2006 MINI COOPER S Complaints

PLETHORA OF ELECTRICAL PROBLEMS. HEATED SEATS ARE A MAJOR CONCERN. THEY GO ON AND OFF BY THEMSELVES, SEEM HAUNTED. SOMETIMES, THEY GET SO HOT THEY LEAVE BURN MARKS IN MY LEGS. I AM AFRAID OF AN ELECTRICAL FIRE. THE HEATED SEATS GET SO HOT, THEY LEFT BURN MARKS IN MY SEAT. AISIN 6 SPEED AUTOMATIC TRANSMISSION, EQUIPPED WITH "LIFETIME" FLUID, BEGINS SLIPPING GEARS AT 70K THE SUPERCHARGER HAD TO BE REPLACED DUE TO THE "DESIGN" OF THE SUPERCHARGER IT COULD NOT BE REPAIRED, I WAS FORCED BY BMWUSA TO PURCHASE A REMANUFACTURED SUPERCHARGER. I WAS TOLD IT WAS A "COMMON PROBLEM" I HAVE ALSO FOUND OUT FROM FORUMS SUCH AS NORTHAMERICANMOTORING.COM THIS IS A PROBLEM THAT BMW DOES NOT WANT TO ADMIT ITS AT FAULT FOR HOWEVER THEY ARE ACKNOWLEDGING THE WIDESPREAD HAPPENINGS ACROSS THE COUNTRY. THE AVAILABILITY OF NEW SUPERCHARGERS IS VERY LOW BECAUSE OF THIS PROBLEM, HENCE ME PURCHASING A REMFGD ONE. REAR WIPER MOTOR FAILED AT 40K QUOTED HUNDREDS TO REPLACE, NOT WORTH IT!!!!! *TR

ON 29SEP2007, MY 2006 MINI COOPER S WAS SERVICED TO PERFORM THE LOW MILEAGE SERVICE AT 3,354 MILES. THE CAR WAS NOT DRIVEN ON 30SEP2007. ON 01OCT2007, THE CAR WAS DRIVEN A DISTANCE OF APPROXIMATELY ONE MILE EACH WAY TO A BUS STOP. THE CAR WAS PARKED OVERNIGHT IN THE GARAGE BENEATH MY TOWNHOUSE. AT 6:00 AM ON 02OCT2007, WHEN I WANT TO THE LOWER LEVEL OF MY TOWNHOUSE AND OPENED THE DOOR TO THE GARAGE, I SAW THAT THE GARAGE WAS FILLED A "FOGGY SMOKE" AND THERE WAS A "BURNING ODOR". THE POLICE WERE CALLED TO INVESTIGATE THE CAUSE OF THE SMOKE. AS THE SMOKE BEGAN TO SPREAD INTO THE UPPER LEVEL OF MY HOME, THE FIRE DEPT WAS CALLED AS BACK-UP. THE FIREMEN LOCATED THE SOURCE UNDER THE HOOD OF MY CAR AND DETERMINED THE SMOKE TO BE FROM A "BURNED POWER STEERING BELTON THE VEHICLE IN THE GARAGE". THE FIREMEN MOVED THE CAR TO THE PARKING LOT AND DISCONNECTED THE BATTERY. I WAS INSTRUCTED TO HAVE THE CAR TOWED TO THE DEALERSHIP. I TOLD THE DEALERSHIP THAT THIS VEHICLE WAS DEFECTIVE AND WOULD NO LONGER FEEL SAFE DIVING THE CAR. THEY AGREED TO REPLACE THE CAR WITH A NEW 2007 MINI COOPER S ([XXX]). I WAS LED TO BELIEVE THAT MINE WAS AN "ISOLATED INCIDENT" BUT HAVE NOW BECOME AWARE THAT OTHERS HAVE HAD SIMILAR PROBLEMS WITH MINI COOPER S FROM 2007-2009. WHEN I CONTACTED THE DEALER, I WAS ADVISED TO NOT PARK MY CAR IN THE GARAGE UNTIL THE CAUSE OF THE PROBLEM HAS BEEN DETERMINED OR IF THERE IS A RECALL. I NOW AM NOT PARKING IN THE GARAGE. I AM SUBMITTING THIS REPORT ON THE 2007 INCIDENT SINCE IT WAS NEVER REPORTED AND I AM AFRAID THAT THE RATE OF OCCURRENCE MAY BE UNDER-REPORTED. THANK YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE PASSENGER SEAT AIR BAG WARNING LIGHT IS ON ALL THE TIME, INDICATING LESS THAN 25 LBS IS ON THE SEAT, EVEN THOUGH THERE IS NOTHING ON THE SEAT. *TR

MY WIFE NOTICED AN UNUSUAL ELECTRICAL HUMMING NOISE THAT RAPIDLY BECAME PROGRESSIVELY LOUDER COMING FROM SOMEWHERE IN THE ENGINE COMPARTMENT WHEN THE CAR WAS RUNNING. VERY QUICKLY IT BECAME HARDER AND HARDER TO STEER UNTIL IT FELT LIKE THERE WAS NO ASSISTED STEERING AT ALL. SHE HAS NOT BEEN ABLE TO DRIVE IT SINCE. RECENTLY WENT TO A MINI DEALERSHIP TO HAVE IT CHECKED OUT WITH THE RESULT THAT THEY SAID THE PUMP DID INDEED FAIL. NO RECALL HAS BEEN ISSUED AS OF YET, EVEN THOUGH THIS SEEMS TO BE A WIDESPREAD PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 MINI COPPER S CONVERTIBLE. WHILE DRIVING APPROXIMATELY 45 MPH THE VEHICLE DECELERATED AND THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE VEHICLE OVERHEATED AND STALLED. THE VEHICLE WAS TOWED TO THE CONTACTS HOME. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.

