2002 NISSAN FRONTIER Complaints

WHILE HAVING MINOR COSMETIC REPAIRS DONE, OUR [REPUTABLE] BODY SHOP REPAIRMAN POINTED OUT THAT THE FRONT RADIATOR SUPPORT FRAME IS COMPLETELY RUSTED THROUGH. EVERYTHING ELSE ON THIS TRUCK IS SOLID. I AM METICULOUS ABOUT IT. THERE IS OBVIOUSLY SOME SORT OF DEFECT ON THIS AREA FOR IT TO BE 90% DETERIORATED! THE SLIGHTEST TOUCH CAUSES IT TO CRUMBLE...IN THE PAST, EVEN TOYOTA HAS STOOD BEHIND THEIR VEHICLES WITH CORROSION ISSUES...I WOULD CERTAINLY HOPE NISSAN COULD LOOK INTO THIS THE SAME WAY...ITS A REAL SHAME THAT I CAN ONLY SEE ANOTHER YEAR MAYBE BEFORE MY RADIATOR FALLS OUT AND CAUSES SOMETHING MUCH WORSE... *TR

TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE WARNING INDICATOR CONTINUOUSLY ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. ON A SEPARATE OCCASION THE VEHICLE JERKED VIOLENTLY WITH A REDUCTION IN THE ENGINE POWER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE KNOCK SENSOR, MASS AIR FLOW SENSOR AND FOUR OXYGEN SENSORS WERE REPLACED. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIR WAS PERFORMED. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC FOR THE SECOND TIME AND THE WIRING HARNESS WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM AND THEY INFORMED THE CONTACT THAT THE WIRING HARNESS CONNECTORS EXHIBITED CORROSION AS A RESULT OF NOT BEING WEATHERPROOF DURING PRODUCTION. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 04/10/12*LJ THE CONSUMER STATED HE SPENT CLOSE TO $2000 REPAIRING THE VEHICLE. THE CHECK ENGINE LIGHT CONTINUED TO ILLUMINATE, AFTER REPLACING THE O2 SENSORS FOUR TIMES. ALSO, THE WIRING HARNESS HAD TO BE REPLACED BECAUSE WHEN THE VEHICLE WAS MANUFACTURED IT WAS NOT WEATHER PROOF WHICH CAUSED CORROSION IN THE WIRES, WHICH SENT INCORRECT SIGNALS TO THE VEHICLE'S COMPUTER. THE CONSUMER NO LONGER OWNS THE VEHICLE. UPDATED 05/31/12

TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE VIN DID NOT QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 04V230000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 139,893.

A VERY STRONG AND VERY OVERPOWERING GAS SMELL CAME INSIDE THE VEHICLE WHILE I WAS DRIVING IT AT NIGHT. I HAD MY 5-YEAR OLD STRAPPED IN HIS CAR SEAT IN THE BACK. I WAS STUCK IN TRAFFIC ON I-95 AND DIDN'T HAVE MANY OPTIONS BUT TO CONTINUE TO DRIVE HOME. THE "SERVICE ENGINE SOON" LIGHT CAME ON AS WELL. THE NEXT DAY, I TOOK THE VEHICLE IN FOR SERVICING AT MY NISSAN DEALERSHIP MECHANIC, AND I HAVE SPECIFIC TEXT FROM THE WORK INVOICE THAT STATES THE FOLLOWING WORD-FOR-WORD: "CANNISTER COMING APART. RIGHT VALVE STUCK INSIDE - REPLACED - GAS LEAKING DOWN SIDE. REPLACED GAS TANK - RUSTED." THE WORK INVOICE ALSO DETAILS THAT THE DEALERSHIP MECHANIC REPLACED THE FOLLOWING COMPONENTS: (1) CANISTER ASSY E (2) VALVE ASSY - CO (3) FUEL TANK (4) RING-O FUEL GAG. THIS VEHICLE HAS NEVER BEEN IN ANY ACCIDENTS AND I FULLY MAINTAIN IT ACCORDING TO THE MANUFACTURER'S SCHEDULE. I HAVE BEEN A RESPONSIBLE AND GENTLE OWNER. I FEEL THIS WAS EXTREMELY UNSAFE -- TO HAVE GASOLINE LEAKING OUT DUE TO A RUSTED GAS TANK IS [IN MY OPINION] AN UNACCEPTABLE DEFECT -- THE GAS TANK SHOULD HAVE BEEN MADE [IN MY OPINION] OUT OF A NON-RUSTING MATERIAL. I HAVE COMPLAINED TO NISSAN USA AND THEY OFFERED ME (ON THE PHONE THE REPRESENTATIVE SAID IT WAS AS "GOODWILL") A $250 NISSAN DEBIT CARD FOR FUTURE REPAIRS ON THIS VEHICLE. BUT THE TOTAL COST THAT I HAD TO PAY FOR THIS LEAKING GASOLINE ISSUE WAS $1,254.83. I AM WILLING TO PROVIDE NHTSA WITH MY RECEIPT THAT SHOWS THE TEXT INDICATING THE DETAILS OF THIS DEFECT AND THAT I HAD TO PAY $1,254.83 TO RECTIFY IT. *TR

