MINI Complaints

THE POWER STEERING FAILED AND STOOPED WORKING AS I WAS DRIVING THROUGH BOSTON. NOW, THE POWER STEERING PUMP STAYS ON EVEN WHEN THE KEY IS TAKEN OUT OF THE IGNITION. *JS

ENGINE COOLING FAN LOW SPEED STAGE FAILURE. THERE HAS BEEN A RECALL OF COOLING FAN FOR THE SAME MODEL UP TO MODEL YEAR 2004. BUT MY 2005 MINI COOPER S HAS THE SAME PROBLEM. THUS, IT IS APPROPRIATE TO EXTEND THE RECALL TO INCLUDE MODEL YEAR 2005. *JS

WHILE DRIVING MY 04 MINI COOPER AT FREEWAY SPEED, I SUDDENLY LOST POWER STEERING ASSIST. I CAN STILL DRIVE THE VEHICLE, BUT IT IS VERY DIFFICULT TO TURN. I TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND WAS TOLD THE NEW POWER STEERING PUMP ALONE WILL COST ME OVER 600 DOLLARS. THIS DOES NOT INCLUDE THE LABOR AND OTHER MISCELLANEOUS COSTS ASSOCIATED WITH REPLACING THE UNIT. THE REPAIR WILL COST ME IN EXCESS OF 1000 DOLLARS, WHICH I CAN NOT AFFORD AT THIS MOMENT. I UNDERSTAND THAT MULTIPLE COMPLAINTS RELATING TO THE POWER STEERING SYSTEM IN THE 04 MINI COOPER HAVE BEEN FILED. HOWEVER, I HAVE NOT SEEN A RECALL REGARDING THIS ISSUE. I WOULD LIKE TO KNOW IF YOU FORESEE A RECALL FOR THIS ISSUE, AND WOULD APPRECIATE ANY HELP YOU CAN OFFER. THANK YOU FOR YOUR TIME AND CONSIDERATION. *TR

VEHICLE FAILED DUE TO ISSUE WITH THE TIMING CHAIN TENSIONER. THIS CAUSED THE TIMING CHAIN GUIDES TO BREAK AND DROP INTO THE OIL PAN. ENTIRE ENGINE MAY NEED TO BE REPLACED. ENGINE FAILED AS I WAS PULLING OUT ONTO A VERY BUSY STREET (7TH STREET IN PHOENIX AZ) LEAVING ME STRANDED AND UNABLE TO MOVE IN TRAFFIC. THE CAR HAD TO BE PUSHED ONTO A SIDE STREET. *TR

PURCHASED 2006 MINI COOPER S BRAND NEW AT A MINI DEALER IN BOSTON. THE VEHICLE HAS 108K HIGHWAY MILES. I HAD SERVICED THE VEHICLE AT THE DEALER UNTIL WARRANTY RAN OUT AND TRANSITIONED TO A NATIONAL CAR CARE CHAIN. I BEGAN TO NOTICE THE VEHICLE SLIPPING BETWEEN SECOND AND THIRD GEAR WHEN TRAVELING IN STOP AND GO TRAFFIC. I BROUGHT THE CAR TO MY REGULAR MECHANIC AND THEY INDICATED THAT I SHOULD BRING IT TO A TRANSMISSION SHOP. DELIVERED THE CAR TO THE SHOP AND HAVE BEEN INFORMED THAT MY CVT TRANSMISSION HAD FAILED AND WOULD NEED TO BE RE-MANUFACTURED. I WAS ALSO INFORMED THAT MY POWER STEERING PUMP IS LEAKING AND FAILING. THE POWER STEERING FAN HAD SEIZED AND WAS LIKELY THE CAUSE OF THE POWER STEERING FAILURE. THE MINI DEALERSHIP QUOTED ME OVER 10K FOR THE TRANSMISSION REPLACEMENT ONLY DID NOT INQUIRE ABOUT POWER STEERING AND THERE WERE NO PROGRAMS FOR CUSTOMERS IN THIS SITUATION. THIS COST IS MORE THAN THE CAR IS WORTH. THE TRANSMISSION SHOP WILL DO THE REPAIRS FOR 6K. *TR

