2022 NISSAN LEAF Complaints

The high-voltage battery on my 2022 Nissan Leaf is subject to Recall 25V655. I learned about this in late October 2025. The recall notice states that the battery cells can develop excessive lithium deposits, which increases electrical resistance and can cause rapid battery heating during Level 3 fast charging. Nissan instructs owners not to use Level 3 charging at all until a “remedy” is available. The issue is that the remedy described by Nissan is not an actual repair of the battery defect. Nissan states it will install software that monitors for “state-of-charge fluctuation” and, if detected, will prevent the vehicle from restarting or recharging in order to avoid a thermal incident. This means the defect inside the battery cells is still present, and the car may disable itself if the defect begins to appear. The recall materials also state there is no warning before overheating occurs. This creates multiple safety concerns: • The underlying battery defect remains uncorrected. • The vehicle can become immobilized (unable to restart or recharge) if the software detects the condition. • Loss of Level 3 charging capability affects the ability to travel safely or plan charging when needed. • A battery fire risk exists during Level 3 charging if the defect is not detected in time. Nissan’s documents state that the software is meant only to prevent the “progression” of a thermal incident, not to repair the defective battery. I am concerned that my vehicle contains a known hazardous defect that has not been physically repaired and that the software-only response is inadequate to ensure safety. I am filing this complaint so NHTSA is aware that the remedy being offered does not address the internal battery defect itself and may leave owners exposed to continued safety and reliability risks.

“2022 Nissan Leaf with 63,000 miles. Vehicle loses propulsion, unable to accelerate above 40 mph, and goes into turtle mode. Dealer opened the high-voltage battery and found multiple swollen modules. Nissan refuses to replace swollen modules and will only replace one cell despite EV system failure. Vehicle is unsafe to drive.”

The contact owns a 2022 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the unrepaired recall was dangerous. The dealer was contacted, and the contact was advised not to use the Level 3 quick charging because the vehicle might catch on fire. The manufacturer was not contacted. The contact had not experienced a failure.

I am the original owner of a 2022 Nissan Leaf, purchased new. On the evening of Thursday, 11/20/2025 I became aware of an active recall affecting my vehicle related to a battery fire hazard when using DC fast charging stations. I only learned of this serious safety defect when attempting to trade in my vehicle, at which point the dealership declined to accept it due to the unresolved recall. This recall poses a significant safety risk that I was not informed about despite being registered with Nissan. I have regularly used DC fast charging stations without any knowledge that doing so could result in a fire and potential severe injury. The recall notice does not appear in my Nissan account dashboard, although two other recalls for my vehicle are properly displayed there. However, when I independently search my VIN on the NHTSA website, the recall is clearly linked to my vehicle. As a result of this defect and lack of proper notification, I now own a vehicle with reduced functionality, a documented fire risk, and diminished resale value. On the morning of Friday, 11/21/2025 I contacted Nissan's Consumer Affairs and requested that Nissan repurchase my vehicle given the severity of this safety defect and the impact on my ability to use or sell the vehicle. This morning (Monday 11/24/25) I was informed Nissan has refused to buy back my vehicle. The promptness of their reply is concerning and indicates they do not take this issue seriously. I am deeply concerned about the adequacy of Nissan's recall notification process when such a critical safety issue was never communicated to me through my registered account or other direct means. I request that NHTSA investigate why I was not properly notified of this recall despite being the registered owner, whether other affected owners may have similarly failed to receive adequate notice of this serious safety defect, and whether Nissan's refusal to repurchase my vehicle is appropriate given the circumstances.

The latest recall, NHTSA Recall 25v-655 for which there is no fix, has rendered my vehicle useless for any round-trip of more than approximately 130 miles from home. This is the same issue for which there was a recall for 2019/2020 LEAFs and after a year there was no known fix from the manufacturer.

The contact owns a 2022 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the contact was informed by the dealer that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was informed. The contact had not experienced a failure.

The contact owns a 2022 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electric System). The contact stated that a week after purchasing the vehicle, the same type of battery was replaced for an unknown reason. The contact stated that after quick charging to 97% and almost seven months later, while driving approximately 65 MPH, the vehicle lost power, and a turtle icon was displayed. The contact added that the message "Slow Down - Overheating" was displayed. The vehicle was taken close to the residence and turned off to allow it to cool down. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.

Nissan has a safety recall with no resolution. You cannot travel in this vehicle if you cannot use a fast charger. I have family emergency. I called Nissan consumer affairs. Case XXX. customer service said maybe a loaner car can be an option. MARSHAY a consumer affairs representative said this is not an option. There is nothing they can do. There is no resolution at this time or eta. Nissan should take all of these cars back if they are this dangerous and they don't know how to fix. Nissan mechanics dont know what to say and just refer you to Nissan Comsumer Affairs who dont have an answer. Slow charging is 8 hours or more, you can't go anywhere. Charging is 30 to 45 minutes at each station even if is called fast charging.

My 2022 Nissan Leaf is part of recall R25C8 involving a battery fire risk during DC fast charging. Nissan has advised not to use Level 3 charging, which prevents normal operation of the vehicle. The dealership refuses to provide a rental or loaner while I wait for the remedy. I am currently unable to use the vehicle safely for transportation. This recall has made the vehicle unusable and Nissan is denying transportation assistance. I am requesting NHTSA intervention.

I own a 2022 Nissan Leaf (VIN [XXX] ) affected by Recall 25V-655. This recall prohibits use of Level 3 DC fast-charging due to a potential battery-fire risk, leaving the car unsuitable for long-distance use. My dealer’s service manager told me Nissan may have a fix “in spring 2026 or not.” That means no remedy is available for at least 6–12 months. I purchased this car only days before Nissan filed the recall (signed 9/30/25, posted 10/1/25). My salesperson specifically told me that the 2019–2020 Leafs had a battery recall with no fix, but the 2022 was unaffected. The timing suggests Nissan may have known the 2022 recall was imminent but had not disclosed it to dealers or buyers. I am requesting NHTSA ensure Nissan provides a timely, safe remedy or compensates affected owners for loss of functionality and value. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)