2004 PORSCHE CAYENNE Complaints

WHILE DRIVING CHECK ENGINE LIGHT ON AND VEHICLE LACK POWER. DROVE TO INDEPENDENT REPAIR SERVICE, REPLACED 8 IGNITION COILS AND 8 SPARK PLUGS TO CORRECT PROBLEM. ALL IGNITION COILS CRACKED. *TR

TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE STALLED AND FAILED TO RESPOND WHEN CONTACT ATTEMPTED TO ACCELERATE. THE VEHICLE ACCELERATED AT ONCE AND JOLTED RAPIDLY. THE CONTACT STATED THAT THE FAILURE RECURRED EVERY TIME VEHICLE'S SPEED WAS AROUND 20 MPH. THE CONTACT WAS ABLE TO AVOID THE FAILURE IF THE VEHICLE MAINTAINED A HIGHER SPEED. AFTER SEVERAL DAYS, THE VEHICLE WAS NOT ABLE TO BE DRIVEN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIR; HOWEVER WHEN NOTIFIED, THEY STATED THAT THE FAILURE COULD BE RELATED TO A FAILED DRIVE SHAFT. THE MANUFACTURER WAS NOT MADE AWARE. THE FAILURE AND CURRENT MILEAGES WERE 94,000.

PORSCHE KNOWINGLY MANUFACTURED CAYENNE MODEL VEHICLES WITH PLASTIC COOLANT TUBES THAT DEGRADE AND FRACTURE CAUSING ENGINE COOLANT TO LEAK INTO THE ENGINE, POTENTIALLY LEADING TO SIGNIFICANT ENGINE DAMAGE. PORSCHE HAS KNOWN ABOUT THIS DEFECT AND FAILED TO MAKE CONSUMERS AWARE OF THE POTENTIAL FAILURE DESPITE THE RISK TO THE OWNERS SAFETY AND POCKETBOOK. *KB

TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, AN OVERHEATING INDICATOR LIGHT BEGAN TO ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN DIRECTLY TO AN INDEPENDENT REPAIR SHOP WHERE ENGINE COOLANT WAS ADDED TO THE VEHICLE. WHILE ADDING THE COOLANT, THE TECHNICIANS NOTICED THAT THE COOLANT WAS LEAKING OUT THROUGH ITS PLASTIC TUBING. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE THE PLASTIC TUBING FOR THE ENGINE COOLANT WAS BEING REPLACED WITH ALUMINUM TUBING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 54,500.

THE CONTACT OWNS A 2004 PORSCHE CAYENNE TURBO. THE LEFT FRONT AIR SUSPENSION COLLAPSED WHILE DRIVING AT 20 MPH. THE AIR SUSPENSION BAG ALSO EXPLODED WHICH CAUSED THE VEHICLE TO MOVE UNCONTROLLABLY TO THE LEFT. THE CONTACT WAS ABLE TO DRIVE TO THE DEALER WHO STATED THAT IT WAS A FAULT OR DEFECTON TO THE FRONT LEFT SIDE SUSPENSION AIR BAG. THE VEHICLE WILL BE REPAIRED; HOWEVER, THE SUSPENSION WAS NOT COVERED BY THE WARRANTY AND PORSCHE HAVE NO INTEREST IN HELPING. THE FAILURE MILEAGE WAS 60,000 AND WILL COST APPROX $4,000 TO REPLACE THROUGH A PORSCHE DEALERSHIP. *TT

COOLANT PIPE START TO FAIL FOR THE MODEL YEAR 2004-2006. THE MATERIAL FOR COOLANT PIPE WAS MADE OF PLASTIC AND IT RESULTED IN A DISINTEGRATION OF PIPE OVERTIME DUE TO TEMPERATURE CHANGES. PORSCHE TECHNICIANS IDENTIFIED THIS ISSUE AND PORSCHE ENGINEERS ALSO IDENTIFIED THIS ISSUE. THEY CAME UP WITH A REPLACEMENT PART WHICH IS MADE OF ALUMINUM TO MITIGATE DAMAGES TO THE ENGINE DUE TO SUDDEN FAILURE OF COOLANT PIPE. IF THE PIPE BUSTED, IT WILL CAUSE THE VEHICLE TO FAIL DURING OPERATION AND MAY RESULT IN A HAZARDOUS INCIDENT CAUSING ENVIRONMENTAL ISSUE AND POSSIBLY INJURY TO THE DRIVER AND ITS PASSENGER. IT IS HIGHLY RECOMMEND THAT PORSCHE TO RECALL THIS PRODUCT AND REPLACE IT FOR ALL DEFECT TO PREVENT FURTHER INCIDENT. ADDITIONALLY, THIS IS AN ENGINEERING FLAW SO THE COST TO REPAIR, REPLACE OR TO UPGRADE CANNOT BE THE OWNER RESPONSIBILITY. *TR

TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. WHILE DRIVING APPROXIMATELY 50 MPH, A SEVERE VIBRATION OCCURRED ALONG WITH A SIMULTANEOUS BANGING SOUND OUTSIDE OF THE VEHICLE. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN MOTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY INFORMED THE CONTACT THAT THE CENTER DRIVE SHAFT BEARING WAS FAULTY AND WOULD NEED TO BE REPLACED. THE CONTACT SCHEDULED AN APPOINTMENT WITH THE DEALER FOR THE REPAIR. THE FAILURE MILEAGE WAS 50,800. UPDATED 5/24/11 *CN UPDATED 06/06/11

WATER PUMP FAILURE. ORIGINAL PART HAS PLASTIC IMPELLER AND HIGH FAILURE RATE DEALER WII REPLACE WITH UPGRADED PART BUT NO REEMBURSEMENT. *TR

MAIN DRIVE SHAFT CENTER BEARING FAULTY, FAILURE WITHOUT NOTICE, CAUSING SEVERE VIBRATION IN DRIVE TRAIN. DEALER WILL REPLACE WITH UPGRADE PART WITH NO REIMBURSEMENT FROM MAKER. *TR

ORIGINAL ENGINE COOLING TUBES DEFECTIVE, PLASTIC COMPOSITION.CAN FAIL WITHOUT INDICATION CAUSING OVERHEATED ENGINE AT ANY TIME. REPLACEMENT PARTS ARE UPGRADED TO METAL. NO RECALL AND MAKER WILL NOT REEMBURSE DAMAGE OR REPAIR. *TR