSE SEVERAL TIMES. IT IS A HUGE SAFETY HAZARD. *TR

AIRBAG DEPLOYMENT PASSENGER SEAT SENSOR MAT DEFECTIVE.THIS SENSOR TURNS OFF PASSENGER SIDE AIRBAG INTERMITTENTLY AND WITHOUT WARNING BEFORE DRIVING.MINI WILL NOT CORRECT THE SAFETY ISSUE ON VEHICLES OUT OF WARRANTY. *TR

TL*THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT PASSENGER AIR BAG LIGHT ILLUMINATED ALTHOUGH A PASSENGER (WHO WEIGHED OVER 200 LBS) WAS SEATED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE SENSOR MAT NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 48,500 AND THE CURRENT MILEAGE WAS APPROXIMATELY 153,600.