2003 MINI COOPER Complaints

THE VEHICLE FOR MONTHS WOULD MAKE A SMALL JUMP FORWARD WHEN PUTTING IN REVERSE. THEN THE TRANSMISSION WOULD MAKE A GRINDING NOISE WHEN IN DRIVE. THE CAR WOULD FEEL SPONGY IN DRIVE WHEN FIRST STARTING OFF IN THE MORNING AND AT FULL STOPS.

OUR 2003 MINI COOPER HAS ABOUT 120K MILES ON IT. IT WAS COMPLETELY FINE UNTIL RECENTLY WHEN THE POWER STEERING PUMP STARTED WHINING. SOMETIMES IT COMPLETELY STOPPED WORKING AND WE HAD NO POWER STEERING, THANKFULLY THIS WAS WHILE THE CAR WAS PARKED AND NOT WHILE DRIVING. TURNING THE WHEEL IS A LITTLE HARDER THAN USUAL, AND IF YOU TURN IT TOO MUCH, THE CAR BOGS DOWN AND THE REVS GO WAY DOWN. WE'VE TRIED FLUSHING AND REPLACING THE POWER STEERING FLUID, BUT IT DIDN'T SEEM TO HELP. WE'VE EVEN PUT IN SOME EXPENSIVE ADDITIVES THAT PROMISE TO REPAIR THE PROBLEM AND STOP THE NOISE, BUT IT DOESN'T WORK. WE DON'T FEEL SAFE KNOWING THAT OUR POWER STEERING MAY GO OUT AT ANY MOMENT. AND WE CERTAINLY DON'T APPRECIATE THE LOOKS WE GET WHEN WE DRIVE PAST PEOPLE. *TR

TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT STATED THAT THE GEAR SHIFTER FAILED TO MOVE WHEN ATTEMPTING TO OPERATE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000.

THE DASHBOARD AIRBAG WARNING LAMP IS ALWAYS ILLUMINATED. THE DEALER WANTS THOUSANDS TO FIX THIS PROBLEM EVEN THOUGH OTHER MODEL YEARS HAVE BEEN RECALLED. WE DON'T KNOW IF THE AIRBAG WILL OPERATE CORRECTLY IN AN EMERGENCY. *TR

STEERING FLUID CONTINUOUSLY LEAKS - REPLACE HYDRAULIC HOSE TWICE - KNOWN DEFECT - MINI REFUSED TO FIX FOR FREE ENGINE COOLING - FAN RUNS AFTER SHUTOFF CONTINUOUSLY - KNOWN DEFECT - MINI REFUSED TO FIX FOR FREE ELECTRICAL - DOORS, WINDOWS, SUNROOF FIRE OFF ON THEIR OWN WHILE CAR IS MOVING AND WHEN IS PARKED. WILL DO THIS AT HIGHWAY SPEED OR WHEN SITTING OUTSIDE (RAIN OR SHINE) - CAR UNLOCKS ITSELF AND WINDOWS ALL OPEN UP -KNOWN DEFECT - KIND OF DISTRACTING AT HIGHWAY SPEED -MINI REFUSED TO FIX FOR FREE. DEALERS WILL NOT FIX THESE ISSUES UNLESS YOU MAKE THEM RECALL VEHICLES WITH MULTIPLE SMALL PROBLEMS ( NOT JUST ONE BIG PROBLEM) - THIS MODEL HAS 73 TSBS THAT DEALERS CHARGE YOU TO FIX EVEN THOUGH THE PROBLEMS ARE KNOWN AND DANGEROUS ISSUES. IN MY MIND, MANY SMALL PROBLEMS CAN BE MORE DANGEROUS THAN A FEW BIG ONES - STEERING, DOOR LOCKS, COOLING - NOT GOOD. THIS IS AN OLD CAR BUT THESE PROBLEMS ARE OLD TOO - KNOWN TSBS SHOULD NOT BE SUBJECT TO WARRANTY TIME FRAMES, THEY ARE STILL DANGEROUS AFTER THE WARRANTY EXPIRES. WHEN THESE CARS ARE ROUTINELY SERVICED, THESE KNOWN/DANGEROUS ISSUES NEED TO BE CORRECTED OR THE CARS SHOULD BE TAKEN OFF THE ROAD. I USED THE DATE OF THE LAST INCIDENT, NOT THE FIRST ONE. THANK YOU. *TR

THE LEFT REAR CONTROL ARM BROKE IN HALF. I NOTICED MY CAR WAS NOT REVERSING CORRECTLY AS IF THE REAR WHEEL WAS DRAGGING. I EXITED THE CAR AND ELEVATED IT WITH A FLOOR JACK TO FIND THE REAR CONTROL ARM ON THE DRIVER'S SIDE BROKEN IN HALF. *TR

