1996 PONTIAC SUNFIRE Complaints

DEC 19, 2001 THE RACK AND PINION IN THE CONSUMER'S 1996 PONTIAC SUNFIRE FAILED. *NM THE CONSUMER THEN RECEIVED A RECALL IN THE MAIL AND REQUESTED REIMBURSEMENT WHICH WAS APPROVED. IN MARCH THE STEERING RACK AND PINION FAILED AGAIN TO THE POINT THE GEAR WAS STRIPPED AND THE HOUSING WAS CRACKED. THE CONSUMER REQUESTED A REFUND. *JB *NM

WHEEL BEARING SEEMS TO BE GOING BAD. THE MOTOR HAS BEEN JUMPING WHEN I TAKE OFF FROM A STOP LIGHT. I THINK THE MOTOR MOUNTS MIGHT BE BAD. THE CAR IS A 96 AND IT HAS 109,000 MILES ON IT. *AK

WHILE DRIVING ACCELERATOR PEDAL WAS STUCK AND WENT TO THE FLOOR. CONSUMER APPLIED THE EMERGENCY BRAKE AND WAS ABLE TO PULL OVER TO THE SHOULDER. THEN, HAD THE VEHICLE TOWED. *AK

WHILE ON THE STREET VEHICLE WAS IN PARK AND THE KEY WAS TAKEN OUT OF THE IGNITION SWITCH. THEN, VEHICLE CAUGHT ON FIRE BEHIND THE STEERING WHEEL. BLACK SMOKE. AND LARGE FLAMES APPEARED. FIRE DEPARTMENT SHOW UP TO EXTINGUISH THE FIRE. DEALER NOTIFIED. *AK

MY INCIDENT IS NOT A FAILURE, BUT A CONSTANT PROBLEM. SINCE I BOUGHT THE CAR USED IN DECEMBER OF '03, THERE HAS BEEN MAJOR HESITATION WHEN IDLE OR ACCELERATING. IN FEBRUARY OF '04 MY FUEL PUMP DIED, LEADING ME TO ASSUME THIS WAS THE PROBLEM. I PURCHASED A NEW FUEL PUMP AND INSTALLED IT. I JUST HAD TO REPLACE MY FUEL PUMP AGAIN BECAUSE I WAS BEGINNING TO HEAR A HIGH-PITCHED SQUEAL FROM THE PUMP AND THE HESITATION HAD WORSTENED (MAY '04). THESE PROBLEMS ARE STILL THERE, LEADING FRIENDS TO BELIEVE THAT THIS IS A HEAD/HEAD GASKET PROBLEM INSTEAD OF A DIRECT FUEL SYSTEM PROBLEM. MY CAR HAS ALREADY STALLED IN TRAFFIC DUE TO THIS ON 4 DIFFERENT OCCASIONS (ALL WITHIN LESS THAN A WEEK SINCE THE FUEL PUMP REPAIRS). I AM NOW NOT ABLE TO USE MY CAR FOR MORE THAN SMALL ROUND TRIPS OUT OF FEAR OF MY CAR STALLING AND LEAVING ME STRANDED. *MR

MY VEHICLE HAS A VERY STRONG GAS ODOR. THE PROBLEM IS WITH FUEL INJECTORS. MECHANIC STATES THE CAR COULD CATCH FIRE AND WILL NOT PASS INSPECTION. THE FUMES ARE SO STRONG IT CAUSES THE DRIVER TO FEEL ILL AND COMPLAINS OF HEADACHES AND COULD POSSIBLY BECOME DIZZY CAUSING DRIVER TO LOSE CONTROL OF CAR. VERY DANGEROUS!!

WHILE DRIVING 25 MPH THE VEHICLE CAUGHT FIRE UNDER THE GLOVE COMPARTMENT. DUE TO THE INTERIOR DAMAGE THE VEHICLE WAS TOTALED. THE CAUSE OF THE FIRE HAS YET TO BE DETERMINED. NO INJURIES REPORTED. PLEASE PROVIDE ADDITIONAL INFORMATION. *NM

I PURCHASED A 1996 PONTIAC SUNFIRE IN JULY OF 2003. I PREVIOUSLY OWNED A 1997 SUNFIRE AND DIDN'T HAVE ANY PROBLEMS LIKE THIS. THE MOST SERIOUS ISSUE IS WHEN I TURN MY HEADLIGHTS ON, THE FUSE BLOWS AND THE TAIL LIGHTS AND THE DASH LIGHTS (LIGHTS FOR SPEEDOMETER, TACHOMETER, FUEL AND TEMP GAUGE) DO NOT WORK. I ALMOST GOT INTO AN ACCIDENT WHEN MY LIGHTS AND DASH FAILED ME. WHEN I WAS TRYING TO REPLACE THE FUSE SPARKS FLEW OUT AND THE FUSES BLEW IMMEDIATELY. I FEEL IT IS A MANUFACTURER DEFECT. IT IS GOING TO COST ME A LARGE AMOUNT OF MONEY TO HAVE THIS FIXED. GM ALSO WONT GIVE ME THE TIME OF DAY WHEN I CALL AND COMPLAIN. I THINK THAT THERE SHOULD BE AT LEAST AN INVESTIGATION. ( * NUMBER OF FAILURES IS APPROXIMATE THERE ARE MORE. I THOUGHT IT WOULD BE FAIR TO STATE THE VERY LEAST AMOUNT I HAVE COUNTED.) ALSO MY VEHICLE HAS BEEN INOPERABLE FOR SEVERAL WEEKS. (THIS VEHICLE HAS 106,000 MILES ON IT) THANK YOU FOR YOUR TIME. *JB

THE VEHICLE WAS PARKED AND THE CONSUMER NOTICED OIL WAS LEAKING FROM UNDERNEATH THE VEHICLE. THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER FOR ANALYSIS AND THE MECHANIC NOTICED THAT THE HEAD GASKET NEEDED TO BE REPLACED DUE TO DETERIORATION. *AK THE VEHICLE HAD ALSO BEEN LOSING COOLANT FOR THE PAST YEAR AND EXHIBITED A COOLANT SMELL. *SC *JB

I WAS A PASSENGER IN THE CAR, SO I DON'T KNOW SPECIFIC MILEAGE, OR VIN NUMBER. THE CAR HAD APPROXIMATELY 80,000 MILES ON IT. THE ACCIDENT OCCURRED ON JULY 5, 2002. IT WAS A FAIRLY LOW SPEED CRASH, MYE ESTIMATE IS WE WERE GOING ABOUT 30 MPH AT IMPACT. WE STRUCK THE CAR IN FRONT OF US. THE AIRBAG DEPLOYED IN MY FACE. I WAS WEARING MY SEAT BELT AND WAS NOT SITTING PARTICULARLY CLOSE TO THE AIRBAG. THE FORCE OF THE IMPACT FROM THE AIR BAG, BROKE MY NOSE AND RESULTED IN PERMANENT DAMAGE TO MY EYES. I WAS THE ONLY PERSON INJURED IN THE ACCIDENT.