AT 35 MPH I NOTICED INTERMITTENT LOSS OF POWER STEERING (PS). I WAS DIVING ON 2 LANE WINDING COUNTRY ROAD WITH NO SHOULDERS AND ENDED UP IN THE ONCOMING LANE BEFORE I REGAINED CONTROL. LUCKILY WAS NO TRAFFIC AT THE TIME. THE MOST TERRIFYING THING IS WHEN PS IT'S DEAD FOR A WHILE AND THEN SUDDENLY COMES BACK ON. IF YOU ARE IN A CORNER, BECAUSE YOU'VE JUST BEEN MUSCLING THE STEERING WHEEL, AND PS COMES BACK YOU WILL BE SUDDENLY OVER-STEER AND VEER OUT OF YOUR LANE. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH, THERE WAS A COMPLETE LOSS IN THE POWER STEERING WITHOUT ANY PRIOR WARNING. THE CONTACT WAS ABLE TO CONTINUE DRIVING WITH CAUTION AT A REDUCED SPEED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE POWER STEERING PUMP WOULD NEED TO BE REPLACED. THE CONTACT PLANNED TO HAVE THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THERE WAS CURRENTLY THERE AN OPEN INVESTIGATION ASSOCIATED WITH NHTSA ACTION NUMBER EA11005 (STEERING: HYDRAULIC POWER ASSIST: PUMP). THE APPROXIMATE FAILURE MILEAGE WAS 60,000. THE VIN WAS UNAVAILABLE.

MY POWER STEERING FAILED AS I WAS DRIVING DURING RUSH HOUR ON A MAJOR HIGHWAY INTO WASHINGTON, DC. THE WHEEL WAS NOT LOCKED, BUT IT BECAME EXTREMELY DIFFICULT TO TURN THE WHEEL IN ANY DIRECTION, WHICH WAS VERY DANGEROUS AS TRAFFIC WAS GOING 70MPH. I WAS ABLE TO PULL THE CAR OFF AT AN EXIT, AND STOP IT ON THE SHOULDER. I TURNED OFF THE ENGINE AND RE-STARTED THE CAR, AT WHICH TIME THE POWER STEERING APPEARED TO WORK NORMALLY AGAIN. THIS WAS THE MOST RECENT INCIDENT OF THIS TYPE, BUT THERE HAVE BEEN AT LEAST TEN. IN OTHER INSTANCES, THE POWER STEERING FAILS DURING PARALLEL PARKING IN THE TIGHT SPACES ON CITY STREETS. THIS IS UNPREDICTABLE, HOWEVER -- MONTHS CAN PASS WITH NO PROBLEM, AND THEN IT STARTS AGAIN. *TR

THE XENON IGNITER COMPONENT IN THE LEFT HEADLAMP HAS INTERMITTENT FUNCTION, FREQUENTLY CAUSING THE BULB NOT TO LIGHT. THE QUOTED REPAIR COST BY THE DEALER IS IN EXCESS OF $800 BECAUSE THE IGNITER PART IS NOT A REPLACEABLE COMPONENT (THE ENTIRE HEADLIGHT ASSY IS REPLACED). THE ORIGINAL OEM BULB IN THE AFFECTED LEFT HEADLAMP WAS REPLACED BY MINI DURING ITS WARRANTY PERIOD AND THIS WAS NOT REPORTED TO ME (THE LEFT AND RIGHT BULBS DID NOT MATCH UPON MY EXAMINATION OF THEM WHEN FIRST OBSERVING THIS PROBLEM). $800 TO FIX A LIGHT BULB IS RIDICULOUS, AND I'VE BEEN LIVING WITH THIS SAFETY HAZARD SINCE I OBSERVED IT IN SEPTEMBER 2010. BMW USA SHOULD BE COMPELLED TO RECALL THIS DEFECTIVE COMPONENT. *TR

VEHICLE LOST POWER STEERING. I HAD THE POWER STEERING ASSIST COOLING FAN REPLACED TWICE AND THE RELAY SWITCH FOR THE COOLING FAN. IT WORKED FINE FOR A TIME. NOW (10,000 MILES LATER) IS INTERMITTENT. *TR