2008 MINI COOPER Complaints

THE TURBO OIL FEED LINE IS INHERENTLY FLAWED AND PREMATURELY FAILS BECAUSE OF A BAD DESIGN. THIS FAILURE CAUSES HOT OIL TO LEAK ALL OVER A HOT TURBO. I WAS LUCKY ENOUGH TO NOT HAVE MY ENGINE CATCH FIRE WITH THE FAILED O-RING ON MINE. I WAS DRIVING ON THE HIGHWAY WHEN LARGE CLOUDS OF SMOKE BEGIN TO FLOW FROM THE ENGINE COMPARTMENT. I WAS FORCED TO PULL OVER AND GET TOWED HOME. I WAS OUT OF WARRANTY BUT STILL VERY LOW MILEAGE (48K) WHEN MINE FAILED. *TR

IN SEPTEMBER, 2013, MY 2008 MINI COOPER HARDTOP, WITH THE N12 ENGINE, HAD THE TIMING CHAIN FAIL UNDER OPERATION. THIS CAUSED THE ENGINE TO STOP, AT HIGHWAY SPEED, AFFECTING STEERING, BRAKING AND ALL ABILITY TO MANEUVER THE VEHICLE OUT OF TRAFFIC. TWO VEHICLES BARELY AVOIDED MY DISABLED VEHICLE. I CONTACTED MINI USA AND THEY REFUSED TO ACKNOWLEDGE THE FACTORY DEFECT IN THE TIMING-CHAIN TENSIONER THAT CAUSES THE TIMING CHAIN TO FAIL. I PAID OVER $8000 FOR A REPLACEMENT N12 ENGINE. WITH LESS THAN 10,000 MILES ON THE REPLACEMENT ENGINE, IN JULY, 2016, THE TIMING CHAIN FAILED AGAIN. THIS TIME THE VEHICLE WAS CROSSING A BRIDGE AND THERE WAS NO PLACE TO TRY TO PULL OFF. THE SITUATION WAS VERY DANGEROUS AND LEFT MY FAMILY VULNERABLE TO ONCOMING TRAFFIC. I CONTACTED MINI USA AGAIN, AND ALTHOUGH THEY HAVE ADMITTED TO THE TIMING CHAIN DEFECT ON THEIR N14 ENGINE, IN THE S SERIES VEHICLE, THEY STILL REFUSE TO ISSUE A RECALL FOR THE N12 ENGINES IN WHICH THE TIMING CHAIN FAILURES ARE MORE NUMEROUS. THIS DEFECT CAUSES THE VEHICLE TO BECOME INOPERABLE AT SPEED WHICH IS UNSAFE IN THE EXTREME. MINI USA NEEDS TO ISSUE A SAFETY RECALL FOR EVERY VEHICLE EQUIPPED WITH THE N12 ENGINES.

AIRBAG WARNING LIGHT ON BECAUSE OF FAULTY PASSENGER SIDE SEAT MAT SENSOR. AIRBAGS ARE DISABLED WITHOUT REPAIR/REPLACEMENT.

PRISTINE CONDITION, LOW MILEAGE, DEALER SERVICED MINI COOPER S (OWNED SINCE NEW) BEGAN EXHIBITING A RATTLING NOISE FROM ENGINE AT 34K MILES. DEALER DIAGNOSED IT AS A TIMING CHAIN DEFECT AND TIMING CHAIN TENSIONER DEFECT. THIS IS A KNOWN ENGINE DEFECT. REFERENCE CLASS ACTION SUIT AND SETTLEMENT 338403. THIS SETTLEMENT BY BMW/MINI USA COVERS THIS FLAW AND BMW/MINI KNOWS THAT VEHICLES PRODUCED WITHIN THE 2007-2010 TIMEFRAME HAVE THIS FLAW. THIS FLAW CAN RESULT IN CATASTROPHIC ENGINE FAILURE. IN MY CASE, IT WAS NOISY UNDER ACCELERATION, AND WAS INTO THE DEALER FOR SERVICE WITHIN DAYS OF FIRST ISSUE. THIS IS A KNOWN FLAW. HOWEVER, BMW/MINI SETTLED THE CLASS ACTION LAWSUIT AND SET ASIDE MILLIONS OF DOLLARS FOR CLAIMS....BUT THOSE CLAIMS MUST BE FILED BY 7/1/16. I DID NOT HAVE THE ISSUE BEFORE THAT DATE, I HAD IT HAPPEN IN SEPTEMBER 2016 - TWO MONTHS LATER. I HAVE REQUESTED SOME ACCOMMODATION FROM BMW/MINI, HOWEVER THEY ARE REFUSING TO PARTICIPATE AT ANY LEVEL, EVEN THOUGH THEY KNOW THIS WAS A FLAWED PART AND COULD HAVE CAUSED SIGNIFICANT DAMAGE. I AM NOT EXPECTING FULL REIMBURSEMENT, BUT IF THEY KNOW THE CAR HAS A MAJOR FLAW, THEY SHOULD HAVE SOME COVERAGE IN PLACE FOR ANY OF THESE VEHICLES WITH THE FLAW. THUS FAR THE REGIONAL SERVICE MANAGER AND MINI USA HAVE INDICATED BECAUSE THIS HAPPENED AFTER 7/1/16 THEY WILL NOT ACCOMMODATE.

