2015 RAM 1500 Complaints

The contact owns a 2015 Ram 1500. The contact received a notification of NHTSA campaign number: 21V632000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and informed the contact that the part was not yet available. The manufacturer was notified of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2015 Ram 1500. The contact stated that while starting the vehicle, there was an abnormal ticking sound coming from the engine. After driving the vehicle for a while, the ticking noise started to fade and was less noticeable. The contact took the vehicle to an independent mechanic to be diagnosed. The contact was informed that the exhaust manifold bolts were defective, causing an exhaust leak around the gasket. The mechanic recommended that the manifold be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

I bought this vehicle used in December 2019 from J.L Freed Honda in Montgomeryville Pa. Truck had about 78,000 miles on it. I noticed a ticking noise coming from the engine when it was started cold. Salesman advised that it was nothing to worry about and is common with RAM trucks until they warm up. Sure enough within a minute the ticking subsided. I purchased the truck and the ticking has continued when started cold. I recently had the truck inspected and was advised that the ticking was a manifold exhaust leak that will only get worse over time and is an emissions issue as well as a safety issue. I started to research the issue on line and found that the leak is caused by broken manifold bolts. It is well documented in online Forums for Dodge RAM and it appears to be a known issue with the Manufacturer but no resolution or recall has been issued. It has obviously caused much frustration for RAM owners of the 5.7 Hemi engine as detailed in the RAM Forum. The repairs are costly and with the problem being as common as it is with no resolution or help from the manufacturer, please review for possible recall.

My vehicle has been wait-listed for the EGR re-call parts since August 17, 2020. The dealer claims they receive 1-2 repair kits a week. Other dealers within 50 miles say the same. As a CA resident, I can now no longer register my vehicle until the VB1/NHTSA 19V-757 repair is complete. In CA, a smog test is required every 2 years, I have completed this (PASSED), but my registration, although paid in full, has been held pending the re-call repair. I currently have an appointment to hopefully secure another 60 registration extension, otherwise, my vehicle would be subject to citation and/or impound based on incomplete registration. The dealer informed me that I am approx. 3-4 months away in the que for repairs. Basically, I need relief from the mandate within CA based on the unforgiving and unrealistic policy that California Air Resources Board(CARB) and DMV have imposed and lack of oversite related to production/distribution of the re-call part kits.

Manifold bolts have sheared causing exhaust leak while occasionally enters cab area when not in motion. Issue was brought to the attention of dealer on 4 different occasions when under warranty and no repair was made. Ram customer care was contacted now that the power train warranty has expired and no solution was offered. This is a well documented issue and I am concerned about the safety risk.

Electronic fuel sensor failed at 47k miles. Sensor contact wears away from friction and falsely reports a empty tank, when fuel is present. Vehicle operator has no idea how much fuel is in the tank at any time. Thousands of testimonials online of the same issue. Ramforum.com, ramforumz.com and Youtube.com all have complaints and how to videos.

The contact owns a 2015 Ram 1500. The contact stated that the coolant level was low. The contact received notification of NHTSA campaign number: 19V757000 (Engine and Engine Cooling). The vehicle was taken to the local dealer who stated that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue, but no further assistance was provided. The contact stated the parts were back ordered for approximately three years. The approximate failure mileage was 100,000. Parts distribution disconnect.

About a dozen times the accelerator pedal sticks to the floor. The pedal stays depressed even when my foot is not on it anymore. The vehicle races uncontrollably as fast as it can. Occasionally a red warning light with a thunderbolt displays on the dash. I have not taken it to the dealer because it is no longer under warranty but, I have replaced the throttle body and it made no difference. Also I have checked the NHTS website for recalls. My original factory floor mat does not go under pedal so as not to be the culprit. When the pedal sticks to the floor I must place the toe of my shoe on the side of the the accelerator pedal and lift it up. This stops the acceleration and the red warning light goes off. The sticking pedal has occurred about a dozen times and has only happened over the last 18 months. The safety problem is becoming more frequent. On Monday while taking my daughter to school I pulled out onto the highway from a stop sign and quickly accelerated. Upon reaching the 45 mph speed limit I let off the accelerator pedal but the pedal stayed depressed. My Ram truck quickly accelerated to 72 mph all the while I had to weave around a car to avoid an accident. The warning light did not come on this time. I have tried braking but this only slows the vehicle slightly. When releasing the brake the truck accelerates full throttle again. Lifting up on the accelerator pedal is the only thing that works. The sticking pedal has only occurred when accelerating rapidly.

Since purchasing the truck early this year, the engine has stalled while in motion 5 times. Each time I was able to shift into neutral and start the engine again, and stay in motion. I have taken the truck to 3 different mechanics and none are able to figure out the source of the stall. My safety is at risk because engine control is lost while in motion, if I had to accelerate to avoid collision I would be unable to. Although the engine has started again every time, I am afraid that one time it might not. No warning lamps have come on and no engine codes are available, the truck makes no record of the sudden loss of motive power.

The contact owns a 2015 Ram 1500. The contact received a notification for NHTSA Campaign Number: 21V632000 (Air Bags) however, the part to do the recall repair was unavailable. The dealer had been notified about the recall; however, the contact was informed that the part was not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.