2012 MINI COOPER Complaints

Passenger side airbag light on with no one in seat, had it checked, the repair shop stated that there is a seat sensor fault, the code is 93c3(passenger seat occupancy detector). I have done some research on this and it seems that this a common problem, but there hasn't been any recalls by Mini, and if there is an accident the airbag may not deploy. I was told to by the dealer that it will cost $2300 for parts and labor.

The failed component is the "Footwell Relay Module" (FRM) which enables communication between the instrument panel in the passenger compartment and the engine control components in the engine compartment. When this component fails the following essential controls become inoperable: emergency flashers, turn signals, door locks, and windows. Most other "convenience features controlled by the car instrument panel become inoperable as well. This problem was confirmed by an independent technician, a technician at Mini of Stevens Creek in San Jose, CA, and the owner. No inspections of the part were ever done and the FRM failed without warning. This is a common failure in Minis due to a faulty design. The part is insufficiently protected from inrush current surge when a fully-charged battery is reconnected following service. It is also not sufficiently protected from induced voltage surges from EMI such as C, K or Ka band radar or electrical storms. One or more integrated circuits in the part are destroyed when exposed to current or voltage spikes rendering the part inoperable. The cost to replace the FRM (parts & labor) exceeds $1000.

The contact owned a 2012 Mini Cooper S Countryman. The contact stated while she was at a standstill in traffic, she saw smoke exiting from under the hood. The contact stated no warning light was illuminated. The contact was able to park on the emergency lane and exit the vehicle before the vehicle was engulfed in flames. The contact did not sustain any injuries nor seek medical attention. A police report was filed. The insurance company deemed the vehicle a total loss. The vehicle was towed to a towing lot. The contact spoke to the local dealer and made them aware of the failure. The vehicle was not diagnosed. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V248000 (ENGINE AND ENGINE COOLING), however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 180,000.

The front passenger occupancy detector (or OC3) failed, making the passenger airbags inoperable. This is a common problem with minis and many other models have had the mat warranty extended. The dealer confirmed that the OC3 is bad but wanted $800 just to order the part which is embedded in the seat cushion. Consumers shouldn't have to bear the cost of a defective vital safety component that should last the life of the car.

This car was maintained, by Mini and BMW authorized mechanics and only had OEM parts installed and followed management of vehicle as directed by manufacturer, throughout its history. It was always driven and kept in moderate weather conditions, no extreme heat, cold, wet, or speeds. Used almost daily for 30-60 minute commutes. Just after 100K miles, total engine failure was suddenly experienced on the freeway, due to combustion in two valves, damaging two cylinders and sudden leaking of the exhaust system under the hood. The manufacturer, BWM, has been shown evidence of malfunctioning of the four cylinder engine and will not show evidence of their grounds for why they will not take responsibility.

AFTER DRIVING FEW MILES (10) UP HILL OUT THE DEALER MY CHECK ENGINE LIGHT TURN ON. IT?S NOT BLINKING BUY SEEMS LIKE IT?S HALF AWAY ON THE SIGNED ON THE CAR.

TL* THE CONTACT OWNS 2012 MINI COOPER S COUNTRYMAN. THE CONTACT STATED WHILE DRIVING AT AN UNDISCLOSED SPEED, THE ENGINE POWER REDUCED MESSAGE DISPLAYED ON THE INSTRUMENT PANEL. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. ADDITIONALLY, THERE WAS A KNOCKING SOUND COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE SPARK PLUGS AND COIL PACKS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 118,421.

MINI COOPER BASE MODEL WITH 90K MILES HAS SEAT BELT AND AIR BAG WARNING LIGHTS ILLUMINATED. WARNING LIGHTS STARTED INTERMITTENTLY GOING ON AND OFF AND NOW STAY ILLUMINATED CONTINOUSLY WHEN IGNITION IS ON. NO VEHICLE ACCIDENTS OR INCIDENTS TO CAUSE THIS PROBLEM.

OUR VEHICLE HAS THE AIRBAG LIGHT ON AND I AM AM VERY CONCERNED WITH THE SAFETY OF OUR FAMILY. AFTER RESEARCHING THIS ISSUE, THERE ARE MANY MINI OWNERS THAT ARE HAVING THE SAME PROBLEM WHICH LEADS ME TO BELIEVE THAT THIS IS DEEPER THAN AN ISOLATED ISSUE ON MY VEHICLE. I ALSO FOUND OUT THAT THIS HAS BEEN AN ISSUES THAT WAS CONVERTED INTO A RECALL FOR SEVERAL YEARS BEFORE. MINI SHOULD CONSIDERED DOING AN INVESTIGATION AND EXTENDING THE RECALL TO OTHER YEAR MODELS INCLUDING MY 2012.

COILS CAUSED PROBLEM WITH ECU - RECALL IS OUT FOR SOME MODELS BUT NOT THIS ONE. NOW IT NEEDS NEW COILS AND NEW DME.