2001 PONTIAC MONTANA Complaints

INTERMITTENTLY WHEN AIR CONDITIONER IS OPERATING, WE GET A NOXIOUS CHEMICAL SMELL FROM AIR VENTS. ODOR LASTS FOR SEVERAL MINUTES. THIS IS NOT COMING FROM OUTSIDE BECAUSE WE ARE CIRCULATING INSIDE AIR. WE SEE NO PATTERN TO THIS. IT HAPPENS AT TIMES WHEN THE TEMPERATURE IS VERY HOT AND ALSO WHEN TEMPERATURE IS MODERATE. WE HAVE HAD THE MONTANA TO THE DEALER THREE TIMES. THEY CANNOT COME UP WITH ANY FIX. WE ARE CONCERNED THAT THIS MAY BE DETRIMENTAL TO OUR HEALTH. THE CAR STAYS COOL, IT'S JUST THE AWFUL SMELL. THE CABIN FILTERS ARE PERFECTLY CLEAN.*AK

WHEN THE VEHICLE IS PLACED IN GEAR THERE IS A SCRAPING NOISE. THIS NOISE WAS FIRST NOTICEABLE IN REVERSE ONLY. HOWEVER IT STARTED HAPPENING IN DRIVE AS WELL. ALSO WHEN BRAKING AT INTERSECTIONS THE ENGINE COMPLETELY DISENGAGES AND FREE WHEELS. THEN WHEN ACCELERATING AGAIN IT TAKES A SECOND OR TWO FOR THE TRANSMISSION TO RE-ENGAGE. THE DEALERSHIP HEARD THE NOISE AND EXPERIENCED THE PROBLEM. THEN THE TRANSMISSION COMPLETELY BROKE ON THEIR DRIVE DURING THIS PROBLEM'S EVALUATION. THE TRANSMISSION HAD TO BE REPLACED AFTER ONLY 41,500 MILES. THERE WAS INTERNAL METAL DEBRIS THROUGHOUT AS WELL AS LOTS OF GEAR DAMAGE. *PH

POWER SLIDING DOOR ON A PONIAC MONTANA MINIVAN: THE PASSENGER WAS OPENING THE POWER SLIDING DOOR FROM THE INSIDE AND GOT HER FOREARM TRAPPED BETWEEN THE INSIDE DOOR HANDLE AND THE SEAT (HAND PULLING BACK ON THE HANDLE AND AS THE DOOR SLID OPEN HER ELBOW WAS PINNED AGAINST THE SEATBACK). SINCE THE DOOR DID NOT AUTOMATICALLY REVERSE, IT CONTINUED TO OPEN AND EVENTUALLY BROKE ONE OF THE BONES IN JONIT'S FOREARM. *AK

WHILE DRIVING, THE FRONT END OF THE VEHICLE VIBRATED. *JB THE VEHICLE WOULD HESITATED WHEN ACCELERATED AFTER A COMPLETE STOP OR WHEN SLOWING. THE DEALER WAS UNABLE TO REMEDY THE PROBLEM. THE CONSUMER REQUESTED A REFUND FOR THE VEHICLE. OTHER PROBLEMS ARE AS FOLLOWED: THE VEHICLE FELT AS IF IT WAS GOING TO STALL WHEN IDLED DUE TO DIRTY INJECTOR(S), THERE WAS NOISE ON DRIVER SIDE OF THE ENGINE, THE HORN WOULD GO OFF BY ITSELF/DEALER UNABLE TO DUPLICATE, THE COVER IN THE REAR HATCH ON THE LEFT SIDE DID NOT STAY IN PLACE AND REINSTALLED THE PANEL DOOR, THE TRANSMISSION HAD NO REVERSE AND GRINDS WHEN PLACED IN FORWARD GEARS/REMOVED TRANSMISSION ASSEMBLY AND DISASSEMBLED, THERE WAS CLUNKING WHEN IN GEAR, THE PLANETARY GEARS WERE ROUNDED, THE TRANSMISSION ACTED AS IF IT WANTED TO TAKE OFF, FOUND A LOOSE MOTOR MOUNT ON THE DRIVER SIDE AND WAS TIGHTENED, THE STEERING WAS STIFF, AND WAS NOISY WHEN TURNING RIGHT. *SCC

THE BRAKES ON MY 2001 PONTIAC MONTANA WEAR OUT PREMATURELY. I HAD TO REPLACE THE FRONT PADS 3 TIMES IN 2 YEARS. IN EACH CASE THE INBOARD PAD HAD EXCESSIVE WEAR AND THE OUTBOARD PAD DID NOT. I HAVE BEEN INFORMED THE WEAR INDICATORS ARE ON THE OUTBOARD PADS, THIS PRESENTS A LACK OF WARNING TO THE DRIVER THAT THE BRAKES ARE IN NEED OF SERVICE. THE CALIPERS HAVE BEEN REPLACED ONCE AND THIS DID NOT SOLVE THE PROBLEM.*JB

THE SLIDING DOOR AUTOMATICALLY CLOSED WITHOUT THE CONSUMER PUSHING THE BUTTON. CONSUMER WAS INJURED. *JB

TRANSAXLE SLIPS IN STOP AND GO TRAFFIC AS ENGINE TEMPERATURE REACHES 200 DEGREES. SLIPPAGE INCREACES AS TEMPERATURE INCREASES OVER 200 DEGREES. DEALER CANNOT REPRODUCE DURING SHORT TEST DRIVES. VEHICLE ONLY HAS 35,000 MILES ON TRANSAXLE.

CONSUMER STATES THE VEHICLE WAS PARKED IN THE DRIVEWAY WHEN THE VEHICLE STARTED TO ROLL INTO THE STREET.

PROBLEMS WITH PASS SIDE POWER SLIDING DOOR. IT OPENS BACK UP AFTER IT IS ALMOST SHUT. DOOR DOESN'T UNLOCK ITSELF UNLESS YOU BANG ON IT. OPENED ONCE BY ITSELF. HAS BEEN IN FOR SEVICE 3 TIMES BUT NOT REPAIRED.TS

HORN SOUNDS ON ITS OWN WHILE DRIVING, WITH NO INPUT FROM DRIVER. ALSO, ALARM SOUNDS (USUALLY ONLY 4 TIMES) FOR NO REASON EVEN WHEN NO ONE IS NEAR VEHICLE IF KEY IS USED TO LOCK THE DOORS, AS IF IT WAS SUSCEPTIBLE TO ELECTRICAL INTERFERENCE. DEALER CAN NOT FIND CAUSE OF PROBLEM. DT