2014 PETERBILT 388 Complaints

PROBLEMS WITH (AFTER TREATMENT)CODES FLASHING, CHECK ENGINE, IMMEDIATELY WENT TO STOP ENGINE IMMEDIATELY AND TRUCK SHUT OFF AT 70MPH. FORTUNATELY NOT ON INCLINE OR DECLINE AND WAS ABLE TO PULL TO SAFETY. THIS HAPPENED ON TWO SEPARATE OCCASIONS. PETERBILT NOR CUMMINS HAS NOT BEEN ABLE TO DIAGNOSE THE PROBLEM UNTIL THE FUEL PUMP COMPLETELY FAILED AND TOOK OUT THE ENGINE. MANUFACTURER KNOWS THIS IS A DESIGN AND ENGINEERING FLAW AND REFUSES TO TAKE RESPONSIBILITY FOR THESE OLDER TRUCKS THAT STILL HAVE LOW MILES BUT ARE OUT OF WARRANTY. WE ARE PERSONALLY AWARE OF 5 ENGINE FAILURES IN THE SAME TIME FRAME OF OURS..ALL CUMMINS ISX15 MOTORS. THESE ENGINES ARE LEMONS. THE AFTER TREATMENT ENGINEERING IS A SHAM AND THE MOTORS ARE NOT EQUIPPED TO HANDLE THE STRAIN. THESE ARE PUTTING OWNER OPERATORS OUT OF BUSINESS AND ARE AN ENORMOUS SAFETY HAZARD. WHAT IS THE NHTSA PREPARED TO DO ABOUT THIS AS THE RECALL DUE TO THESE FUEL PUMPS SHOULD HAVE SPANNED MANY MORE YEARS AND THOUSANDS MORE VEHICLES. OUR ISSUE STARTED IN 2016 NOT LONG AFTER PURCHASE THROUGH PETERBILT AND CULMINATED WITH FUEL PUMP FAILURE/CARBON PACKING THIS PAST WEEK. WE WERE TOLD IT WAS WIRING HARNESS AND CUMMINS WAS TO COVER THE COST AS NO ONE SEEMED TO BE ABLE TO DIAGNOSE THE ISSUE. WE HAVE GONE FROM BEING TOLD IT WOULD BE A 3800.00 HARNESS TO BEING TOLD THAT THE TRUCK NEEDS A NEW MOTOR AND FUEL/OIL PUMP USING THE SAME FLAWED AFTER TREATMENT (THIS WERE THE CODES THAT HAD BEEN APPEARING THAT COULD NOT BE DIAGNOSED, NEVER WARNING FOR FUEL PUMP, PRESSURE ISSUES, ETC.) FOR AN ADTL COST OF $39,000 IN ADDITION TO THE SERVICE WORK ALREADY PERFORMED TO NO AVAIL. OWNER OPERATORS CANNOT STAY IN BUSINESS AS MANUFACTURERS BASK IN THE GLORY OF SALES AND MAINTENANCE PROFITS. SOMETHING HAS TO BE DONE. WE HAVE BEEN IN BUSINESS FOR 12 YEARS AND NOW WILL GO OUT OF BUSINESS AND JUST HOPE WE CAN SELL THIS LEMON. ACT NOW.

