2011 MINI COOPER Complaints

Set Belt and Airbag Warning lights came light up for no reason and the computer got a hard code that cannot be reset (ACSM - Crash Safety Module, 93C3, OC3). This will be put in a Safety Risk if the car gets in an accident.

The contact owns a 2011 Mini Cooper S. The contact received a recall notification for NHTSA Campaign Number: 18V248000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

ON 05/06/2021, I PURCHASED A USED 2011 MINI COOPER S TURBO. TWO DAYS LATER, I WENT TO START THE CAR, AND IMMEDIATELY SMELLED SOMETHING ELECTRICAL BURNING. WHEN I LIFTED UP HOOD, I COULD SEE SMOKE COMING FROM INSIDE THE ENGINE. I IMMEDIATELY UNHOOKED THE TWO BATTERY CABLES. I CALLED THE CAR LOT THAT I PURCHASED THE VEHICLE, AND WAS TOLD THAT THAT YEAR MINI HAD ISSUES WITH A COMPUTER BOARD OVERHEATING PAND SOMETIMES EVEN STARTING FIRES EVEN WHEN THE CAR ISN'T RUNNING. I HAVE A MEHANIC SCHEDULED FOR MONDAY TO REPAIR THE CAR.

THE PASSENGERS SEAT OCCUPANCY DETECTOR IS NOT FUNCTIONING AND IT WON'T ALLOW ANY AIRBAG TO ACTIVATE. THE PASSENGER AIRBAG LIGHT IS CONSTANTLY ON AND IT IS A SAFETY HAZARD. THIS IS A COMMON PROBLEM WITH THESE CARS, AND NO RECALL HAS BEEN ISSUED.

THE COOLANT THERMOSTAT HOUSING IS ALWAYS MAKING A PROBLEM. I SEE THERE IS EXTENDED WARRANTY ON OTHER YEARS MODEL. BUT IT HAS TO BE INCLUDED MY VEHICLE'S YEAR. THEY USES SAME THERMOSTAT HOUSING AND MAKING A SAME PROBLEM. LEAKS OR IT STUCK OPENED/CLOSED VERY EASILY. WITHIN A 3 YEARS I NEED TO CHANGE THE THERMOSTAT HOUSING/ TIMES WITH OEM PART. FIRST TIME IT MAKES A PROBLEM AT AROUND 90000 MILES.

TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT WHILE PARKED, THE CONTACT ATTEMPTED TO PULL DOWN THE FRONT DRIVER SIDE SUN VISOR AND THE CLIP FRACTURED CAUSING THE INTERIOR LIGHT TO REMAIN ILLUMINATED. THE VEHICLE WAS TAKEN TO BRAMAN MOTORCARS (2801 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33409) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,462.

THE PASSENGER AIRBAG WARNING LIGHT INDICATING THE PASSENGER SIDE AIRBAG IS DISABLED EVEN IF PASSENGER IS SEATED. OUR MECHANIC TELLS US THE ON-BOARD COMPUTER SYSTEM NO LONGER RECOGNIZES THE PASSENGER FRONT AIRBAG SENSOR. CONSEQUENTIALLY, THE AIRBAGS ARE BEING DISABLED ON BOTH PASSENGER AND DRIVER SIDE OF THE CAR.

EXHAUST VANOS SOLENOID FAILURE 06/12/2019. THIS IS A COMMON ISSUE TO MINI'S AND BMW'S THAT OCCURS ON A REGULAR BASIS WHICH INTERRUPTS THE POLLUTION CONTROL SYSTEM. BMW WHO MANUFACTURES THE PART HAS EXTENDED THE WARRANTY FOR THIS PART ON BMW'S TO 10 YEARS BUT HAS NOT YET ADDRESSED ALL THE ISSUES THAT MINI OWNERS HAVE HAD WITH THE PARTICULAR PART. THERE ARE TWO IN THE ENGINE AND THEY ARE IDENTICAL (INTAKE/EXHAUST) COST TO REPLACE IS OVER $500. WHY DOES BMW GET A REPLACEMENT AND MINI OWNERS HAVE TO PAY. THE CAR GOES INTO A LIMP MODE WHEN FAILURE OCCURS, SO STILL DRIVABLE BUT AT REDUCED POWER. THIS IS A COMMON ISSUE AND PREVALENT IN BOTH MINI FORUMS AND BMW FORUMS. THE WARRANTY SHOULD BE EXTENDED FOR MINI OWNERS PART # 11-36-8-610-388. IT IS A DEFECTIVE DESIGN BY THE MANUFACTURER.

THERMOSTAT & HOUSING PLUS WATER PUMP HAVE BEEN REPLACED. CAR STILL RUNS TEMPS IN EXCESS OF 230 BEFORE FAN WILL COME ON. I AM FEARFUL THE ENGINE MAY GET ON FIRE DUE TO HEAT AND THEREFORE, I AM NOT DRIVING IT. TOOK IT TO THE DEALER AND THEY REMOVED 2 RELAYS, ONE OF WHICH CONTROLLED THE ENGINE FAN. I REPLACED THE RELAY.

AIRBAG LIGHT INDICATING FAULTY DEVICE. THE INDICATIONS STARTED TO APPEARS RANDOMLY AND MOST FOR THE PASSENGER SEAT HOWEVER TODAY IS ON ALL TIME.