THE AIRBAG SENSOR LIGHT ALONG WITH THE SEATBELT LIGHT STAYS ON CONSTANTLY FROM STARTUP.TRIED TO RESET BY INSTRUCTIONS IN THE OWNERS MANUAL BUT DIDN'T WORK.MINI SERVICE WANTS 100.00 TO JUST EVALUATE THE PROBLEM.THE PROBLEM IS THAT MINI /BMW KNOW THERE IS DEFAULT WITH THE SEAT SENSORS BUT WON'T TAKE ON RESPONSIBILITY AS THE CAR OWNERS ARE PAYING $1500-2200 + TO HAVE THIS REPAIRED. THIS IS A VERY SERIOUS SAFETY ISSUE AS NONE OF THE AIRBAGS WILL WORK IN THE CAR AT THIS POINT. *TR

WHILE DRIVING THE AIRBAG WARNING LIGHT CAME ON AND PASSENGER AIR BAG LIGHT TURNED OFF. AT THE SAME TIME THE SEAT BELT LIGHT CAME ON. HAD BOTH CHECKED AND WHEN CAR WAS RETURNED BOTH LIGHTS WERE OUT. PASSENGER SEAT BOTTOM WAS REPLACED. I WAS TOLD THAT THIS IS COMMON PROBLEM WITH THE SEAT BOTTOM. NO PROBLEM NOTED FOR THE SEAT BELT LIGHT. 1/2 MILE FROM DEALER BOTH WARNING LIGHTS AGAIN TURNED ON AND THE PASSENGER AIR BAG LIGHT TURNED OFF. AT THIS POINT I AM NOT SURE IF THE CAR IS SAFE TO DRIVE OR NOT.

I HAVE A 2006 MINI COOPER. RECENTLY, COMPLETE POWER TO THE VEHICLE HAS BEEN LOST WHILE THE VEHICLE IS IN OPERATION. THIS HAS OCCURRED TWICE OVER THE PAST MONTH. THE VEHICLE WAS BEING OPERATED ON A PAVED CITY STREET AT SPEEDS OF APPROXIMATELY 20-25 MILES PER HOUR WHEN THE POWER FAILURES OCCURRED. THE VEHICLE WAS REQUIRED TO BE BROUGHT TO A COMPLETE STOP BEFORE POWER TO THE VEHICLE COULD BE RESTORED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED MINI COOPER REPAIR CENTER (NIELLO MINI, SACRAMENTO, CA) ON 07/26/11. THE DEALERSHIP COULD FIND NO FAULTS WITH THE VEHICLE AND HAD US DRIVE THE VEHICLE OFF THE LOT "AS IS" WITH INSTRUCTIONS TO BRING IT BACK IN FOR FURTHER TESTING IF THE PROBLEM HAPPENED AGAIN. NEXT TIME COULD BE TOO LATE AS THIS PROBLEM COULD CAUSE AN ACCIDENT TO OCCUR. *TR

A PROBLEM DEVELOPED WITH THE STEERING WHEEL OF MY MINI COOPER "S" (2006). THE PROBLEM STARTED SOMEWHAT GRADUALLY, OVER A PERIOD OF SEVERAL DAYS TO A WEEK, DURING WHICH THE WHEEL BECAME MORE AND MORE DIFFICULT TO TURN. MY VEHICLE HAS NEVER BEEN IN AN ACCIDENT OR IN ANY SORT OF INCIDENT. IT HAS LESS THAN THIRTY-FIVE THOUSAND MILES ON IT. I TOOK MY MINI TO AN AUTHORIZED MINI-COOPER REPAIR FACILITY WHO INFORMED ME THAT THE KNOCK (SP?) SENSOR AND STEERING MOTOR HAD FAILED AND NEEDED REPLACEMENT. THIS WAS AT A COST OF APPROXIMATELY $2,000.00 DOLLARS, HOWEVER IT DID NOT RESOLVE THE ISSUE. THE STEERING WHEEL CONTINUES TO BE SLUGGISH AND DIFFICULT TO MANEUVER. IT IS MY BELIEF THAT WHATEVER IS WRONG WITH THE STEERING IS A DESIGN FLAW, AS NO CAR WITH LESS THAN THIRTY-FIVE THOUSAND MILES ON IT SHOULD EXHIBIT SUCH A STRANGE AND CRITICAL FAILURE. *TR

AIR BAG FAILURE LAMP LIGHT ON. 2006 JCW MINI COOPER. ON STARTUP, LAMPS ALL GO THROUGH STARTUP ILLUMINATION THEN GO DARK. AIRBAG FAILURE LAMP RELIGHTS 1 SECOND LATER AND REMAINS ON. NO INTERIOR WIRING DONE, CAR IS AS WAS RECEIVED NEW FROM DEALER. *TR