6 PETERBILT MY COMPANY OPERATES ARE 2014 AND 2015 CAR HAULERS. ALL ARE CONSISTENTLY DESTROYING REAR AXEL TIRES BOTH SIDES DRIVER AND PASSENGER (THREAD IS COMING OUT). DAMAGED SEEMS TO HAPPEN DUE TO OVERHEAT OF TIRES. WE TRIED USING DIFFERENT BRAND OF TIRES, BUT BLOW OUT DID NOT STOP. WE TOOK TRUCKS TO [XXX] AND THEY ARE UNABLE TO FIND ANY ISSUES. WITH EACH OCCURRENCE THREAD FROM DRIVE TIRE IS COMING OFF AND TIRE STILL HOLDS AIR. IT DAMAGES ALL LIGHTS ON TRUCK THEN IT DAMAGES MUD GUARDS AND BREAKS SAFETY WINGS ON THE TRAILER. EACH TIME COSTS ABOUT 2000$ PLUS ROAD SERVICE. ONLY SOLUTION WE FOUND AT THIS TIME TO RUN ALL POSITION TIRES ON DRIVE TIRES. SO FAR WE DID NOT HAVE ANY ISSUES FOR PAST 30 DAYS. LAST TRUCK WE PURCHASED FROM [XXX] , THEY AGREED TO SWAP TIRES AT THEIR OWN EXPENSE TO ALL POSITION... NO SOLUTION IS OFFERED TO US. WE HAVE LOST OVER $40,000 SO FAR ON BRAND NEW TRUCKS... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

6 PETERBILT MY COMPANY OPERATES ARE 2014 AND 2015 CAR HAULERS. ALL ARE CONSISTENTLY DESTROYING REAR AXEL TIRES BOTH SIDES DRIVER AND PASSENGER (THREAD IS COMING OUT). DAMAGED SEEMS TO HAPPEN DUE TO OVERHEAT OF TIRES. WE TRIED USING DIFFERENT BRAND OF TIRES, BUT BLOW OUT DID NOT STOP. WE TOOK TRUCKS TO [XXX] AND THEY ARE UNABLE TO FIND ANY ISSUES. WITH EACH OCCURRENCE THREAD FROM DRIVE TIRE IS COMING OFF AND TIRE STILL HOLDS AIR. IT DAMAGES ALL LIGHTS ON TRUCK THEN IT DAMAGES MUD GUARDS AND BREAKS SAFETY WINGS ON THE TRAILER. EACH TIME COSTS ABOUT 2000$ PLUS ROAD SERVICE. ONLY SOLUTION WE FOUND AT THIS TIME TO RUN ALL POSITION TIRES ON DRIVE TIRES. SO FAR WE DID NOT HAVE ANY ISSUES FOR PAST 30 DAYS. LAST TRUCK WE PURCHASED FROM [XXX], THEY AGREED TO SWAP TIRES AT THEIR OWN EXPENSE TO ALL POSITION... NO SOLUTION IS OFFERED TO US. WE HAVE LOST OVER $40,000 SO FAR ON BRAND NEW TRUCKS... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WE OPERATE 6 BRAND NEW PETERBILT 388 CAR HAULERS. EVERY TRUCK RANDOMLY BLOWS DRIVE INSIDE TIRE. ONCE TIRE BLOWS IT CAN BLOW ADJACENT TIRE. SO FAR WE HAD ABOUT 20 BLOW OUT IN 2 MONTH TIME. ONLY SOLUTION SO FAR WE FOUND WAS TO REROUTE EXHAUST PIPE TO THE SIDE AND REPLACE TIRES TO ALL POSITION TIRES. NO REIMBURSEMENT FROM PETERBILT. CALLED EVERY POSSIBLE NUMBER, BUT NO RESPONSE. THIS IS A FACTORY DEFECT AND EXHAUST CAUSES INSIDE TIRE TO OVERHEAT AND CAUSE BLOW OUT. TIRES BLOW EVERY 1000-3000 MILES. WE HAVE SPEND OVER 30,000$ ON ROAD CALLS AND TIRE REPLACEMENT SO FAR. *TR

