2003 MINI COOPER S Complaints

5/18/13 - AFTER PARKING THE CAR, THE POWER STEERING PUMP CONTINUED TO OPERATE WHEN THE KEY WAS REMOVED FROM THE IGNITION. THE KEY WAS INSERTED BACK INTO THE IGNITION SWITCH AND TURNED TO THE "ON" POSITION. THE POWER STEERING PUMP STOPPED RUNNING. 5/28/13 - WHEN RETURNING TO WORK AFTER LUNCH THE CAR STARTED PERFECTLY AND NO PROBLEMS WERE APPARENT. I PULLED UP TO A STOP LIGHT AND SAT WAITING ON THE LIGHT TO TURN GREEN. WHEN THE LIGHT CHANGED I STARTED ACCELERATING IN 1ST GEAR AND NOTICED THAT THE STEERING WAS VERY HEAVY. I IMMEDIATELY PULLED OVER TO MAKE SURE THAT THE PUMP WAS NOT OVERHEATING. THE PUMP HAS COMPLETELY FAILED AT THIS POINT AND THE CAR IS ABLE TO DRIVE, ALBEIT DANGEROUSLY. *TR

THE POWER STEERING PUMP DOESN'T SHUT OFF WHEN THE CAR DOES. THE PUMP RAN UNTIL THE BATTERY DIED. *TR

I WAS CHANGING LANES TO PREPARE TO EXIT OFF THE INTERSTATE WHILE ON MY WAY TO WORK. AS I MADE THE LANE CHANGE NOTICED STEERING WAS TIGHTER. AFTER EXITING THE INTERSTATE, THE VEHICLE WAS VERY HARD TO STEER AT THE TOP OF THE EXIT RAMP. THE TURN MADE WAS VERY WIDE NEARLY MISSING ONCOMING TRAFFIC. SUSPECT POWER STEERING PUMP HAS FAILED. *TR

IN SEPTEMBER 2011, I WAS DRIVING MY 2003 MINI COOPER S AT 55MPH ON A RURAL TWO LANE HIGHWAY WHEN I EXPERIENCED A MOMENTARY LOSS POWER STEERING OF POWER STEERING. THIS RESULTED IN THE WHEEL BECOMING VERY DIFFICULT TO TURN. WHEN POWER STEERING RETURNED (WITHOUT WARNING), MY CAR SWERVED BUT I WAS ABLE TO KEEP IT ON THE ROAD. THIS HAPPENED SEVERAL TIMES OVER THE NEXT 20 MILES BEFORE I LOST POWER STEERING AND IT DID NOT RETURN.WHEN I ARRIVED HOME, I CHECKED THE POWER STEERING PUMP AND IT WAS NON-OPERATIONAL. I REPLACED THE PUMP AND ITS DEDICATED COOLING FAN. IN AUGUST 2012 (125000 MILES), I AGAIN LOST POWER STEERING AT HIGHWAY SPEEDS. THE SECOND FAILURE WAS IDENTICAL TO THE FIRST (SUDDENLY CAME AND WENT BEFORE CUTTING OUT AND NOT RETURNING). *TR

