2003 MINI COOPER Complaints

ON 1/26/06 I TOOK MY CAR INTO TUFFY AUTO TO HAVE THE TIRES ROTATED, AT THE TIME THE MECHANIC TOLD ME THAT THE RIGHT REAR LOWER CONTROL ARM HAD A CRACK IN IT. AT THAT TIME I CALLED MINI AND TOLD THEM THAT MY RIGHT REAR LOWER CONTROL ARM WAS DAMAGED. I WAS TOLD BY THE SERVICE MANAGER AT MINI THAT MY DRIVING WAS THE CAUSE OF THIS AND THAT IT WOULDN'T BE COVERED UNDER WARRANTY. I THEN TOOK PICTURES OF THE LOWER CONTROL ARM WHILE IT WAS STILL ATTACHED TO MY CAR, THESE PICTURES SHOW THAT THERE WAS A SHEARING EFFECT ON THE REAR-MOST PART OF THE ARM AND THERE WAS NO BENDING ON THE ARM. I THEN HAD THE CAR TAKEN BY FLAT-BED TO MY MINI DEALERSHIP WHERE THEY ARE REPLACING THE LOWER AND UPPER CONTROL ARM. MY PICTURES REFUTE WHAT THEY ARE SAYING ABOUT THIS BEING A DRIVERS FAULT AND THEY ARE REFUSING TO WARRANTY THE WORK.*JB

FAILURE OF STEERING GEAR ASSEMBLY RESULTING IN REPLACEMENT OF ASSEMBLY 3X. FAILURE RESULTED IN MORE DIFFICULTY TURNING STEERING WHEEL AND CREAKING NOISE EMITTING FROM UNDERSIDE OF CAR. DEALER STATED THERE WAS A TSB ON THIS ISSUE. 1ST INSTANCE 7/8/04 @32,297 MILES, 2ND INSTANCE 3/2/05 @48,551 MILES, 3RD INSTANCE 7/25/05 @59,112 MILES. ALL FAILURES OCCURRED BETWEEN JULY 2004 AND JULY 2005. OLD PART KEPT BY DEALERSHIP.*JB

OWNER NOTICED CHANGE IN STEERING RESULTING IN HARD TURNING AND NO RETURN OF STEERING WHEEL WITHOUT ASSISTANCE AFTER TURNING VEHICLE. DEALER FOUND FAILURE OF LOWER STEERING SHAFT UNIVERSAL JOINT AND REPLACED LOWER STEERING SHAFT ASSEMBLY AND RETAINED OLD PART. VEHICLE WAS MANF. 2/2003 AND HAS 64482 MILES ON IT TO DATE.

1) GRINDING NOISE WAS HEARD FROM RIGHT REAR CORNER OF THE CAR WHILE BRAKING. 2) UPON INSPECTION, IT WAS FOUND THAT THE RIGHT REAR BRAKE PADS HAD WORN DOWN COMPLETELY ALTHOUGH THE LEFT REAR BRAKE PADS HAVE APPROXIMATELY 1/2 PAD REMAINING. I HAD THE VEHICLE TOWED TO THE NEAREST DEALER FOR WARRANTY SERVICE. 3) VEHICLE IS CURRENTLY AT GLOBAL IMPORTS MINI IN ATLANTA AWAITING INSPECTION BY A SPECIAL BMW ENGINEER TO DETERMINE THE CAUSE OF THIS UNUSUAL WEAR OF BRAKE COMPONENTS. THE BRAKE CALIPERS THAT OPERATE THE BRAKE SYSTEM ARE SUSPECTED TO BE DEFECTIVE/FAULTY. THIS SAME PROBLEM ALSO OCCURRED ON THIS SAME VEHICLE ON MAY 8, 2004. AT THAT TIME, THE VEHICLE WAS ALSO SENT TO GLOBAL IMPORTS IN ATLANTA WHERE THE BRAKE PADS AND ROTORS WERE REPLACED UNDER WARRANTY DUE TO EXCESSIVE WEAR FOR THE MILEAGE ON THE CAR. HOWEVER, THE BRAKE CALIPERS WERE NOT INSPECTED OR REPLACED BY GLOBAL IMPORTS AT THIS TIME. BECAUSE THIS HAS OCCURRED TWICE ON THE SAME VEHICLE, I DO NOT FEEL SAFE DRIVING MY VEHICLE WITH A SUSPECT BRAKE SYSTEM. THE SERVICE MANAGER AT GLOBAL IMPORTS (ERIC PETERS) HAS STATED THAT HE BELIEVES THIS TYPE OF INCONSISTENT UNEVEN BRAKE WEAR IS CONSIDERED "NORMAL" PHOTOGRAPHS TAKEN AT THE TIME OF RECENT OCCURRENCE ARE AVAILABLE TO SHOW A COMPARISON BETWEEN THE BRAKE PAD THICKNESS ON BOTH THE RIGHT AND LEFT SIDE OF THE VEHICLE. PLEASE CONTACT ME FOR THESE PHOTOGRAPHS. *NM