2002 NISSAN FRONTIER PICK UP. CONSUMER WRITES IN REGARDS TO A SERIOUS CORROSION PROBLEM IN THE UNDER BODY; ESPECIALLY THE DRIVE SHAFT. *TGW AN INSPECTION REVEALED MAJOR RUST IN THE UNDER BODY. THE CONSUMER STATED TWO YEARS AFTER PURCHASING THE VEHICLE, A METAL GUARD COVERING THE CATALYTIC CONVERTER RUSTED OFF. *JB

TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT HE NOTICED THAT THE FUEL TANK WAS LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THERE WAS SEVERE RUSTING AND SMALL PIN HOLES IN THE GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE COMPONENT WAS NO LONGER WAS BEING MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE EXHAUST MANIFOLD WAS FRACTURED AND SENDING CO2 THROUGH THE VENTS WHILE DRIVING 25 MPH AND ABOVE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER REPLACED THE PASSENGER SIDE EXHAUST MANIFOLD. AFTER THE REPAIRS, THE DRIVER SIDE EXHAUST MANIFOLD FRACTURED AND THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER. THE DEALER ADVISED THAT IT WAS COMMON FOR THE MANIFOLD TO FRACTURE IN THE PARTICULAR YEAR, MAKE AND MODEL. THE CONTACT DID NOT REPLACE THE DRIVER SIDE EXHAUST MANIFOLD. THE FAILURE MILEAGE WAS 150,000.

2002 NISSAN FRONTIER. CONSUMER STATES STEERING PROBLEMS *TGW THE CONSUMER STATED THE NEAREST DEALER IS 80 MILES AWAY AND WOULD LIKE TO HAVE HIS MECHANIC PERFORM THE RECALL WORK. *JB

TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE INTERIOR HEATER WAS ACTIVATED AND WOULD BLOW EXTREMELY HOT AIR WHEN DIRECTED TO THE FOOT VENT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED TO SIMPLY CHANGE THE HEATER SETTINGS. THE CONTACT WAS CONCERNED BECAUSE THE HEAT WOULD BURN HIS FEET. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 150,000. UPDATED 10/05/11

TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THE VEHICLE WAS REPAIRED FOR THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 10V554000 (STEERING:COLUMN). AFTER RECEIVING THE VEHICLE FROM THE AUTHORIZED DEALER, THE CONTACT NOTICED THAT THE STEERING WHEEL WAS POSITIONED OUT OF ALIGNMENT. WHENEVER THE STEERING WHEEL WAS POSITIONED TO DRIVE STRAIGHT, THE VEHICLE WOULD STEER TOWARDS THE RIGHT. THE MANUFACTURER AND AUTHORIZED DEALER WERE NOTIFIED, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 93,898. UPDATED 8/29/11 *CN THE DEALER INFORMED THE CONSUMER THE ALIGNMENT WAS PROBABLY OFF. UPDATED 10/03/11