2000 ORION V Complaints

A FIRE ORIGINATED FROM THE RIGHT REAR SIDE BRAKE DRUM DESTROYED THIS BUS.AFTER REVIEWING COMPLAINT NUMBER 10082983 & 10119358. I BELIEVE THIS INCIDENT IS RELATED TO THE FIRE OF OUR BUS. I REQUEST AN INVESTIGATION BECAUSE THIS IS A TRANSIT BUS AND THE SAFETY OF PASSENGERS IS OF CONCERN.

A FIRE ORIGINATING FROM THE RIGHT REAR SIDE BRAKE DRUM DESTROYED THIS BUS. AFTER REVIWING PRIOR COMPLAINT NUMBER 10082983, WE BELIEVE THIS INCIDENT IS RELATED TO THE INCIDENT THAT WAS THE SUBJECT OF COMPAINT # 10082983. WE REQUEST AN INVESTIGATION BECAUSE THIS IS A TRANSIT BUS AND THE SAFETY OF PASSENGERS IS OF CONCERN.

1) INTERUPTION OF SERVICE REPORTED BY BUS OPERATOR AND FIRE DEPARTMENT REQUESTED. 2) MECHANICAL FAILURE OF PNEUMATIC BRAKE CHAMBER CAUSING BRAKES TO DRAG RESULTING IN SUFFICIENT HEAT TO IGNITE THE TIRE AND THE SURROUNDING AREAS OF THE VEHICLE. 3) ALTERNATE BRAKE CHAMBER HAS BEEN RESEARCHED, TESTED AND IMPLEMENTATION STARTED.*AK

APRIL 21, 2003 U.S. DEPARTMENT OF TRANSPORTATION NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION OFFICE OF DEFECTS INVESTIGATION NSA-10.01, 400 7TH STREET, SW WASHINGTON, DC 20590 SUBJECT: ANTI-LOCK BRAKE SYSTEM (ABS) DEFECT ?? 2000 MODEL ORION V TRANSIT BUSES THE REGIONAL TRANSPORTATION DISTRICT OF DENVER, COLORADO OPERATES A SUBFLEET OF 303 MODEL YEAR 2000 ORION V TRANSIT BUSES. THESE BUSES ARE EQUIPPED WITH THE MERITOR WABCO ANTI-LOCK BRAKE SYSTEM (ABS) AND TRACTION CONTROL SYSTEM. ON OCTOBER 29, 2002 DURING A HEAVY SNOWSTORM, 29 OF THESE ORION BUSES EXPERIENCED FRONT WHEEL LOCK UP UPON BRAKE APPLICATION. IT APPEARED THE ABS MODULATOR VALVES WERE OBSTRUCTED BY SNOW AND ICE, AND FAILED TO RELEASE AIR DURING AN ABS CYCLE. RTD ACCIDENTALLY DISCOVERED THAT BY POWERING DOWN THE BUSES AND POWERING THEM BACK UP, THE ABS WENT THROUGH A SELF-TEST PROCEDURE, WHICH ALLOWED VENTING OF TRAPPED AIR IN THE BRAKE CHAMBER AND RELEASED THE BRAKE. THIS PROBLEM REPEATED ON MARCH 19, 2003 DURING ANOTHER HEAVY SNOWSTORM IN DENVER. DURING THE MIDST OF THE SNOWSTORM, OVER 200 RTD BUSES, MOST OF THEM ORION BUSES, WERE STUCK ON SNOW. RTD CONTRIBUTED MOST OF THE STUCK BUSES TO THE FRONT WHEEL LOCK UP PROBLEM RESULTING FROM THE FAILURES OF THE ABS. TWO OTHER SUBFLEETS IN RTD??S FLEET THAT ARE EQUIPPED WITH SIMILAR ABS EXPERIENCED NO SIMILAR ABS FAILURES DURING THE TWO SNOWSTORMS. RTD HAS REQUESTED ORION AND MERITOR WABCO TO CORRECT THIS BRAKE SYSTEM SAFETY RELATED DEFECT. HOWEVER, ORION AND MERITOR WABCO HAVE REFUSED TO TAKE ANY ACTIONS. RTD IS FILING THIS COMPLAINT IN HOPING OF GETTING THE ASSISTANCE FROM THE GOVERNMENT TO REQUIRE THE VEHICLE MANUFACTURER AND/OR THE EQUIPMENT MANUFACTURER TO TAKE ACTIONS TO CORRECT THIS DEFECT. PLEASE CONTACT THE UNDERSIGNED FOR ADDITIONAL INFORMATION IF NECESSARY AT 303-299-6265 OR EMAIL [email protected]. *JB