2006 MINI COOPER Complaints

A EXTENDED WARRANTY WAS ISSUED FOR THE COOPER S R53 TILL 2005 MODEL YEAR .... THE R 53 WAS PRODUCED INTO THE 2006 MODEL YEAR FOR THE NORTHAMERICAN MARKET .... HAVE REPLACED TO PUMP ONCE AROUND 40-50 K ON THE CAR , OUT OF POCKET, AND PUMP HAS FAILED AGAIN AROUND 95K . THE WARRANTY ON MODELS TILL 2005 WAS EXTENDED TO 13 YEARS AND/OR 150K ..... WHY ARE THE FEW REMAINING MODELS OF THE 2006 RUNOFF NOT COVERED.. FIRST PUMP FAILED ON THE MY WASHINGTON AUTO ROAD..... NOT A GOOD PLACE TO SAY THE LEAST..... THE OTHER ON THE WASHINGTON, D.C. BELTWAY DURING THE AFTERNOON RUSH.... MANAGED TO KEEP SAFE BUT WAS NOT A GOOD SITUATION FOR ANYONE ... STEERING PUMP WOULD SURGE ON AND OFF-ROAD CAUSING INCONSISTENT POWER ASSIST IN TURNS WITH A EVENTUALLY NO ASSIST WAS MUCH MORE DRAMATIC THE FIRST TIME WAS ONLY SAVED BY RECOGNIZING THE PROBLEM AS IT OCCURRED THE SECOND TIME ... WHEN THE FIRST PUMP WAS REPLACED ALL LINES , COOLING FAN AND ITS DUCT WORK WERE REPLACED A WELL ......

STOPPED AT GAS STATION TO FILL UP. RESTARTED CAR AND BEGAN TO DRIVE...NOTICED EXTREME STIFFNESS IN STEERING AND PULLED OVER. SHUT ENGINE OFF AND THEN RESTARTED POWER STEERING RETURNED. LATER IN THE DAY...I WAS GOING FOR A DRIVE AND IT OCCURRED AGAIN. THIS TIME, IT WAS AFTER I HAD STOPPED AT THE GYM FOR AN HOUR, AND WAS RETURNING HOME. AGAIN, I PULLED OVER SHUT OF ENGINE AND THEN RESTARTED. POWER STEERING RETURNED.

MY '06 MINI COOPER S WITH ABOUT 87,000 MILES IS LEAKING POWER STEERING FLUID AND HAS BEEN DOING SO FOR THE LAST 3 YEARS OR 20,000 MILES. I'VE BEEN TOLD I NEED TO REPLACE THE ELECTRIC POWER STEERING PUMP. I BELIEVE MINI SHOULD HAVE TO REPAIR/REPLACE THE POWER STEERING PUMP UNIT BECAUSE IS LIKELY A FAILURE SIMILAR TO THE POWER STEERING FAILURE DOCUMENTED AND COVERED BY NHTSA CAMPAIGN NUMBER: 15V660000. WHILE THE STEERING MECHANISM IS STILL FUNCTIONING, CAN A CATASTROPHIC POWER STEERING FAILURE BE FAR OFF?

TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THERE WAS A LOSS OF POWER STEERING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE POWER STEERING PUMP WAS REPLACED HOWEVER THE FAILURE RECURRED THE NEXT DAY. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC AND UNKNOWN REPAIRS WERE PERFORMED. IN ADDITION, THE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. ON A SEPARATE OCCASION, THE ALTERNATOR FAILED AND WAS NOT REPLACED. THE CONTACT MENTIONED THAT THE ENGINE COOLING FAN ALSO FAILED TO FUNCTION, WHICH CAUSED THE RADIATOR TO BE REPLACED TWICE. THE ENGINE WAS REPLACED AT A DIFFERENT TIME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

POWER STEERING RANDOMLY WHEN OUT WHILE IN MOTION. THANKFULLY, I WAS ON A LOCAL ROAD GOING SLOWLY WHEN IT HAPPENED. PULLED OVER TO THE SIDE, TURNED OFF THE CAR AND TURNED IT BACK ON. POWER STEERING CAME BACK.

TL* THE CONTACT OWNS A 2006 MINI COOPER S. THE CONTACT STATED THAT WHILE IN PARK, THE VEHICLE FAILED TO START. IN ADDITION, THE CONTACT STATED THAT WHILE REVERSING AT A LOW SPEED, THE STEERING WHEEL WAS DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO STEER THE VEHICLE. ONCE IN PARK, THE VEHICLE FAILED TO TURN OFF WITH THE KEY IN THE OFF POSITION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING MOTOR HAD FAILED AND MELTED. THE POWER STEERING MOTOR, WIRES, BATTERY, PUMP, FAN, PRESSURE HOSE AND ALTERNATOR WERE REPLACED. AFTER REPAIRS, THE MECHANIC WAS UNABLE TO DIAGNOSE THE VEHICLE USING THE DIAGNOSTIC TOOL. THE VEHICLE WAS THEN TAKEN TO A DEALER WHO STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000.

WAS DRIVING TO SEE MY HUSBAND OUT OF TOWN AND MY STEERING WHEEL START GETTING HARD, I STOPPED TURN OF THE CAR AND BACK ON AND IT WORKED, BUT AFTER THAT IT COINTINUE TO DO IT MORE AND MORE OFTEN, TOOK IT TO THE MECHANIC AND HE SAID IT WAS THE POWER WHEEL PUMP,

ONCE THE CAR WARMS UP THE AUTOMATIC TRANSMISSION LURCHES WHEN THE CAR SHIFTS FROM 1ST TO 2ND AND 3RD GEAR. THE ENGINE STILL ACCELERATES, HOWEVER, THE TRANSMISSION SIMPLY WHINES AND NO POWER IS DISTRIBUTED TO THE WHEELS. VERY UNSAFE WHEN PULLING OUT IN TRAFFIC. MINI ADVERTISED THESE VEHICLES AS NEVER REQUIRING TRANSMISSION FLUID CHANGES. THE VEHICLE HAS LESS THAN 100,000 MILES. NO RECALL EXISTS, HOWEVER, THE ISSUE IS WELL DOCUMENTED ON WEB FORUMS.

TL* THE CONTACT OWNS A 2006 MINI COOPER S. WHILE DRIVING 30 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING LINE AND PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000.(STEERING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 106,000.

TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER. ALSO, WHEN MAKING A LEFT OR RIGHT TURN, THE ENGINE LIGHT ILLUMINATED FOR A SECOND AND DIMMED. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE LOCATED. THE FAILURE RECURRED. IN ADDITION, WHILE DRIVING 54 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND IT BEGAN TO SMOKE AND LEAK OIL. THE DEALER DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 52,000.