WE OPERATE 6 BRAND NEW PETERBILT 388 CAR HAULERS. EVERY TRUCK RANDOMLY BLOWS DRIVE INSIDE TIRE. ONCE TIRE BLOWS IT CAN BLOW ADJACENT TIRE. SO FAR WE HAD ABOUT 20 BLOW OUT IN 2 MONTH TIME. ONLY SOLUTION SO FAR WE FOUND WAS TO REROUTE EXHAUST PIPE TO THE SIDE AND REPLACE TIRES TO ALL POSITION TIRES. NO REIMBURSEMENT FROM PETERBILT. CALLED EVERY POSSIBLE NUMBER, BUT NO RESPONSE. THIS IS A FACTORY DEFECT AND EXHAUST CAUSES INSIDE TIRE TO OVERHEAT AND CAUSE BLOW OUT. TIRES BLOW EVERY 1000-3000 MILES. WE HAVE SPEND OVER 30,000$ ON ROAD CALLS AND TIRE REPLACEMENT SO FAR. *TR

WE OPERATE 6 BRAND NEW PETERBILT 388 CAR HAULERS. EVERY TRUCK RANDOMLY BLOWS DRIVE INSIDE TIRE. ONCE TIRE BLOWS IT CAN BLOW ADJACENT TIRE. SO FAR WE HAD ABOUT 20 BLOW OUT IN 2 MONTH TIME. ONLY SOLUTION SO FAR WE FOUND WAS TO REROUTE EXHAUST PIPE TO THE SIDE AND REPLACE TIRES TO ALL POSITION TIRES. NO REIMBURSEMENT FROM PETERBILT. CALLED EVERY POSSIBLE NUMBER, BUT NO RESPONSE. THIS IS A FACTORY DEFECT AND EXHAUST CAUSES INSIDE TIRE TO OVERHEAT AND CAUSE BLOW OUT. TIRES BLOW EVERY 1000-3000 MILES. WE HAVE SPEND OVER 30,000$ ON ROAD CALLS AND TIRE REPLACEMENT SO FAR. *TR

2014 PETERBILT 388 CAR HAULER TRAVELING AT LOW SPEED 25 AT WORK ZONE. PASSENGER SIDE TIRE BLEW. ONLY WHEEL TIRE AND COUPLE WIRES DESTROYED THIS TIME. COST MY COMPANY $1000 TOWING, NEW WHEEL $350, NEW TIRES $800... AND COUPLE THOUSAND MORE ON OTHER ITEMS. TRUCK WAS ABOUT 76000 POUNDS. FRONT AXEL WAS 11800. *TR

2014 PETERBILT 388 CAR HAULER. PASSENGER SIDE 2014 MICHELIN XZA 275/70/R22.5 BLEW UP. TRUCK LOST POWER HOOD WAS RIPPED APART. WHEEL, DOOR, HOOD, ELECTRICAL, AIR INTAKE DESTROYED. WAITING FOR INSURANCE TO COVER ANY DAMAGE. SO FAR HAVE SPEND OVER 20,000$ PLUS ROAD SERVICE. TRUCK WAS TRAVELING 73 MPH FRONT WEIGHT 11200. TIRE HAD AROUND 18000 MILES. *TR

FRONT MICHELIN XZA 2 TIRE BLEW. IT WAS REPLACED 7/15/2014 AT 130,673. TIRE HAD LESS THEN 35,000 ON IT. TRUCK WAS DAMAGED WHEEL DESTROYED. HOOD DAMAGED, BUMPER DAMAGED. ROAD SERVICE REPLACED 1 TIRE AND WHEEL PAID $1500 TIRE SIZE 275/70/22.5 *TR

TL* THE CONTACT OWNS A 2014 PETERBILT 388 TRACTOR, EQUIPPED WITH MICHELIN XZ4 TIRES, SIZE 275/70/22 1/2 (NA). WHILE DRIVING APPROXIMATELY 67 MPH, THE FRONT PASSENGER SIDE TIRE EXPLODED AND DAMAGED THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED BACK TO THE LOT. THE TIRE FAILURE WAS NOT DIAGNOSED, BUT THE TIRES WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE DOT NUMBER WAS UNKNOWN. THE APPROXIMATE TRACTOR FAILURE MILEAGE WAS 122,000 AND THE TIRE FAILURE MILEAGE WAS 45,000.