2016 RAM 1500 Complaints

Lost acceleration, check engine light and warning light came on ‘Service Electronic Throttle Control’ Diagnostic code P0336 Crankshaft Position Sensor A Circuit Truck has issues starting, once running, it idles rough and is in limp mode Appears to correspond with Safety Recall W68 / NHTSA 20V-475

The contact owns a 2016 Ram 1500. The contact stated that while driving at an undisclosed speed, the ABS and brake warning lights illuminated. The vehicle was taken to an independent mechanic where it was determined that the ABS module needed to be replaced. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 42,000.

the a pillar on the right side of the windshield is rusted and the trim falling off which could rollover safety and parts flying off and possibly striking other vehicles on the road.

ABS module on the vehicle has failed. Took it to be diagnosed and was told the code was that there was an internal component failure and the module would need to be replaced as it is a common issue. Intermittent service power steering message while driving and power steering stops working making vehicle has to maneuver at low speeds. Power steering returns after the vehicle is shut off and restarted. Have not been able to be reproduced for dealer to diagnose.

The last few weeks I’ve noticed my truck hasn’t been right. With some online investigation I realized the misfire code I been getting is related to a cam and lifter issue. Based on the forms I’ve viewed. The ram 1500 with the 5.7 engine has a known issue that the cams and lifters wear down after a very short period of time. I’ve seen cases of 60k miles up to 120k miles. This is a crucial part of the vehicle and there’s no reason this should only last for a short period of time. Especially with all these people who claim had to spend thousands of dollars on repairs or sometimes new engines entirely. I have older vehicles from the 2000’s with more miles than never have had issues like this. This is either a bad part that was produced or bad material of some sort. I’m hoping I’m not the only one to complain about this and we can try to resolve this issue.

In May/June 2023, my ABS, Emergency Brake, and traction control lights all came on on my dashboard. I received a notice when starting the car that I need to service electronic braking system and service trailer brake system. At the same time, my cruise control stopped working. I took my vehicle to Hendrick Dodge in Cary, NC, on June 7, 2023, and received the following diagnosis: C220-49-Anti-lock brake module internal - internal electronic failure. The receipt said "the abs module is dead recommend replacing the hcu and abs module." It was an expensive repair and the advisor handling my visit that day assured me that my brakes still work and the vehicle is safe to drive. I also asked if safe to pull my horse trailer and he said yes. I decided a few months later to get the repair done and tried to order the module through the Hendrick Parts department. They indicated that there was an engineering hold on the part and they could not order it. The hold went until early (perhaps February or March?) 2024. So I made a note to call back in March - which I did, but at a different dealership parts department (John Heister in Sanford, NC). At that time, they said the hold was until May 2024. So I called back in May and they indicated the part is now available, but the vehicle has to come back in to be inspected and take pictures and ensure they order the correct part. I took the vehicle on May 21, they confirmed the issue and ordered the parts. The parts did not come in until August, when I had the following replaced for a cost of $2770 on August 30, 2024 to replace the ABS module and install anit-lock brake control. Earlier this month my husband who owns a 2022 Ram 1500 received a notification for a recall for the same issue on his truck. Due to my experience, I believe the 2016 RAM 1600 has the same issue and a recall should be extended to include 2016 models.

There is a problem with the rackin pin power steering. My vehicle steering wheel will just stop turning without a struggle and then kick back in.

The ABS module has been out on my truck for almost a year and RAM still hasn't released a part. According to forums on the internet for this year model and others, this has become a common issue. I am driving my truck without the ability to use my ABS system. I have called RAM customer service and my local dealer(s) several times and a part is not available. I can't get a response from my case worker with RAM. This should be a recall issue.

The automatic brake system (ABS) module has failed. Warning lights on the dash are for brakes, traction control and automating braking. The lights are frequent but not constant. When lit, the vehicle loses 4 wheel drive and cruise control. Sudden loss of cruise control at highway speeds is a safety hazard. Loss of 4 wheel drive in inclement weather is also a hazard. The truck was inspected by a Ram dealer and the ABS module was identified as defective. This was in June of 2024. As of today the replacement module from Mopar is still unavailable and currently showing “under engineering review” in the manufacturers system. The availability date for the part has been “rolling” since my initial issue in June. The Ram dealership and the Ram Customer Service team cannot provide a solution or a firm date of resolution. There is a recall for the same make and model for newer versions of my vehicle but not my 2016 Ram 1500. The Customer Service rep stated my truck was suitable to drive other than poor weather conditions. The rep did agree that the vehicle was unsafe in this condition.

There was a recall for High Pressure Fuel Pump. Part ended up exploding and debris getting into fuel system, which made engine faulty. Found out just today there is a recall for ABS system, which ABS light has been on for 3 months The vehicle has shut off on the freeway 5 times, always on the freeway which was dangerous. The vehicle has been inspection and worked on by Ram dealership but they cannot find remedy for the vehicle. Yes the engine light was on and the ABS light is on currently. After new engine and PCM was installed the engine light went off but vehicle shut off last night which was (10/17/2024) now there is a red light blinking