AIR BAG CHECK LIGHT IS ON. NO AIR BAG WAS DEPLOYED, NO CRASH WAS INVOLVED. THIS IS ON GOING PROBLEM WITH THE MINI COOPER WHICH SHOULD HAVE A RECALL. COST IS OVER 1000.00 DOLLARS TO REPAIR. IF NOT REPAIRED AIR BAG MAY NOT DEPLOY IN A CRASH. *JB

WHILE PULLING INTO THE PARKING GARAGE AT WORK, THE REAR OF MY MINI COOPER S MADE A NOISE. THE CONTROL ARM ON THE RIGHT, REAR SUSPENSION BROKE. WHEN LOOKING UNDER THE REAR, THE CONTROL ARM WAS IN TWO PIECES, BROKEN IN THE MIDDLE. THE VEHICLE IS AT THE DEALER AND I WILL BE REQUESTING THE PART BACK. *JB

THE WINDSHIELD CRACKED IN SEVERAL PLACES AND NEEDED TO BE REPLACED. VEHICLE WAS TAKEN TO DEALER FOR CHECK UP, AND CONSUMER WAS INFORMED THAT THE WINDSHIELD HAD CERTAIN SPOTS THAT COULD NOT TOLERATE ROAD CONDITIONS. THIS COULD BE DANGEROUS IF THE WINDSHIELD BREAKS WHILE THE VEHICLE WAS BEING DRIVEN.*AK

COMPLETE FAILURE OF THE INTERNAL CONTROLLER AREA NETWORK, RESULTING IN BLOWN ELECTRONICS, SERVICE ENGINE SOON LIGHT, ABS LIGHT, DSC LIGHT AND AIR BAG LIGHT. CAUSE WAS APPARENTLY A FAULTY RADIO. HOWEVER, A REPLACEMENT RADIO FAILED WHEN INSTALLED IN THE VEHICLE, BRINGING MORE CONTROLLER AREA NETWORK PROBLEMS.*AK

WHILE DRIVING 10 MPH A FIRE STARTED IN THE DASHBOARD. CONSUMER MANAGED TO PULL OVER, AND PUT OUT THE FIRE OUT. THEN HAD THE VEHICLE TOWED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

AIRBAG LIGHT WENT ON WHICH INDICATES THE AIRBAG IS NOT FUNCTIONING. HAVE TAKEN THE CAR TO THE DEALERSHIP THREE TIMES ALREADY TO HAVE THIS FIXED. WILL BE TAKING IT IN FOR THE FOURTH TIME TOMORROW. THE FIRST TIME I TOOK IT IN, THEY TOLD ME THEY FIXED THE PROBLEM. THE SECOND TIME THEY TOLD ME THEY HAD TO REPLACE THE ELECTRICAL HARNESS IN ORDER TO FIX THE PROBLEM. THE THIRD TIME THEY TOLD ME THAT THEY HAD TO REPLACE THE ELECTRICAL HARNESS AGAIN TO FIX THE PROBLEM. I'M CURIOUS WHAT THEY WILL SAY THIS TIME. MANY PEOPLE HAVE REPORTED THE SAME AIRBAG LIGHT PROBLEM ON THE MINI CHAT ROOMS. THE SCARY THING IS THAT THE DEALERSHIP TOLD ME THAT WHEN THE AIRBAG LIGHT COMES ON, EITHER ONE OR BOTH OF MY AIRBAGS WILL NOT DEPLOY IF I GET INTO AN ACCIDENT.*AK