2005 MINI COOPER S Complaints

SOMETIME IN LATE SUMMER OF LAST YEAR, MY CAR BEGAN TO MAKE A "HONKING" SOUND. IT SOUNDED LIKE THE CLUTCH THAT HAD ALREADY BEEN REPLACED ON BOTH OF OUR 2005 MINI COOPERS UNDER WARRANTY (ANOTHER POSSIBLE SAFETY ISSUE?) BUT THE CLUTCHING SEEMED OK. UP UNTIL THE TIME I WAS ABLE TO GET THE CAR IN TO THE SHOP TO GET LOOKED AT, I NOTICED A PUDDLE IN THE GARAGE, AND I ALSO NOTICED IT WAS GETTING HARDER TO STEER. THE SHOP DETERMINED THAT MY STEERING RACK WAS LEAKING AND NEEDED TO BE COMPLETELY REPLACED, WHICH WE DID. NOW, JUST OVER 1 YEAR LATER, THE CAR IS ALREADY EXHIBITING THE SAME BEHAVIORS EXACTLY. SOMETHING IN THE VEHICLE IS CAUSING THE RACK TO MALFUNCTION AND REQUIRE REPLACEMENT. *TR

THE POWER STEERING PUMP IN MY 2005 MINI COOPER S CONVERTIBLE INTERMITTENTLY STOPS WORKING 1 TO 5 TIMES PER WEEK. THERE DOES NOT APPEAR TO BE ANY PATTERN TO IT, IT HAS HAPPENED AT COLD START, AFTER WARM START, HOT/COLD/WET/DRY WEATHER, LEVEL/SLOPED PARKING, WHILE DRIVING & STATIONARY, ETC. I'VE LEARNED TO LIVE WITH IT AS AN ANNOYANCE, UNTIL I RECENTLY HAD A VERY FRIGHTENING FAILURE THAT VERY NEARLY HAD *FATAL* CONSEQUENCES. I WAS DRIVING ROUGHLY 25 MPH, THE POSTED SPEED LIMIT, IN A RESIDENTIAL AREA, WHEN A YOUNG CHILD (I ESTIMATE 4-5 YEARS OLD) RAN INTO THE STREET FROM BETWEEN TWO PARKED CARS 5 OR 6 CAR LENGTHS IN FRONT OF ME. I SLAMMED ON THE BRAKES (ABS FULLY ENGAGED) AND ATTEMPTED TO SWERVE INTO THE ONCOMING [EMPTY] LANE AT AVOID... BUT MY STEERING PUMP WAS OUT AND I COULD NOT ALTER MY COURSE SUFFICIENTLY. I CAME TO A STOP WITH THE CHILD BARELY THREE FEET OFF MY FRONT BUMPER! SO NO DAMAGE OR INJURY, BUT... THIS FAILURE COULD EASILY HAVE BEEN MUCH, MUCH WORSE! *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WARNING LIGHT ILLUMINATED AT ENGINE START UP. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED TO THE CONTACT THAT THE OCCUPANCY SENSOR FAILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000 AND THE CURRENT MILEAGE WAS 41,000.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL BECAME DIFFICULT TO STEER AND SEIZED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE VIN WAS NOT AVAILABLE.THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING 30 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MOVE WHEN THE CONTACT NOTICED A BURNING ODOR. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE HE WAS INFORMED THAT THE ELECTRIC POWER STEERING COMPONENT HAD MELTED AND NEEDED TO BE REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THERE WAS A CONCURRENT INVESTIGATION FOR THE FAILURE HOWEVER, THERE WERE NO RECALLS. THE MANUFACTURER OFFERED NO FURTHER ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT AND THE FAILURE MILEAGES WERE 63,260. UPDATED 12/20/11*LJ THE CONSUMER WAS INFORMED THE POWER STEERING UNIT HAD SUFFERED A COMPLETE MELT DOWN WHICH SPREAD TO THE POWER STEERING HOSE AND WIRING HARNESS. UPDATED 01/20/12

POWER STEERING FOR THE LAST YEAR OR SO ONLY WORKS A FRACTION OF THE TIME. THE FIRST TIME IT WENT OUT WAS WHILE DRIVING ON THE FREEWAY. LAST WEEKEND IT STOPPED WORKING AND DIDN'T WORK AGAIN FOR A FULL WEEK. VERY HARD TO DRIVE THIS VEHICLE WHEN IT GOES OUT UNEXPECTEDLY. *KB

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING APPROXIMATELY 35 MPH, THE PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE FAILURE OCCURRED WHENEVER THE ENGINE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE FRONT PASSENGER SEAT SENSOR PAD WAS FAULTY AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM IN WHICH THERE WAS NO RESOLUTION. THE APPROXIMATE FAILURE MILEAGE WAS 41,000.

