2012 MINI COOPER S Complaints

THE 2012 MINI COUNTRYMAN S ALL4'S TRANSFER CASE SEAL FOR THE REAR DRIVE SHAFT FAILED AT 39,000 MILES. THIS CAUSE THE INTERNAL GEARS TO FAIL AND THE TRANSFER CASE TO BE FULLY REPLACED. IT SHOULD BE KNOWN THE DEALER TRIED TO USE A REPLACEMENT SEAL AND IT ARRIVED DAMAGED AND UNUSABLE.

THERMOSTAT HOUSING BEGAN TO LEAK, THE PART IS PLASTIC AND HAD BECOME CRACKED UNDER NORMAL WEAR.

MY ENGINE LIGHT CAME ON AND WHILE ON THE FREEWAY, THE CAR SLOWED TO 19 MPH, THEN DIED. I WILL NEED A NEW TIMING CHAIN, ENGINE, AND MORE. THIS CAR IS NEW TO ME FROM A USED CAR DEALERSHIP.

TURBO COOLANT PUMP - LAST YEAR MY CAR SMELLED LIKE BURNT RUBBER AND SMOKE BEGAN COMING OUT OF THE TAILPIPES. THE SMOKE WAS SO BAD, THE CAR LOOKED LIKE IT WAS ON FIRE. I TOOK IT TO A BODY SHOP TO GET IT FIXED AND THE SMOKE STOPPED. ABOUT 9 MONTHS LATER, I WAS PARKED WITH THE CAR ON. THE RUBBER SMELL AND SMOKE APPEARED AGAIN. I TOOK IT TO A MECHANIC WHO SAID IT WAS THE COOLANT PUMP FOR THE TURBO. HE SAID THERE HAD BEEN A RECALL FOR IT. I LOOKED UP THE RECALL, BUT MY VIN WAS NOT INCLUDED. MY CAR IS HAVING THIS EXACT PROBLEM AND MINI WILL NOT FIX IT. IT COSTS $3300 FOR ME TO FIX, WHEN CLEARLY, IT IS A MINI MANUFACTURING PROBLEM.

THE CHECK ENGINE LIGHT CAME ON AT 55,005 MILES WHILE WE WERE DRIVING. WE TOOK IT TO BE SERVICED AND WERE TOLD THAT THE THERMOSTAT HOUSING /THERMOSTAT SENSOR NEEDED TO BE REPLACED BECAUSE IT WAS STUCK IN THE OPEN POSITION. THIS CAUSED THE CHECK ENGINE LIGHT TO BE ILLUMINATED. THEY MENTIONED THAT THERE WAS A RECALL FOR THIS PART DATED 8/5/2016 ON THE SAME MAKE, MODEL AND YEAR, BUT OUR VIN WAS NOT INCLUDED IN THE RECALL. HOW COULD THAT BE? THE CAR IS EXPERIENCING THE EXACT SAME ISSUE DESCRIBED IN THE RECALL. I WOULD LIKE TO HAVE SOMEONE CONTACT ME ABOUT THIS ISSUE.

TL* THE CONTACT OWNS A 2012 MINI COOPER S. THE CONTACT STATED THAT THE FRONT AND REAR DRIVER SIDE CARPET WAS WET. ALSO, WHILE DRIVING, THE SOUND OF WATER SWISHING AROUND COULD BE HEARD COMING FROM THE BOTTOM AND THE TOP OF THE VEHICLE. THE CONTACT ALSO MENTIONED THAT THE VEHICLE ALARM WOULD INDEPENDENTLY ACTIVATE. THE VEHICLE WAS TAKEN TO MINI OF MANHATTAN (793 11TH AVE, NEW YORK, NY 10019, (212) 586-6464), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 70,000.

VEHICLE HAD BEEN DRIVEN 24 MILES AND PARKED FOR ABOUT 10 MINUTES WHEN ENGINE COMPARTMENT CAUGHT FIRE. MASTER MECHANIC DIAGNOSED IT ORIGINATED WITH THE COOLANT PUMP AND CAUSED A SHORT CIRCUIT WITH THE ELECTRONICS OF THE PUMP IGNITING A FIRE.

TL* THE CONTACT OWNS A 2012 MINI COOPER S. WHILE ATTEMPTING TO EXIT THE VEHICLE, THE FRONT PASSENGER AND DRIVER SIDE AND THE REAR DRIVER SIDE DOORS FAILED TO OPEN WITHOUT WARNING. THE FAILURES RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DOOR ACTUATORS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED EXCEPT FOR THE REAR DRIVER SIDE DOOR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

ENGINE RATTLING NOISE (TIMING CHAIN AND TENSIONER) AT ALL TIMES, VEHICLE HAS ONLY 50,000 MILES

TL* THE CONTACT OWNS A 2012 MINI COOPER S. THE CONTACT STATED THAT WHILE HAVING MAINTENANCE PERFORMED, THE CONTACT WAS NOTIFIED THAT THREE OF THE FOUR TIRE RIMS WERE CRACKED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE THREE TIRE RIMS WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 44,342. DATED 01/23/15*LJ UPDATED 9/7/2017*CN