2005 MINI COOPER Complaints

AFTER RUNNING ERRANDS IN THE MORNING I PARKED MY CAR IN MY SPOT IN FRONT OF MY HOUSE. WHEN I WALKED AWAY THE CAR WAS SILENT. TWO HOURS LATER MY NEIGHBOR KNOCKED ON MY DOOR TO LET ME KNOW THAT MY CAR (WHICH HAD BEEN OFF AND PARKED FOR TWO HOURS) WAS MAKING A LOUD WHINING NOISE. I WENT OUTSIDE TO CHECK IT OUT, AND DETERMINED THAT THE NOISE WAS COMING FROM MY CAR WHILE IT WAS OFF. I IMMEDIATELY TOOK THE CAR, WHICH WAS DRIVING WELL AT THE TIME, TO MY LOCAL MECHANIC WHO COULD NOT DETERMINE THE CAUSE OF THE PROBLEM AND RECOMMEND THAT I SHOULD TAKE IT IMMEDIATELY TO THE MINI DEALERSHIP. WHEN I ARRIVED AT THE MINI DEALERSHIP THEY IMMEDIATELY TOOK MY CAR BACK. I WAS TOLD THAT MY POWER STEERING PUMP WAS FAILING AND OVERHEATING, WHICH CAUSED THE POWER STEERING FAN TO KEEP RUNNING WHILE THE CAR WAS OFF. THE SERVICE REPRESENTATIVE SAID THAT THIS HAPPENS TIME TO TIME, AND IF I HAD CONTINUED DRIVING THE CAR IT MAY OF CAUGHT ON FIRE. THE TECHNICAL WORDS ON THE WORK ORDER FROM THE MINI MECHANIC WERE, "SCANNED CAR FOR FAULTS, AFTER CHECKING CARS FAULT MEMORY IT WAS FOUND THAT THERE WAS A CURRENT FAULT FOR AN OPEN CIRCUIT ON THE ELECTRIC POWER STEERING PUMP." BOTH THE POWER STEERING PUMP AND FAN HAD TO BE REPLACED. *TR

WHILE I WAS DRIVING THE POWER STEERING ALL OF A SUDDEN WENT OUT THUS MAKING THE STEERING EXTREMELY HEAVY. IT CAUGHT ME BY SURPRISE. COULD BE DANGEROUS TO DRIVERS IF FAILURE OCCURS ON A TURN. POWER STEERING SHOULD NOT FAIL. *TR

I HAD TO REPLACE THE POWER STEERING PUMP AS IT HAD FAILED. IT FIRST FAILED WHILE I WAS ON A HIGHWAY OFF-RAMP AND NEARLY CRASHED. THE FAILURE WAS DUE TO THE POWER STEERING FAN SEIZING AND THEREFORE IT WAS NOT COOLING THE POWER STEERING PUMP. AFTER SOME INVESTIGATION OF MY OWN, I FOUND OUT THAT THE ROOT CAUSE OF THIS PROBLEM WAS THE LOW FAN SPEED RESISTOR FAILED ON THE ENGINE COOLING FAN. THE POWER STEERING FAN WILL ONLY ACTIVATE ONCE THE ENGINE COOLING FAN IS RUNNING. IF THE LOW FAN SPEED RELAY FAILS, THE ENGINE COOLING FAN WILL ONLY TURN ON AT 233F (HIGH SPEED FAN MINIMUM TEMPERATURE). ONCE THE ENGINE COOLING FAN TURNS ON AT 233F, THE POWER STEERING FAN WILL TURN ON TO COOL THE POWER STEERING PUMP. THE POWER STEERING FAN WILL BE TOO HOT AT THIS POINT AND WILL OVERHEAT ITSELF AND SEIZE. THE POWER STEERING FAN FAILURE THEN CAUSES THE POWER STEERING PUMP TO OVERHEAT AND FAIL. IF THE POWER STEERING FAN IS NOT REPLACED BEFORE THE POWER STEERING PUMP FAILS, THIS CAUSES THE ENTIRE HYDRAULIC SYSTEM FOR THE POWER STEERING SYSTEM TO FAIL AS WELL AND LEAK HYDRAULIC FLUID. IF THE POWER STEERING SYSTEM FAILS, THIS CAN CAUSE THE POWER STEERING PUMP TO ULTIMATELY CATCH ON FIRE DUE TO IT OVERHEATING FROM LOW LEVELS OF HYDRAULIC FLUID. THE COMPLETE REPLACEMENT OF PARTS ALONE FOR THE POWER STEERING SYSTEM IS $1,296.35. THIS SYSTEM IS REQUIRED FOR DRIVING THE VEHICLE AT ANY SPEED AS IT IS A "POWER ASSISTED STEERING" SYSTEM, THUS MAKING IT VERY HARD TO CONTROL THE VEHICLE AT ANY SPEED. IF YOU VISIT ANY MINI FORUM (I.E. WWW.NORTHAMERICANMOTORING.COM OR WWW.MOTORINGALLIANCE.COM) YOU CAN FIND HUNDREDS OF POSTS ABOUT THE POWER STEERING SYSTEM FAILING IN MINIS. I REPLACED THE PUMP AND FAN ($876.46 PARTS COST), THEN HAD TO REPLACE THE ENTIRE SYSTEM ($1296.35 PARTS COST) WHEN THE SYSTEM FAILED AGAIN BECAUSE OF THE LOW SPEED ENGINE FAN RESISTOR FAILING AND CAUSING THE ENTIRE PROBLEM. *TR

