2012 MINI COOPER S COUNTRYMAN Complaints

MY AIRBAG LIGHT WAS ILLUMINATED ON DASH AND CENTER CONSOLE. I TOOK MY VEHICLE TO A MECHANIC WHO FOUND MULTIPLE SEAT MAT SENSOR FAULT CODES STORED. THE SEAT MAT IS NOT FUNCTIONING PROPERLY BY FAILING TO RECOGNIZE IF THERE IS A PASSENGER IN THE SEAT AND/OR THEIR WEIGHT. AS A RESULT, THE AIRBAG MAY FAIL TO DEPLOY COMPLETELY OR INADVERTENTLY DEPLOY ON A PASSENGER WEIGHING LESS THAN 45 POUNDS. BOTH RESULTING IN ADDITIONAL INJURIES AND/OR DEATH. MY MECHANIC HAS INFORMED ME MINI HAS HAD NUMEROUS ISSUES/RECALLS WITH THESE SEAT MAT SENSORS, AS DOCUMENTED IN MINI SERVICE BULLETIN DATE JANUARY 2019 (I HAVE ATTACHED A COPY). THE ISSUE AFFECTS NUMEROUS MINI MODELS MADE THROUGHOUT VARIOUS YEARS, INCLUDING 2012 WHICH IS THE SAME YEAR AS MY MINI. THESE SEAT MAT SENSORS DEFINITELY NEED TO BE REEVALUATED AND POTENTIALLY EXPAND THE RECALL/SAFETY ALERT TO INCLUDE ADDITIONAL MODELS.

TL* THE CONTACT OWNS A 2012 MINI COOPER S COUNTRYMAN. THE CONTACT TOOK THE VEHICLE TO MINI OF ARLINGTON (2001 N COLLINS ST, ARLINGTON, TX 76011) FOR AN OIL CHANGE AND WAS INFORMED BY THE MECHANIC THAT THE WATER PUMP WAS FAILING AND NEEDED TO BE REPLACED. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 18V248000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CONFIRMED THAT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

DRIVER SIDE FRONT DOOR FAILS TO OPEN WHEN STATIONARY. USING REMOTE AND/OR THE INTERIOR UNLOCK TOGGLE ALLOWS THE UNLOCK INDICATOR ON THE UPPER DOOR SILL TO POP UP; HOWEVER, NEITHER THE INTERIOR NOR EXTERIOR DOOR HANDLES, WHEN PULLED, OPEN THE DOOR. DRIVER MUST EXIT VIA WINDOW OR PASSENGER SIDE DOOR. ALL OTHER DOORS OPERATE IN A NORMAL FASHION. THIS HAPPENED INTERMITTENTLY FROM 2 MAY 2020 UNTIL 26 MAY 2020. CURRENTLY AS OF 26 MAY 2020, THE DOOR UNLOCK INDICATOR POPS UP OR DOWN WITH REMOTE OR INTERIOR TOGGLE, BUT FAILS TO OPEN WHEN INTERIOR OR EXTERIOR DOOR HANDLE IS PULLED. THIS IS A KNOWN DEFECT AND CAN BE IDENTIFIED ON VARIOUS WEBSITES. THOUGH THE YEAR AND MODEL MAY BE DIFFERENT THAN OURS, MANY PARTS ARE SHARED ACROSS MODELS AND YEARS. HTTP://FORUMS.PELICANPARTS.COM/MINI-DISCUSSION-FORUM/939545-DRIVER-DOOR-WONT-OPEN.HTML HTTPS://WWW.NORTHAMERICANMOTORING.COM/FORUMS/STOCK-PROBLEMS-ISSUES/187003-DRIVER-S-DOOR-WON-T-OPEN-FROM-INSIDE-OR-OUTSIDE.HTML HTTPS://WWW.MINI2.COM/THREADS/DRIVER-DOOR-STUCK-CLOSED-HELP.183918/ HTTP://WWW.PSMINI.ORG/FORUM/DRIVERS-DOOR-WONT-OPEN-FROM-INSIDE_TOPIC6265.HTML HTTPS://MINICOOPERFORUMS.COM/FORUM/2002-2006-MINI-COOPER-R50-11/MINI-COOPER-DOOR-WONT-OPEN-NOT-ACTUATER-3479/*DT*JB

THE FIRST IMAGE SHOWS A QUOTE FOR WORK THAT EDISON MINI STATED MY CAR NEEDS. THE SECOND IMAGE IS A SCREENSHOT I SAVED FROM THE INTERNET WHEN I RESEARCHED IF THE ISSUE WITH THE THE WATER PUMP IS A KNOWN ISSUE FOR MY YEAR AND MAKE OF MY CAR. IS THERE A WAY WHERE YOU CAN HELP ME TO GET THIS WATER PUMP ISSUE CORRECTED BY MINI, AT THEIR EXPENSE? MY CAR IS A 2012, 8 YEARS OLD AND I HAVE A MERE 77,000 MILES ON IT.

