2006 MINI COOPER S Complaints

PASSENGER AIR BAG WARNING LIGHT STAYS ON ALL THE TIME. DEALER AND INDEPENDENT REPAIR SHOP SAY THE SEAT SENSOR NEED TO BE REPLACED. IT IS LOCATED IN THE SEAT AND THE WHOLE SEAT NEEDS TO BE REPLACED. ESTIMATED COST $1200. TO 1500. US DOLLARS. THE PASSENGER SEAT IS RARELY USED. THE REPAIR IS NOT COVERED BY WARRANTY. I DON'T KNOW IF THE AIR BAG WILL DEPLOY. APPARENTLY ALL BMW'S WERE RECALLED FOR THIS PROBLEM BUT NOT THE MINI COOPERS WHICH ACCORDING TO POSTED THREADS ARE ALSO EXPERIENCING THE SAME PROBLEM. *TR

BLUE BLACK SMOKE FROM FRONT GRILL OF WARM (20 MILES) DRIVEN CAR. CAR WAS OFF AND PARKED IN HIGHWAY 40 MCDONALDS RESTAURANT PARKING LOT NEXT TO A 10,000 GALLON HEATING FUEL TANK. PARKER FUEL COMPANY EMPLOYEES PUT OUT THE FIRE IN THE ENGINE COMPARTMENT JUST BELOW THE ENGINE. NOTE THE BATTERY WAS DISCONNECTED IMMEDIATELY BEFORE OPENING THE BONNET/HOOD AT WHICH TIME THE SMOKE AND VISIBLE FLAME WAS EXTINGUISHED 5 TIMES VIA 1 SMALL (DEPLETED) AND 3 TIMES ENDING VIA A 2ND LARGER PARKER FUEL COMPANY UNIT. HOWARD COUNTY FIRE AND POLICE VEHICLES ARRIVED AFTER FIRE HAD ENDED. CAR SEEMED NORMAL OVER 20 MILE PORTION OF TRIP ON HIGHWAY 70 + 40 @ 70 + 55 MPH SPEEDS. FLAME COULD BE VIEWED ORIGINATING UNDER ENGINE WHEN LOOKING DOWNWARD IN SPACE BETWEEN ENGINE AND FIREWALL BELOW EXHAUST MANIFOLD. NOT SURE IF FIRE WAS FROM POWER STEERING PUMP DRIVE (ELECTRIC MOTOR), POWER STEERING HOSE(S), PS FAN OR COMPROMISED OIL PUMP VOLUME CONTROL SOLENOID VALVE LEAKING OIL ON VERY HOT SUPERCHARGED ENGINE EXHAUST. I WAS VERY LUCKY THAT THE 4 MINUTES I WAS INSIDE MCDONALDS ,THAT MULTIPLE PARKER FUEL COMPANY EMPLOYEES ARRIVING TO WORK HAD SEEN THE SMOKE AND HAD MULTIPLE FIRE EXTINGUISHERS AND TRAINING TO PUT OUT FIRES. MY CAR WOULD HAVE COMPLETELY BURNED UP IN THE TIME IT WOULD HAVE TAKEN THE FIRE DEPT TO ARRIVE. THE 1ST PARKER FUEL COMPANY EMPLOYEE WAS ALREADY AT MY CAR WITH PLIERS TO DISCONNECT THE BATTERY AS HE KNEW IT WAS NOT STEAM FROM A RADIATOR, BUT BLACK SMOKE FROM A ELECTRICAL, GAS, OIL OR RUBBER/PLASTIC SOURCES BEING DIFFICULT TO EXTINGUISH. *TR

AIRBAG LIGHT IS ON FULL TIME, AFTER A PERIOD OF INTERMITTENT ACTIVITY. THERE ARE HUNDREDS OF SIMILAR COMPLAINTS ON THE WEB. THE HIGH COST OF REPAIRS SEEMS TO HAVE RESULTED IN A THRIVING BUSINESS SELLING REPLACEMENT "EMULATORS" THAT IMITATE THE SENSOR PAD ELECTRICAL CHARACTERISTICS. THIS IS THE SAME PASSENGER SEAT OCCUPANCY SENSOR MAT FAILURE FOR WHICH THERE HAVE BEEN EXTENSIVE RECALLS FOR BMW VEHICLES MADE BY THE SAME MANUFACTURER. OWNER CALLED MINI, WAS STONEWALLED AND TOLD THERE WAS NO INTEREST IN HEARING ABOUT THE PROBLEM, JUST TAKE IT TO A DEALER. ASKED DEALER SERVICE REP IF IT WAS SAFE TO DRIVE IN THIS CONDITION, WAS TOLD "I'M NOT ALLOWED TO ANSWER THAT." THIS IS A SAFETY ISSUE THAT RISES TO THE LEVEL OF REQUIRING A RECALL, AS WAS DONE FOR EARLIER MINI YEARS. MINI DOES NOT OFFER THE SENSOR MAT AS A SEPARATE PART, INSTEAD REQUIRES REPLACEMENT OF THE SEAT UPHOLSTERY, A $600+ BMW PART NUMBER WHICH IS BACK ORDERED WITH NO CERTAIN DELIVERY DATE OR PRICE. INCLUDING LABOR, THE COST TO REPAIR IS 10% TO 20% OF THE CURRENT SALES PRICE OF THIS YEAR MINI. PLEASE, THERE CAN BE NO EXCUSE FOR NOT RECALLING VEHICLES WITH THIS SIGNIFICANT AND EXPENSIVE SAFETY DESIGN FLAW. (TR