IN THE EARLY FALL, SEPTEMBER 2011, I ENCOUNTERED ISSUES WITH MY CAR NOT SHIFTING PROPERLY. IT'S AN AUTOMATIC TRANSMISSION SO I KNOW THERE WAS NOTHING I COULD BE DOING TO CAUSE THIS PROBLEM. THE CAR HAS BEEN SERVICED REGULARLY AND DRIVEN WITH CARE WHILE IN MY POSSESSION(I'M THE SECOND OWNER. NO SIMILAR ISSUES ON CARFAX REPORT). WHILE THE ENGINE IS COOL AND NOT YET AT ITS OPTIMAL TEMPERATURE THE DRIVE IS FINE AND YOU MAY NOT EVEN NOTICE A PROBLEM; HOWEVER, EVERY RIDE, ONCE WARMED UP THE CAR BEGINS TO SHIFT INCREDIBLY VIOLENTLY AS IT IS OBVIOUSLY STRUGGLING TO SWITCH GEARS. THIS OCCURS ALSO WHILE SLOWING DOWN AND THE CAR IS DOWNSHIFTING CREATING AN OPPORTUNITY TO BE "SLUNG" INTO A CAR FROM BEHIND(THIS HAPPENED IN THE MID SUMMER OF 2011). AFTER DROPPING THIS CAR OFF SEPTEMBER 15TH TO THE LOCAL MINI DEALERSHIP, I DID NOT HEAR FROM THEM FOR ALMOST THREE WEEKS. IN THE FIRST WEEK OF OCTOBER I WAS CONTACTED AND TOLD IT LOOKS LIKE MY CAR IS VERY EASILY FIXABLE AND SHOULD BE READY SHORTLY. IT WAS EXPLAINED TO ME THAT A SEAL HAD BROKEN ON THE TRANSMISSION LEAKING FLUID ONTO IT CAUSING THIS SHIFTING MALFUNCTION. WHEN THEY FINALLY TOLD ME I CAN PICK UP MY CAR(APPROXIMATELY OCTOBER 18TH) THEY REGRETTED TO INFORM ME THE PROBLEM WAS NOT ABLE TO BE FIXED AND I WOULD HAVE TO BRING IT ELSEWHERE AS THEY DO NOT REBUILD TRANSMISSIONS. NOW IT IS BACK IN MY POSSESSION WHERE I AM FORCED TO COMMUTE IN IT DAILY, DRIVING WORSE THAN IT WAS BEFORE I DROPPED IT OFF. IT NOW DISPLAYS "PE" FOR ITS CURRENT GEAR FROM TIME TO TIME. THIS IS NOT THE ONLY COMPLAINT I HAVE FILED FOR THIS CAR MATCHING OTHER CONSUMER COMPLAINTS. I AM A VICTIM OF THEIR FAILED POWER STEERING AS WELL. *TR

I WAS DRIVING DOWN BROOKWOOD STREET AND WENT TO MAKE A CURVE WHEN I REALIZED THAT I COULDN'T TURN THE CAR. I WAS ABLE TO PULL HARDER ON THE WHEEL AND MAKE THE CURVE. I PULLED OVER AND TURNED THE CAR OFF TO LOOK THINGS OVER,CHECKED THE POWER STEERING FLUID WHICH WAS FULL. I RESTARTED THE CAR AND THE STEERING WORKED AGAIN.I FINISHED DRIVING TO WORK WITH NO PROBLEMS. WHEN I CAME OUT OF WORK I AGAIN HAD NO POWER STEERING AND HAD THE CAR TOWED INTO A SHOP WHERE THEY TOLD ME THE POWER STEERING PUMP HAD FAILED AND IT WAS GOING TO COST OVER $1300 TO FIX. I HAD THE REPAIR DONE BUT AM AFRAID TO DRIVE THE CAR AS THEY TOLD ME IT COULD HAPPEN AGAIN EVEN WITH THE NEW PART. *TR

TEMPORARY LOSS OF POWER STEERING. AFTER DRIVING FOR ABOUT 2 HOURS, I STOPPED TO FILL UP AT A GAS STATION. I THEN STARTED THE CAR AND BEGAN TO DRIVE OUT OF THE GAS STATION. I SOON NOTICED THE POWER STEERING WAS NOT WORKING. I PULLED INTO A PARKING SPACE, OPENED THE HOOD, AND PROCEEDED TO CHECK THE POWER STEERING FLUID. THE POWER STEERING FLUID RESERVOIR WAS FULL. I RESTARTED THE CAR AFTER ABOUT 5 MINUTES AND THE POWER STEERING WAS WORKING AGAIN. THIS TEMPORARY POWER STEERING LOSS HAS OCCURRED 3 MORE TIMES OVER THE LAST MONTH SINCE THE INITIAL INCIDENT DESCRIBED ABOVE. DURING THE LAST OCCURRENCE, I DROVE A SHORT DISTANCE BACK TO MY HOME WITH NO POWER STEERING. I'D LIKE TO POINT OUT STEERING WAS VERY DIFFICULT, NEARLY UNDRIVEABLE AROUND SLOW SPEED TURNS. THE STEERING EFFORT WAS MUCH MORE THAN MANUAL STEERING CARS I'VE OWNED IN THE PAST. *TR