2003 MINI COOPER S Complaints

TL* THE CONTACT OWNS A 2003 BMW MINI COOPER S. WHILE DRIVING, THE VEHICLE SHUT OFF. THE CONTACT NOTICED SMOKE COMING FROM UNDERNEATH THE HOOD. WHEN THE BATTERY WAS DISCONNECTED SHE NOTICED THAT THE WIRES WERE MELTING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS INSPECTED. THE DEALER INFORMED THE CONTACT THAT THE RELAY AND POWER STEERING PUMP BOTH FAILED AND WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 41,000. .UPDATED 09/19/11 *BF THE CONTROL HARNESS AND POWER SUPPLY HARNESS CONNECTOR MELTED ON THE POWER STEERING MOTOR. THE VEHICLE HAS SINCE BEEN REPAIRED.

POWER STEERING PUMP STARTED TO BECOME LOUDER AROUND 83K MILES. WHEN I WAS DRIVING AROUND A TURN, THE STEERING WHEEL TIGHTENED UP AND IT BECAME ALMOST IMPOSSIBLE TO TURN THE WHEEL. I ALMOST WRECKED BECAUSE OF THIS. AFTER RESEARCH, IT IS CONCLUDED THAT MY POWER STEERING GAVE OUT. NOTHING HAS BEEN DONE YET TO CORRECT THE FAILURE. *TR

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT STATED WHILE DRIVING 65 MPH THE POWER STEERING FAILED. THE VEHICLE WAS DRIVEN ONTO THE EMERGENCY LANE BECAUSE THE STEERING WHEEL WAS VERY HARD TO MANEUVER. THE DEALER WAS CONTACTED IN REGARDS TO A RECALL AND STATED ONLY A CLASS ACTION LAW SUIT WAS IN PROGRESS. THE CONTACT WAS TOLD TO BRING THE VEHICLE INTO THE DEALER TO BE REPAIRED AT HER OWN EXPENSE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 58,000. UPDATED 08/31/*LJ THE POWER STEERING PUMP WAS REPLACED. UPDATED 09/12/11

POWER STEERING ABRUPTLY FAILED IN RUSH HOUR TRAFFIC. WAS FORTUNATELY ABLE TO GET VEHICLE TO THE SHOP FOR REPAIR WITHOUT FURTHER INCIDENT. POWER STEERING FAILURES ARE UNFORTUNATELY ALMOST GUARANTEED IN MY YEAR AND MAKE VEHICLE. THE INDEPENDENT MECHANIC SAID THAT THIS IS A VERY COMMON COMPLAINT AND MINI USA HAS EVEN REDESIGNED THE POWER STEERING PUMP DUE TO THE HIGH FAILURE RATE, AND ALSO RECOMMENDED REPLACING THE FAN DUE TO HIGH LIKELIHOOD OF SHORTING OR FIRE. I PARTICIPATE IN AN ENTHUSIAST FORUM WHERE THESE REPORTS ARE COMMON WHICH IS WHY I TOOK IT TO THE SHOP IMMEDIATELY, TO AVOID FURTHER IN-DRIVING FAILURE OR WORSE, A CAR FIRE. THIS ISSUE HAS BEEN INVESTIGATED IN THE PAST AND IT IS UNCONSCIONABLE THAT NEITHER NHTSA NOR MINI USA HAS RECALLED THESE VEHICLES FOR WHAT IS AN ALMOST GUARANTEED FAILURE WITH OBVIOUS AND POTENTIALLY GRAVE SAFETY RISKS. I AM PAYING $1200 FOR THE REPAIR WHICH IS EXPENSIVE BUT NOT OUT OF LINE WITH WHAT OTHERS ARE PAYING AND WORTH MY PERSONAL PIECE OF MIND SINCE MINI USA WILL NOT PUBLICLY ADMIT THERE IS A PROBLEM. VEHICLE IS A 2003 MINI COOPER S WITH 87,000 MILES. *TR

SUDDEN LOSS OF STEERING DUE TO THE FAILURE OF THE POWER STEERING PUMP WHEN EXITING HIGHWAY. FORTUNATELY, I HAD ENOUGH STRENGTH TO STAY WITHIN THE CURVE OF THE OFF RAMP WHILE BRAKING TO A STOP. MY WIFE WOULD NOT HAVE HAD THE STRENGTH TO KEEP THE AUTO FROM GOING OFF THE RAMP.

