1993 PLYMOUTH GRAND VOYAGER Complaints

CONSUMER STATES THAT WHILE DRIVING THE PASSENGER FRONT DOOR "FLEW" OPEN WITHOUT WARNING. DOOR HINGE CONNECTION IS VERY WEAK. DOOR IS "HANGING" DOWN FROM ASSEMBLY AND CAN NOT BE CLOSED PROPERLY OR LOCKED FROM THE INSIDE. *NLM

THE WELD POINTS WHERE THE HINGES WERE WELDED TO THE FRAME HAVE RUSTED SUFFICIENTLY TO RENDER THE RIGHT DOOR UNUSABLE. THERE IS A SERIOUS CONCERN WITH THE LEFT DOOR. *JG

CONSUMER BROUGHT VEHICLE IN FOR RECALL REPAIRS, 96V099. MECHANIC INFORMED CONSUMER THAT THE PREVIOUS OWNER TOOK CARE OF THE RECALL AND THAT THE PROBLEM CONSUMER WAS EXPERIENCING WAS A SENSOR, WHICH WAS NOT RECALL RELATED. CONSUMER WAS CHARGED FOR DIAGNOSTIC TESTING AND FEELS THIS IS AN ERROR SINCE NO TESTING WAS AUTHORIZED. CONSUMER REQUESTS REIMBURSEMENT. *JG

FUEL WAS LEAKING FROM VEHICLE. TOOK VEHICLE TO DEALER AND HAD TO REPLACE FUEL RAILS. CONSUMER ALSO, RECALL 00V286000 FOR 1996-2000 VEHICLES. *AK

VEHICLE WAS INVOLVED IN A FRONTAL COLLISION OF APPROXMATELY 30-35 MPH, WHICH DRIVER'S AIR BAG INFLATED VERY LITTLE AFTER IMPACT. DEALER AND MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

4 OF 6 FUEL INJECTORS LEAK FROM UNDER PLASTIC TOP OF INJECTOR NEAR THE ELECTRICAL CONNECTION. FUEL LEAKS AND POOLS ON TOP OF THE ENGINE. INJECTORS SEAL AND STOP LEAKING AS ENGINE WARMS UP. INJECTORS DO NOT LEAK IF THE OUTSIDE AIR TEMPERATURE IS NOT BELOW 50 DEGREES F. I TALKED WITH KENAI CHRYSLER, OUR LOCAL DEALER, AND WAS TOLD THAT THERE IS NO RECALL ON THE INJECTORS. I ALSO TALKED TO A LOCAL SHOP IN HOMER, AK, SUNNY SERVICE. THE OWNER, J. J. CARROLL, HAS SEEN THIS PROBLEM SEVERAL TIMES. I BELIEVE THIS COULD LEAD TO A FIRE IN THE ENGINE COMPARTMENT. AFTER THE CAR WARMS UP THE FUEL EVENTUALLY EVAPORATES FROM THE HEAT OF THE ENGINE, BUT THERE IS A STRONG GASOLINE ODOR IN AND AROUND THE CAR.

CONSUMER STATES BRAKE PEDAL IS HARD AND STIFF AND THE ABS AND BRAKE LIGHT STAYS ON. DEALER FOUND PROBLEM WITH HYDRAULIC CONTROL UNIT WHICH IS UNDER RECALL (96V099000). HOWEVER, AUTHORIZED DEALERSHIP WOULD NOT HONOR RECALL. CONSUMER HAD TO TAKE VEHICLE TO ANOTHER AUTHORIZED DEALERSHIP THAT WAS 200 MILES ROUND TRIP. *TT

SEAT BELT RETRACTOR ON DRIVER'S SIDE WOULD NOT RETRACT OR RELEASE INTERMITTENTLY. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

VEHICLE WAS REPAIRED UNDER RECALL 96 V 099 000. SINCE REPAIR OF VEHICLE BRAKES HAVE FAILED FOUR TIMES, ONE OF WHICH RESULTED IN A COLLISION. WHEN BRAKES WERE APPLIED PEDAL BECAME HARD. VEHICLE WAS SERVICED AT FRESNO CHRYSLER, IN FRESNO CA 559-225-2100. *AK

WHEN TURNING ON THE HEATING SYSTEM A FUEL SMELL CONSUMED THE PASSENGER COMPARTMENT THROUGH THE VENTS OF THE VEHICLE . DUE TO A LEAKAGE IN THE FUEL RAIL. DEALER HAS BEEN CONTACTED CONCERNING THIS PROBLEM. NLM