2020 PORSCHE TAYCAN Complaints

I was charging at a Tesla Supercharge using the OEM Porsche converter and my car experienced a catastrophic electrical fault. The charge completed but the charger was hard to pull out and then my car had battery fault errors and said it needed immediate service. I took it to the dealer and they pulled these error codes and said severage battery componets had failed including a failed high-voltage battery controller, which is mounted on top of the HV battery and the high-voltage booster (which distributes DC voltage). Porsche is not claiming responsibility and presented me a $17k bill to replace. I'm concerned the temp sensors went off and that this could have led to a fire so I wanted to flag to your office. Here are the fault codes provided from Porsche: B192BF0 - High-voltage DC charger (booster) in wrong mode P33E500 - Quick battery charging (DC), Charge stn., initialization error U15AB00 - Quick battery charging (DC), Communication error between vehicle and charging station U15AE00 - Quick battery charging (DC), Charging station communication failure U15B300 - Fast battery charge (DC) – cable testing error P33F000 - High-voltage system activation, Malfunction B1A88F0 - Actuator for right charge port door – travel error U15AC00 - Signal damping log, Malfunction B200000 - Control unit – function restriction U140900 - Internal temperature measurement, Implausible signal

While driving the vehicle, an error message (Engine Control Error) will pop up. The car will come to an immediate stop…forcing the driver to shut off car and restart it. This has happened multiple times and in one instance occurred on the highway. It almost caused a catastrophic accident as the car came to an abrupt stop in the middle lane of the highway. I’ve taken the car to the dealership multiple times and they have not been able to fix it. I’ve read many Taycan message board posts and it seems like this is a common issue amongst multiple years of Taycans. This is a serious safety issue and a recall should be issued with a remedy for this. Due to this, I cannot drive the car on the highway as I’m scared of it happening randomly. This is a known issue and one that should be recalled and handled appropriately by Porsche.

The EV had a “Engine Control Error” and suffered engine failure on Jan 6th 2026 at 5:17pm. It happened out of nowhere without any warning at low speed.

Made a turn into a street and driving at slow pace (about 20mph) and the vehicle suddenly shuddered and came to complete stop and died in the middle of the road. I had no time to pull over. No warning. It just happened. Fortunately, no oncoming or cars behind me. There was a red dash board warning “Engine Control Error”. I turned off the vehicle and restarted.

This vehicle can not be driven on straight roads of freeways without the "take over steering warning" engaging. This is problematic, this morning on icy roads driving on straight roads the warning engaged, braked and cut power and put the vehicle into a slid on icy roads. This warning also happen frequently on freeway driving, suddenly braking and almost causing drivers behind the vehicle to react to the sudden braking putting this vehicle in jeopardy of rear end collisions or other possible accidents.

The vehicle experiences a sudden and dangerous malfunction while driving. Without any prior warning, the vehicle begins to shake and then immediately brakes on its own, coming to an abrupt stop in the middle of traffic. Only after the vehicle has already braked and shut down does an “Engine Control Error” message appear on the display. There is no advance alert and no time for the driver to react or move out of traffic. This is exceptionally concerning especially as this vehicle was being used a primary mode of transportation for my 2 young toddlers who were present in the vehicle during these failures. The vehicle was purchased directly from Porsche as a Certified Pre-Owned vehicle in June 2025, and was represented by Porsche as having passed all safety and mechanical inspections at the time of purchase. Despite this, the vehicle has continued to experience catastrophic failures. Following the initial shutdown incident, the vehicle was towed to Porsche for service on September 2. Porsche stated that the issue had been repaired and assured that the vehicle was safe to operate. However, on September 29, the same failure occurred again. The vehicle shook, abruptly braked in active traffic, shut itself down, and only then displayed the engine control failure message. This shows that the underlying defect was not corrected and continues to pose a serious safety hazard. The problem is severe, unpredictable, and reproducible. It places the driver, passengers, and surrounding motorists at immediate risk because the vehicle becomes immobilized in traffic with no prior warning and no ability to pull over safely. The vehicle has been inspected by Porsche technicians, but the root cause remains unknown, and Porsche has been unable to provide a successful repair or assurance of safety. This pattern strongly indicates a critical defect in the engine control or power-management system that renders the vehicle unsafe for public road use.

Just took the car back from the dealer after a major recalls and EV motor Failure

During my ownership, the vehicle experienced multiple dangerous failures. It suddenly lost power while driving with my 2-year-old child onboard, and on another occasion the steering wheel locked for several seconds on the freeway. The car has had numerous recalls, and the dealer later confirmed an EV motor failure but offered no buyback. These defects created serious safety risks and caused significant financial loss, which I believe requires NHTSA’s attention.

The contact owns a 2020 Porsche Taycan. The contact received notification of NHTSA Campaign Number: 24V732000 (Electrical System) after owning the vehicle for a week. The vehicle was taken to the dealer, who then stated that because the vehicle had an aftermarket charger inside, the repair could not be performed unless a charger was purchased from the dealer. The dealer confirmed that the aftermarket charger would not perform as needed, and the recall repair would not be successful. The vehicle was not repaired. The manufacturer was not informed of the issue. The contact had not experienced a failure.

Taycan HV battery cells/modules going bad causing the car to be a brick and not drivable and dangerous. Porsche is replacing the failed cells but it can be an ongoing issues that can spread to other cells.