POWER STEERING HAS BECOME INTERMITTENT. WHEN THE CAR IS STARTED, SOMETIMES THE POWER STEERING IS FUNCTIONING AND SOMETIMES IT IS NOT.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHEN THE CONTACT STARTED THE IGNITION, THE POWER STEERING WARNING INDICATOR ILLUMINATED WITH A SUDDEN LOSS OF POWER STEERING. A STRONG ELECTRICAL BURNING ODOR EMITTED INSIDE OF THE VEHICLE. THE FAILURE OCCURRED SIX TIMES WHEN THE VEHICLE WAS IN MOTION. AN AUTHORIZED DEALER WAS NOTIFIED AND ADVISED THE CONTACT TO HAVE THE FAILURE DIAGNOSED TO DETERMINE THE CAUSE. THE WILL SCHEDULE AN APPOINTMENT FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.

WHILE DRIVING AT A SPEED OF APPROXIMATELY 35-40, THE POWER STEERING ASSIST FAILED COMPLETELY. THE CAR BECAME ALMOST IMPOSSIBLE TO STEER AND CREATED A VERY UNSAFE MOMENT AS I MADE A 90 DEGREE TURN. I WAS ABLE TO GET THE CAR HOME WITH GREAT PHYSICAL EFFORT INVOLVED. THE PROBLEM SEEMS EXACTLY AS DESCRIBED IN ON-LINE DESCRIPTIONS FROM OTHER MINI OWNERS. IT IS A VERY DANGEROUS CONDITION .... IT IS ALSO VERY EXPENSIVE TO REPAIR. I AM SURPRISED THAT A RECALL HAS NOT BEEN REQUIRED DUE TO THE OBVIOUS SAFETY ISSUE!

POWER STEERING PUMP FAILURE. THE FAILURE HAPPENED ON A SNOW COVERED CURVY ROAD, LOST CONTROL AND WENT INTO THE DITCH. NO DAMAGE, WAS ABLE TO GET THE CAR SLOWED ENOUGH BEFORE CRASHING. THANKFUL NO OTHER CARS WERE IN THE OTHER LANE. WAS ABLE TO DRIVE THE CAR OUT UNDER ITS OWN POWER. WILL NOT DRIVE THE CAR NOW. *TR

HI, I'M THE THIRD OWNER OF A 2003 MINI COOPER S SINCE FEBRUARY 2010, LOCATED IN MONTREAL, QUEBEC, CANADA. IN THE BEGINING OF MAY 2011 MY CAR STARTED TO HAVE BIG ISSUES WITH THE POWER STEERING. THE POWER STEERING PUMP IS RUNNING DISCONTINOUS, ALL THE LIGHTS (FRONT, BACK AND DASHBOARD) ARE DIMMING AND AFTER JUST AFEW MILES OF DRIVING THE STEERING WHEEL BECOMES STIFF AND HARD TO TURN. I HAVE THIS PROBLEM NOW EVERYDAY WHEN I TRY TO DRIVE THE CAR. I'VE CHECKED THE POWER STEERING PUMP FAN AND IT SPINS FREE. NO BLOW OF THE F5 FUSE (AS OTHER PEOPLE REPORTED). IT HAPPEND TO ME IN THE LAST YEAR FOR 3 TIMES, BUT ONLY FOR A SHORT TIME. THE POWER STEERING PUMP WENT OUT, BUT FEW HOURS AFTER I TURNED OFF THE ENGINE AND DIDN'T DRIVE THE CAR, THE PUMP CAME BACK NORMALLY (EXCEPTING THE CONTINOUS WHINING NOISE OF IT). DIDN'T TAKE IT TO THE DEALER YET FOR A PUMP REPLACEMENT. I KNOW THE POWER STEERING PUMP FAILURE IS A COMMON PROBLEM ON MINIS 2002-2006 AND I WANT TO CLAIM THIS PROBLEM ON MY CAR TOO. HOPE THIS PROBLEM TO BECOME A RECALL SOON FOR MINI/BMW. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR