2015 RAM 1500 Complaints

I am submitting this complaint to report a serious safety defect involving a high-pressure fuel system failure that occurred shortly after recall service was performed by an authorized dealership. The failure created a significant risk of engine compartment fire and potential loss of vehicle control. On March 25, 2025, my vehicle underwent recall service at Hall Ram Dealership for replacement of the high-pressure fuel pump. This repair required removal and reinstallation of the high-pressure fuel supply lines. These lines are torque-to-yield, single-use components that must be replaced once removed to ensure proper sealing under high operating pressures. On April 7, 2025, while driving at highway speed, the high-pressure fuel line connected to the pump suddenly ruptured. This resulted in an uncontrolled release of fuel into the engine compartment, creating an immediate safety hazard. Atomized fuel was exposed to high-temperature engine components, significantly increasing the risk of ignition and fire. The failure also posed a risk of sudden engine power loss. The vehicle required emergency towing. A review of the March 25 service invoice shows no documentation that the high-pressure fuel lines were replaced. This strongly suggests the original single-use lines were reused, contrary to OEM standards and accepted repair procedures. Reuse of these components can lead to sealing failure, fatigue, and rupture under pressure. This incident raises concerns regarding compliance with federal safety regulations, including 49 U.S.C. Chapter 301 and FMVSS No. 301 governing fuel system integrity. A fuel line rupture under normal operating conditions indicates a critical safety defect and possible improper execution of a recall remedy. I request that NHTSA investigate whether authorized repair facilities are properly following required procedures during recall repairs, including replacement of single-use fuel system components.

I have a 2015 dodge ram 1500 slt 3.6 vvt I purchased the vehicle.I paid full price $18,768 when I first got the truck it has being ticking noise and in has a faulty oil pump also the truck was infected with roaches. I got the truck from dodge ram dealership in morrow ga they just vacuum out the roaches.I bring having problems with this truck since I got it.Any solution y’all going to fix this problem

The contact owns a 2015 Ram 1500. While driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the “Service Electronic Throttle Control” message was displayed, and the vehicle went into LIMP Mode. While attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the residence. The contact stated that the failure had occurred while traveling out of state and was five hours away from home. The vehicle was towed to the dealer, where it was diagnosed with a cracked tone wheel. The contact was informed that the tone wheel needed to be replaced. The vehicle was repaired. Additionally, the contact referenced an unknown recall with a similar failure; however, the VIN was not associated with a recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 138,000.

Traveling at 60MPH on a highway in the middle lane when my truck lost complete power steering. It felt as if I had zero control over my truck at a high speed. I managed to slow down and made it onto the shoulder without crashing. Had my truck towed to Dodge Chrysler ram dealership. Before dropping it off I saw there were at least 10 recalls for my truck that I mentioned to technician. They plugged my truck into their scanner and the technician got in my truck and drove it right into the shop bay. I’m unsure how he was able to maneuver the truck after plugging it in. After diagnosing the problems with my truck they called to tell me that none of the recalls affected my vehicle and they weren’t repairing anything. My gas tank also detached from my vehicle while driving and I knew that was covered. Over a week arguing and proving they are responsible to repair it. They repaired the gas tank and refused to look into the rest of recalls. I could’ve died and hurt many others driving by the loss of power steering traveling at that speed. Truck was fine then randomly loses full control. There are open recalls for my exact truck with this exact issue. The dealership refused to acknowledge any of it.

The contact owns a 2015 Ram 1500. The contact stated that while driving approximately 80 MPH with cruise control engaged, the contact heard an abnormal sound. Upon deactivating the cruise control feature, the vehicle stalled. There was no warning light illuminated. The contact was able to pull over to the side of the road, and after opening the hood, the contact noticed an oil leak. The vehicle was towed to Patriot Diesel, where it was diagnosed and determined that the EGR system and fuel system failures had caused catastrophic engine failure, and there was a hole in the engine. The mechanic determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to NHTSA Campaign Numbers: 22V406000 (Fuel System, Diesel) and 19V757000 (Engine and Engine Cooling). The manufacturer was notified of the failure and informed the contact that the dealer was at fault. No assistance was provided. The failure mileage was approximately 115,000.

The ABS module failed in June of 2025. Ram originally told me the part was on back order 6-8 months. In December they said there were 100 ABS modules on order for our area. In January 2026 they informed the mechanic that is doing the work that there is still parts on back order and it could be another 1-2 months. Today 2/25/26 the mechanic was told there are 265 modules on back order and it can be another 2-3 months. The truck now has a throttle body control issue that is stemming from the ABS issue. The truck is not operable at the moment because of this back order. I have been waiting for 7 months for this part and there are no alternatives on the market. If Ram does not get a part available for me I will either have to find a used one that hopefully isn't going to fail or be out of a $50,000 truck. This is a problem that many people have had according to all of the RAM forums. RAM needs to find a solution because the consumer already paid for the vehicle so parts should be available.

Code P200A and P2D2D showed up, linking to an intake manifold issue. After researching, shows connected to Recall VB1. After speaking with FCA Recall department, they said that the recall was completed. To my knowledge, the vehicle is having the same related issues as the state previous to the recall. FCA will not initiate another recall on my vehicle to resolve the issue the VB1 recall was supposed to address.

The contact owns a 2015 Ram 1500. The contact stated that while driving approximately 45 MPH, the vehicle started shaking and lost motive power. The ETC warning light illuminated, and the message "Service Electronic Throttle Control" was displayed. The vehicle was stopped in a safe location and inspected. The vehicle was turned off and restarted, but it was difficult while cranking over. The vehicle was taken to a dealer, where it was diagnosed, and determined that the tone wheel had delaminated and needed to be replaced. The vehicle was not repaired. The contact associated the failures with NHTSA Campaign Number: 20V475000 (Engine and Engine Cooling). The manufacturer was notified of the failure. The failure mileage was approximately 200,000.

My electric power stear started to go in and out as I was driving. It got very hard to stear and as I was trying to turn would cone back on causing me to drive off the road into a ditch. Now dose not work at all

I have a 2015 Ram 1500, my experience is not unique and this issue is well known online. The ABS module (Part No: 68228991AD) is no longer working and my truck has been having an issue with this for about 3 years. The Parts departments in dealerships will typically say that the manufacturer is "looking" for a new contract parts supplier and say that a certain date is upcoming, but it always gets pushed further into the future. I have been without ABS for a long time for this reason. Since I have moved around, I have been unable to stick with a certain parts department for an extended period of time, but I have had this part on order with the current dealership near me for over 5 months, with no status update other than its on order. This seems like a large safety issue to me and I would like the regulator to do something about this.