FUEL SMELL STARTED TO GET STRONGER IN THE CABIN AND OUTSIDE OF THE VEHICLE, BUT DID NOT SEE ANY LEAKS ON THE FLOOR TILL TODAY. I ALSO NOTICE THE GREEN TEMPERATURE NOTIFICATION COME ON TODAY. I HAD MY OIL CHANGED AT THE BMW/MINI DEALER IN ONTARIO LAST MONTH.

STARTING AROUND 65,000 MILES PASSENGER AIRBAG SENSOR APPEARED ON THE DASHBOARD WHEN CAR WOULD BE TURNED ON AND WOULD REMAIN ON WHILE DRIVING EVEN THOUGH NO ONE WAS IN THE PASSENGER SEAT. HAD IT CHECKED BY LOCAL MINI WORKSHOP AND THEY SAID IT WAS DUE TO THE DEFECTIVE PASSENGER AIRBAG MAT IN 2001-2008 MODELS. THEY LOOKED UP MY CAR FOR RECALL USING MY VIN AND MY CAR WAS NOT INCLUDED, THOUGH THE 2008 COOPER S CONVERTIBLE THAT USES THE SAME EXACT PART WAS INCLUDED. THIS MAKES ABSOLUTELY NO SENSE WHATSOEVER. THIS IS A SAFETY RECALL!! ALL MODELS SHOULD BE INCLUDED SINCE ALL MODELS HAVE THE PROBLEM!! IT IS COMPLETELY ABSURD THAT MINI WOULD PICK AND CHOOSE WHICH OF THEIR CUSTOMER'S LIVES THEY WANT TO SAVE. I AM BEING QUOTED BETWEEN $700 AND $1200 TO GET THIS ISSUE FIXED. MINI SHOULD FOOT THAT BILL; THEY INSTALLED A DEFECTIVE PART THAT IS CRUCIAL IN THE SAFETY OF THEIR CUSTOMERS AND THEY NEED TO OWN UP TO IT.

TAKATA RECALL?? THE SEAT OCCUPANCY SENSOR MALFUNCTIONS - 3 WARNING LIGHTS - ALWAYS ON. TOOK MINI INTO DEALERSHIP FOR THIS PROBLEM ON 9/17/15. THEY DIAGNOSED: J# 1 511MZOTHERDIAG GENERAL DIAGNOSIS VEHICLE NEEDS RIGHT SEAT WEIGHT SENSOR REPLACED. PART NEEDS TO BE ORDERED - $1493.47 PART COST - CUSTOMER ADVISED. NEITHER BMW/MINI CORPORATE OR THE DEALERSHIP CAN SAY WHEN THE REPLACEMENT PART WILL BE AVAILABLE - NOR CAN THEY GUARANTEE OCCUPANT SAFETY - AIRBAGS MAY NOT DEPLOY THERE IS AN ACCIDENT. THE MILEAGE ON THE MINI IS 26,959. WHEN IS THIS VEHICLE TO BE INCLUDED IN THE RECALL? AND WHEN WILL THE PARTS BE AVAILABLE TO FIX IT?

TIMING CHAIN JUMPED OFF OF DEAD CENTER. HAD TO REPLACE TIMING CHAIR TO NEW UPGRADED ASSEMBLY. COST WAS AROUND $1200.00. UPSET BECAUSE THIS HAS BEEN HAPPENING TO A LOT OF MINI COOPERS. SHOULD HAVE SOME KIND OF RECALL TO CONSUMERS. BMW KNOWS ABOUT THIS.WAS DRIVING HOME FROM OUT OF STATE.

SRS COMPUTER AND SENSORS ARE FAILING. NO ACCIDENT, NO FLOODING JUST FAILING SENSORS AND COMPUTER. MINI CLAIMS THIS IS A "MAINTENANCE" ITEM, YET THERE IS NO DOCUMENTED MAINTENANCE PROTOCOL FOR THESE ITEMS. VEHICLE HAS LESS THAN 100K MILES AND AIR BAG SYSTEM COMPONENTS ARE FAILING. HENCE WE DON'T KNOW IF THE SYSTEM WILL WORK OR NOT AND THE VEHICLE WILL NOT PASS OUR STATE INSPECTION.

PASSENGER SIDE AIR BAG LIGHT STARTED BY INTERMITTENLY TURNING ON> NOW ITS IS ON ALL THE TIME. SAME ISSUE AS OTHER MINI COOPERS THAT HAVE BEEN RECALLED. WAS TOLD I HAVE TO REPLACE THE SENSOR SEAT MAT. THIS REPAIR SHOULD BE COVERED BY MINI (BMW).