THE STEERING ON MY '03 MINI COOPER STARTED MAKING WHINING/ GROANING NOISES THAT WERE NOT THE NORMAL STEERING NOISES. THE STEERING HAS LIMITED POWER BOOST, SOMETIMES NEAR NORMAL, OTHER TIMES ALMOST NO BOOST. THE STEERING DOESN'T RETURN TO STRAIGHT AS IT USED TO. AFTER MAKING A RIGHT OR LEFT TURN, THE CAR KEEPS TRYING TO TURN THE LAST DIRECTION STEERED. WITH EFFORT, I CAN HOLD THE CAR STRAIGHT, BUT IT PULLS NOTICEABLY THE LAST DIRECTION TURNED. THE ELECTRIC STEERING MOTOR GROANS, CHANGING SPEED UP AND DOWN, EVEN WHEN THE CAR IS NOT MOVING. ALL FLUID LEVELS ARE NORMAL AND THERE ARE NO LEAKS OR DRIPS OF ANY FLUID. THE POWER STEERING FAN AND RADIATOR COOLING FAN ARE OPERATING CORRECTLY. THE STEERING EFFORT IS NOT CONSISTENT. SOMETIMES AT EXPRESSWAY SPEEDS, AS WELL AS SLOWER SURFACE STREET SPEEDS, THE STEERING STIFFENS UP WHERE IT REQUIRES MUCH EFFORT TO CONTROL, THEN MINUTES LATER, WILL GO BACK TO NORMAL BOOST LEVELS. THIS OFTEN HAPPENS WHEN NEGOTIATING LANE CHANGES OR EXPRESSWAY RAMPS WITH WHAT SHOULD BE A STEADY RATE TURN. AN INDEPENDENT MECHANIC STATES THE ELECTRO- HYDRAULIC STEERING PUMP IS CAUSING THESE ISSUES AND THAT BMW IS AWARE OF THIS PROBLEM. *TR

POWER STEERING PUMP IS BEGINNING TO FAIL. FROM REPORTS I HAVE READ I AM WORRIED THAT THE CAR WILL CATCH ON FIRE AND IN TURN CATCH MY HOUSE ON FIRE. *TR

PARKED VEHICLE IN HOME GARAGE AND THE POWER STEERING PUMP CONTINUED TO RUN EVEN WHEN KEY IS REMOVED. I WAS FAMILIAR WITH THIS ISSUE AS MANY OTHER OWNERS HAVE EXPERIENCED IT AND REPORTED. REFER TO NHTSA ACTION NUMBER : EA11005. THE PUMP WILL CONTINUE TO RUN UNTIL BATTERY DEPLETES OR FIRE OCCURS. THERE IS NO COOLING PROVIDED BY DEDICATED COOLING FAN WHEN VEHICLE IS OFF. I DISCONNECTED THE BATTERY TO STOP PUMP FROM OVERHEATING. *TR

DRIVING HOME FROM WORK GETTING OFF THE TURNPIKE TO TAKE MY EXIT RIGHT, MY 2003 MINI COOPER KEPT GOING STRAIGHT. VERY FRIGHTENING EXPERIENCE AS I COULD NOT TURN THE WHEEL COMING OFF HIGHWAY SPEEDS. THERE IS NO WARNING AT ALL WHEN THIS HAPPENS, YOU JUST CANNOT TURN THE WHEEL TO NEGOTIATE YOUR TURN. I'VE DRIVEN CARS WITHOUT POWER STEERING, BUT WHEN YOU HAVE AN ELECTRIC POWER STEERING FAILURE IT IS IMPOSSIBLE TO STEER THIS CAR. BMW MUST TAKE RESPONSIBILITY FOR THIS WELL DOCUMENTED DANGEROUS FAILURE AND DO THE RIGHT THING OR SOMEONE IS GOING TO GET SERIOUSLY HURT AND/OR HURT SOMEONE ELSE. COST TO FIX THE STEERING PUMP FAILURE - $1200.00. *TR

ELECTRIC POWER STEERING PUMP STOP FUNCTIONING WHILE DRIVING. SUDDEN LOST OF POWER STEERING. DIFFICULT TO STEER. THIS IS THE SECOND PUMP THAT WAS REPLACED ON THE VEHICLE ABOUT TWO YEARS AGO. THE FIRST PUMP STOP WORKING ABOUT TWO YEARS AGO. *TR

THE POWER STEERING PUMP FAILS CAUSING A LOSS OF POWER STEERING IN MY VEHICLE WHILE DRIVING. THIS SPORADICALLY OCCURS WHILE DRIVING CAUSING A SAFETY HAZARD AS IT BECOMES VERY DIFFICULT TO STEER THE VEHICLE. *TR