SOMETIME IN LATE SUMMER OF LAST YEAR, MY CAR BEGAN TO MAKE A "HONKING" SOUND. IT SOUNDED LIKE THE CLUTCH THAT HAD ALREADY BEEN REPLACED ON BOTH OF OUR 2005 MINI COOPERS UNDER WARRANTY (ANOTHER POSSIBLE SAFETY ISSUE?) BUT THE CLUTCHING SEEMED OK. UP UNTIL THE TIME I WAS ABLE TO GET THE CAR IN TO THE SHOP TO GET LOOKED AT, I NOTICED A PUDDLE IN THE GARAGE, AND I ALSO NOTICED IT WAS GETTING HARDER TO STEER. THE SHOP DETERMINED THAT MY STEERING RACK WAS LEAKING AND NEEDED TO BE COMPLETELY REPLACED, WHICH WE DID. NOW, JUST OVER 1 YEAR LATER, THE CAR IS ALREADY EXHIBITING THE SAME BEHAVIORS EXACTLY. SOMETHING IN THE VEHICLE IS CAUSING THE RACK TO MALFUNCTION AND REQUIRE REPLACEMENT. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING APPROXIMATELY 15 MPH, THE STEERING BECAME DIFFICULT TO MANEUVER. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT BELIEVED THAT THE POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED A CONCURRENT INVESTIGATION UNDER NHTSA ACTION NUMBER: EA11005 (STEERING STEERING:HYDRAULIC POWER ASSIST:PUMP STEERING:ELECTRIC POWER ASSIST SYSTEM STEERING:HYDRAULIC POWER ASSIST SYSTEM) THAT COULD POSSIBLY HAVE BEEN RELATED TO THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

WHILE DRIVING 2005 MINI COOPER, I WENT AROUND A CORNER AT ABOUT 30 MPH AND WHEN I TRIED TO STRAIGHTEN OUT THE POWER STEERING HAD QUIT WORKING. IT ALMOST PUT ME IN THE DITCH ON THE WRONG SIDE OF THE ROAD. JUST THANKFUL OF NO ONCOMING TRAFFIC. *TR

THE POWER STEERING PUMP IN MY 2005 MINI COOPER S CONVERTIBLE INTERMITTENTLY STOPS WORKING 1 TO 5 TIMES PER WEEK. THERE DOES NOT APPEAR TO BE ANY PATTERN TO IT, IT HAS HAPPENED AT COLD START, AFTER WARM START, HOT/COLD/WET/DRY WEATHER, LEVEL/SLOPED PARKING, WHILE DRIVING & STATIONARY, ETC. I'VE LEARNED TO LIVE WITH IT AS AN ANNOYANCE, UNTIL I RECENTLY HAD A VERY FRIGHTENING FAILURE THAT VERY NEARLY HAD *FATAL* CONSEQUENCES. I WAS DRIVING ROUGHLY 25 MPH, THE POSTED SPEED LIMIT, IN A RESIDENTIAL AREA, WHEN A YOUNG CHILD (I ESTIMATE 4-5 YEARS OLD) RAN INTO THE STREET FROM BETWEEN TWO PARKED CARS 5 OR 6 CAR LENGTHS IN FRONT OF ME. I SLAMMED ON THE BRAKES (ABS FULLY ENGAGED) AND ATTEMPTED TO SWERVE INTO THE ONCOMING [EMPTY] LANE AT AVOID... BUT MY STEERING PUMP WAS OUT AND I COULD NOT ALTER MY COURSE SUFFICIENTLY. I CAME TO A STOP WITH THE CHILD BARELY THREE FEET OFF MY FRONT BUMPER! SO NO DAMAGE OR INJURY, BUT... THIS FAILURE COULD EASILY HAVE BEEN MUCH, MUCH WORSE! *TR

MY 2005 MINI COOPER CONVERTIBLE WAS PARKED IN A PARKING LOT AFTER A SHORT TRIP, NOT RUNNING. I CAME OUT OF A STORE AND SAW SMOKE POURING OUT FROM ALL AROUND THE HOOD AREA. I RAISED THE HOOD AND THE SMOKE BEGAN TO SUBSIDE. SMELLED LIKE AN ELECTRICAL FIRE. THERE WAS NO PREVIOUS WARNING OF ANY KIND. THE REPAIRS INCLUDE THE ALTERNATOR, POWER STEERING PUMP, RESERVOIR, POWER STEERING PUMP FAN. AT A TOTAL OUT OF POCKET OF $1900.00. *TR

MY WIFE WAS BACKING OUT OF A PARKING SPOT AND THE POWER STEERING ASSIST APPEARED TO HAVE BEEN TURNED OFF. SHE RE-STARTED THE CAR AND THE POWER STEERING WORKED FINE AFTER THAT. IT HAPPENED AGAIN WHEN I WAS ALSO BACKING OUT OF A PARKING SPOT LAST NIGHT. I AM AFRAID THIS COULD BECOME A BIG ISSUE IF THIS HAPPENS IN TRAFFIC THUS THE REPORT. FROM AN INTERNET SEARCH, IT SEEMS THAT NUMEROUS OTHER PEOPLE HAVE THE SAME ISSUE SO THERE SEEMS TO BE A PROBLEM WHICH MINI NEEDS TO FIX BEFORE THIS ENDS TRAGICALLY FOR SOMEONE. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WARNING LIGHT ILLUMINATED AT ENGINE START UP. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED TO THE CONTACT THAT THE OCCUPANCY SENSOR FAILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000 AND THE CURRENT MILEAGE WAS 41,000.