FAILURE OF OC-3 WEIGHT MAT IN PASSENGER SEAT BASE, THUS DISABLING PASSENGER SIDE AIRBAG SYSTEM. COST TO REPLACE SEAT BOTTOM IS $1200. AS THIS PART IS COMMON BETWEEN MINIS AND BMWS, AND IS VERY PRONE TO FAILURE, BMW HAS ISSUED A RECALL ON BMWS IN THIS MODEL YEAR AREA, BUT HAS NOT YET DONE SO FOR MINIS. PERHAPS BMW NEEDS A WRONGFUL DEATH LAWSUIT TO ISSUE A RECALL? THIS IS A TRAVESTY. *TR

THE VEHICLE WOULD NOT SHIFT INTO 2ND/3RD GEAR AFTER A TRAFFIC STOP. THE GEARS WOULD SHIFT ERRATICALLY RESULTING IN LOSS OF POWER AND WE ALMOST HAD AN ACCIDENT. CHECK ENGINE LIGHT IS ON AND A MESSAGE SHOWS UP "EP" WHICH MEANS TRANSMISSION IS ON EMERGENCY. *TR

MY 2006 MINI COOPER CONVERTIBLE HAS INTERMITTENT EXPERIENCED WITH PASSENGER AIR BAG WARNING LIGHT STAYING ON EVEN WHEN PASSENGER IS IN SEAT AND PROPERLY BUCKLED IN. THIS SHOULD BE A RECALL BY BMW. ALSO, HARMONIC BALANCER BROKE AT JUST UNDER 60,000...AND HAVE HEARD THIS IS A MAJOR PROBLEM ON MANY MINI COOPERS. BMW SHOULD BE RESPONSIBLE FOR REPLACEMENT. FAULTY EQUIPMENT. ALSO, CONVERTIBLE GASKET NEEDS REPLACING. INFERIOR MATERIAL USED BY BMW. VERY EXPENSIVE TO REPLACE. *TR

PASSENGER SIDE AIRBAG SENSOR IS FAULTY, CAUSING THE AIRBAG TO NOT DEPLOY IN THE EVENT OF A CRASH, EVEN THOUGH THERE IS A PASSENGER IN THE CAR. THIS IS A HUGE SAFETY CONCERN, AND MINI NEEDS TO DO A RECALL. THERE ARE THOUSANDS OUT THERE WITH THE SAME PROBLEM. *TR

VEHICLE WAS PARKED IN GARAGE FOR 3 MONTHS. WHEN VEHICLE WAS STARTED, THE AIR BAG LIGHT REMAINED ON. IT HAS NOT TURNED OFF FOR 6 MONTHS AND WILL NOT PASS STATE INSPECTION. THE BATTERY WAS STRONG ENOUGH TO START THE CAR WITH NO PROBLEM AND THE VEHICLE HAS IN A GARAGE THE ENTIRE TIME. WHEN THE VEHICLE WAS PARKED, ALL SYSTEMS WERE FUNCTIONING. *TR

PASSENGER SIDE AIR BAG WARNING LIGHT SPONTANEOUSLY LIGHTED WITHOUT INCIDENT AND CONTINUES TO REMAIN ILLUMINATED DURING OPERATION OF VEHICLE WITH OR WITHOUT PASSENGER IN SEAT. MINI OF USA ASSISTANCE DENIES ANY RESPONSIBILITY OR WARRANTY, BUT STATES THAT" AIR BAG MAY NOT FUNCTION IN CASE OF ACCIDENT". THIS VEHICLE HAS 53,00 MILES ON ODOMETER. HAVE OBSERVED MANY SUCH COMPLAINTS ON RELATED INTERNET SITES. *TR

AIR BAG WARNING LIGHT AND SEAT OCCUPANCY WARNING LIGHT CAME ON. TOOK IN FOR SERVICE- TOLD SEAT OCCUPANT MAT (FRONT PASSENGER SEAT) HAS FAILED AND MUST BE REPLACED. REPLACEMENT IS COST PROHIBITIVE ($1700). SAFETY RISK PRESENT BECAUSE AIR BAGS MAY NOT DEPLOY IN EVENT OF CRASH. DEALER SAYS THERE IS NO RECALL AND WILL NOT REPLACE THE PART UNDER ANY EXTENDED WARRANTY. *TR