TL* THE CONTACT OWNED A 2012 MINI COOPER S COUNTRYMAN. AFTER DRIVING FOR APPROXIMATELY FOUR HOURS, THE CONTACT PARKED THE VEHICLE AND BLACK SMOKE APPEARED UNDER THE HOOD. THE CONTACT EXITED THE VEHICLE AND CALLED 911. THE POLICE AND FIRE DEPARTMENTS ARRIVED AND THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT AND A FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED AND TOWED TO AN IMPOUND FACILITY. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 84,000. *LN*JB*PM*JB

THE FRONT PASSENGER SEAT OCCUPANCY DETECTOR SENSOR FAULTS WHICH WERE COVERED IN RECALLS ON EARLIER MODELS ARE STILL A PROBLEM, YET NO LONGER COVERED FOR REPAIR. THIS SENSOR CONTROLS AIRBAG INFLATION DURING ACCIDENTS

CLUTCH SLIPPING, TAKING A LOT OF RPMS TO GET MOVING, LOT OF CHATTER ACCELERATING AROUND CORNERS (LIKE MAKING A TURN FROM OUT OF A DEAD STOP). STALLED OUT AT BUSY INTERSECTIONS, AND AT TRAFFIC SIGNALS ON HILLS, NEARLY CAUSING A FEW ACCIDENTS. BACKING UP INTO DRIVEWAY, JUST TRYING TO GET OVER THE CURB SLOPE WAS ENOUGH TO CAUSE A BURNING SMELL FROM THE CLUTCH. RESEARCH SHOWS THAT THE CLUTCH IN THIS MAKE/MODEL YEAR SUBJECT TO PREMATURE AND EXCESSIVE WEAR (ONLY 7 YRS AND 40K MILES ON THIS VEHICLE - BY CONTRAST, I ALSO DRIVE A VW 10 YEARS OLDER WITH TWICE THE MILEAGE, CLUTCH STILL WORKING PERFECTLY). REPAIR TECH REPORT STATES CLUTCH WORN DOWN TO THE RIVETS, FLYWHEEL HEAVILY SCORED - VEHICLE HAS NO HISTORY OF RACING OR EVEN HEAVY USE, IS ONLY A DAILY DRIVER ON A SHORT (3 MI.) COMMUTE.

I HAD JUST EXITED ONTO THE HIGHWAY AND HAD NOT EVEN MADE IT TO THE NEXT EXIT RAMP, WHEN MY SUNROOF EXPLODED. IT SOUNDED AS IF A GUN SHOT HAD GONE OFF IN MY CAR. WE WERE HIT WITH SHARDS OF GLASS AS THE GLASS DID NOT SHATTER INTO SMALL PIECES. GLASS PIECES WERE 1+ INCHES LONG AND 1+ INCHES WIDE. WE HAD NO VEHICLES NEXT TO US. WE DID NOT FIND ANY DEBRIS IN THE CAR OR ON THE ROOF OF THE CAR EXCEPT FOR SHATTERED GLASS.

SIMPLY PUT, MY SHIFT CABLE DETACHED FROM THE TRANSMISSION. I WENT FROM 1ST TO 2ND TO NEUTRAL TO STOP AT THE END OF MY DRIVEWAY TO LOOK BOTH WAYS BEFORE PULLING ONTO THE ROAD TO NO SHIFT CAPABILITIES WHATSOEVER. LUCKILY IT HAPPENED AT THE END OF MY DRIVEWAY AND NOT ON THE HIGHWAY WHERE I NORMALLY DRIVE TO GET TO WORK. I MANAGED TO POP THE LOOP END BACK IN PLACE, BUT FEAR IT MAY FALL OFF, AGAIN. DEALER WANTED 1K TO REPLACE SHIFT CABLES/HARDWARE. TWO CABLES IN MY SITUATION...

MY 2012 MINI COOPER COUNTRYMAN WITH 83033 MILES IS REQUIRING REPLACEMENT OF THE THERMOSTAT HOUSING, THE RECALLED WATER PUMP WAS INSTALLED BY THE DEALER ON 10/31/2018, I HAD THE VEHICLE TOWED TO THE DEALER, THEY SAID IT WILL COST YOU $1800 TO REPLACE THE THERMOSTAT HOUSING, I HAVE BEEN TOLD NOT TO DRIVE MY CAR ON THE HIGHWAY, IT WILL COST ME $1800. PRE THE DEALERSHIP TO FIX. THERE IS NOT ANY PARTS IN THE UNITED STATES CURRENTLY TO FIX THIS CAR. I HAVE INCLUDED PHOTOS OF THE THERMOSTAT HOUSING THAT WAS REMOVED FROM MY CAR AND BY PAPER WORK FROM THE DEALER. IT LOOK LIKE IT WAS CHIP WHEN THE WATER PUMP WAS REPLACED AND NOT CRACKED. I HAVE ORDER TWO THERMOSTAT AND THEY DO NOT FIX. I AM STILL PAYING FOR THIS CAR THOUGH MINI FINANICEL, MAYBE IT TIME TO HAVE THIS CAR RETURN BACK TO THEM. I CANNOT GET THE CORRECT THERMOSTAT TO GET IT FIX. DO NOT WANT TO KEEP PAYING FOR A CAR I CANNOT DRIVE. SO WHERE DO WE GO FROM HERE....