THIS MINI COOPER A 2003 W/130K MILES DRIVEN BY A YOUNG FEMALE. SHE HAD NO IDEA HER WHEEL WAS GOING TO FALL OFF THE DRIVER SIDE FRONT. SHE HAD CALLED FOR A CHECK ENGINE LIGHT ON AND INTERMITTENT BATTERY FAILURE. IT WAS ASK THAT I DRIVE THE CAR AND LISTEN TO A POP COMING FROM THE WHEEL SECTION. THE POP WAS THE ENTIRE WHEEL ASSEMBLY MOVING FORWARDS AND BACK BUMPING THE WHEEL WELLS AS THE CAR WENT FORWARD. NEEDLESS TO SAY I DIDN'T DRIVE FAR NOR DID I ACCELERATE FASTER THAN 10 MPH. I TOLD THE PARENT OF THE DRIVER THAT THE CAR WAS NOT DRIVABLE UNDER ANY CONDITION AND THAT IT NEEDED IMMEDIATE ATTENTION. THE LOWER CONTROL ARM BUSHING RUBBER WAS COMPLETELY GONE. I DO NOT KNOW IF THIS IS A DEFECT. THIS PART IS A MOUNT AND IT'S HOLDING MANY COMPONENTS OF THIS CAR TOGETHER. IT IS NOTHING LIKE I HAVE SEEN BEFORE USED AS A MOUNT. I HAVE SEEN THE RUBBER WORN FROM THIS TYPE PART BUT THEY WERE NOT BEING USED AS A MOUNT. WHEN THE RUBBER ON THIS PART DETERIORATES IT CAUSES THE MOUNT TO BE UNSTABLE RESULTING IN THE WHOLE WHEEL ASSEMBLY MOVING LIKE A SWING FORWARDS AND BACKWARDS WHILE DRIVING. IN A TRAFFIC SITUATION THIS COULD BE DEVASTATING TO MORE THAN JUST THE DRIVER OF THIS CAR BUT ALSO TO THE CARS DRIVING NEAR IF THE WHEEL WERE TO COME OFF IN THEIR TRAFFIC. NEEDLESS TO SAY THE MINI COOPER WOULD IMMEDIATELY FAIL IN TRAFFIC WITH THE BRAKE CYLINDERS HITTING THE ROAD CAUSING FLYING SPARKS, IF REAR ENDED IT WOULD MORE THAN LIKELY FLIP. THIS IS A DANGEROUS SCENARIO. THIS CAR WAS PURCHASED SECOND HAND AS ARE A LOT OF CARS. THIS IS NOT A PART ON ANYONE'S CHECK LIST AND NOT ONE YOU CONSIDER TO BE ONE OF THIS TYPE OF FAILURE. I AM FILING THIS COMPLAINT BUT I AM NOT THE OWNER OF THIS CAR. I AM MERELY CONCERNED AT THE IMPLICATIONS OF THE DETERIORATION OF THE RUBBER AND WHAT THOSE IMPLICATIONS MEAN TO THE OTHER PURPOSE THIS PART IS SUPPOSE TO PERFORM AND CAN'T WHEN THE RUBBER IS GONE. *TR

WHILE ADJUSTING THE TILT CONTROL ON MY MINI COOPER, I DISCOVERED THAT THE ENTIRE STEERING COLUMN HAD BECOME LOOSE. UPON INSPECTION, I DISCOVERED THAT TWO METAL BRACKETS USED TO SUPPORT THE STEERING COLUMN AND ATTENDANT ASSEMBLY HAD SHEERED OFF, APPARENTLY UNDER NORMAL USE. *TR

NIGHT DRIVING IN COLORADO MTNS. LIGHTS BEGAN TO FLICKER AND POWER STEERING FAILED. FOUND SAFE PLACE TO PULL OVER AND TURNED OFF LIGHTS AND ENGINE. RESTARTED AND TURNED LIGHTS BACK ON TO RESUME DRIVING WITHIN A FEW MINUETS LIGHTS FLICKERED AND POWER STEERING FAILED AGAIN. HAD TO CONTINUE FOR SEVERAL MILES UNTIL IT WAS SAFE TO PULL OVER AGAIN. ATTEMPTED TO TURN OFF HEAD LIGHTS AND USE FOG LIGHTS ON COUNTY DIRT ROAD, STILL LIGHTS FLICKERED/DIMMED AND POWER STEERING FAILED. CURRENTLY VEHICLE IS PARKED AND WE ARE ATTEMPTING TO RESEARCH RECALL MATTERS WITH THIS MALFUNCTION. SUPERIOR DRIVING SKILL IS REQUIRED TO OPERATE THIS VEHICLE WITH NONFUNCTIONAL POWER STEERING. AVERAGE OPERATORS WILL HAVE GREAT DIFFICULTY MAINTAINING SAFE OPERATION OF THE AUTOMOBILE. THIS ISSUE WILL LEAD TO LOSS OF LIFE IF NOT ADDRESSED. NEAREST DEALER FOR MINI IS 130 MILES DISTANT. *TR

TL* THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING APPROXIMATELY 55 MPH, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE POWER STEERING PUMP FAILED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.