2015 RAM 1500 Complaints

W58 recall inspection completed. Chrysler states W68 recall does not apply to vehicle because the part affected was not made at or at the time of the part (tone ring on fly wheel) was not at the location or time as others which are eligible for the recall. Initially EGR recall completed with engine light - a few weeks later crank shaft position sensor error code engine light. Crank shaft position sensor was originally inspected - can cause engine to stop or go into limp mode while driving. Truck went into limp mode after pulling out of driveway onto busy street

Intake manifold melted and smoked. No flame seen but lots of smoke. Check engine light came on and service Electronic Throttle light came on. I have had 2 EGR coolers installed in this vehicle. This was close to being a engine fire. If this is not fixed soon some ones Ecodiesel will burn a family up. NTSB needs to recall these vehicles ASAP

This problem is common for the 5.7l V8 Hemi RAM engine, as reported by owners. It concerns bolts that hold the exhaust shield to the engine manifold. These bolts are known to break off, causing a tapping sound that is heard while the engine is cool, soon quieting down as the engine heats up. The bolt also holds the catalytic converter in place. If not repaired, it can cause the exhaust system shield to break loose entirely, and also possibly causing the catalytic converter to break loose. The failure is well known to owners, and is clearly documented in the following Youtube video: https://youtu.be/cL3xNoKs9E4 titled "The most common Hemi Tick"

I was driving on the Interstate when a electronic short warning light come on, I pulled over on the shoulder of the road and my engine quit and smoke started to come from the engine. I opened the hood and the engine was on fire. I emptied my cooler, all the bottles of water I had and Cokes and managed to put the fire out with out damage to any thing or any one other than the engine, windshield and hood. Dealer does not want to take responsibility, oil cooler seems to be the source of the fire. Oil sprayed on to the fire blanket on the hood kept burning after the main fire was extinguished. My truck was running fine prier to the fire, I have been waiting for a replacement tone wheel (recall # W58) for 6 months. I have had the EGR (recall #VB1) go out twice and fixed. Numerous electrical tail light shortages.

The contact owns a 2015 Dodge Ram 1500. The contact stated that while driving at 55 - 60 mph, the steering wheel stiffened up and was hard to steer. The dealer was made aware of the failure and informed the contact that the VIN was not included in a recall for the failure. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with NHTSA. The failure mileage was 86,000.

I bought my 2015 ram eco-diesel August 2019 I try to get the recall done once and they said they will not install it I waited about a year and called again and they made a appointment for me But the recall with the crankshaft sensor went bad and I had to have it towed they installed the EGR cooler and did a programming to the camshaft sensor now I’ve got the vehicle back it’s hard to start it has no power I don’t understand this I just want the truck to be right I haven’t drove The truck in over a year I just want them to make the truck right thank you

The tone ring of my vehicle has failed causing the crank sensor to not work as designed. This has put my vehicle into a no start condition. I was lucky that this happened just after I returned home instead of while in the 5 lane traffic I was previously in. Had this happened a few minutes earlier I would have been in an accident.

My 2015 Ram 1500 abruptly downshifted into 4th gear while driving down the road at approximately 50 mph. I immediately pulled off the road and found that the truck was stuck in 4th gear. After some research I've found this is very common with the RAM's and that they had a recall on the newer models for the same issue. If I would have been going around a bend when this occurred, it would have caused an accident. I'm not going to have to spend around $1000 to repair something that is an obvious defect. It's going to cause an accident, or more accidents if nothing is done about it.

THE RECALL FOR THE CRANK POSITION SENSOR TONE WHEEL MAY DELAMINATE FALLS SHORT OF CORRECTING THE PROBLEM. MINE DELAMINATED AND IT COST ME $2600 FOR THE REPAIR AT THE DEALER IN GILROY CA. BESIDE LEAVING US STRANDED ON A REMOTE SECTION OF HIGHWAY WITH THE TRAVEL TRAILER WE WERE TOWING. WE PAID $250 FOR TOWING THE TRUCK AND THE TRAILER AND $1000 TO RENT A CAR WHILE THE DEALER WAITED TO DIAGNOSE THE ORDER PARTS AND FINALLY TO REPAIR. AFTER PICKING UP THE TRUCK THE CHECK ENGINE LIGHT CAME ON ABOUT AN HOUR DOWN THE ROAD TOWARD HOME. AFTER I GOT HOME I TALKED TO THE LOCAL DEALER. THE TRUCK JUST TURNED OVER 120000 MILES JUST BEFORE GETTING TO THE DEALER SO EVEN THOUGH THE ISSUE HAPPENED BEFORE THE MILES HIT 120000 THE DEALER TOLD ME IT WOULD NOT BE COVER BY THE EXTENDED WARRANTY THAT WAS PART OF THE EMISSION SETTLEMENT. FIRST I BELIEVE THE RECALL FOR THE CRANK POSITION SENSOR TONE WHEEL MAY DELAMINATE SHOULD COVER THE COST TO REPLACE THE WHEEL, NOT JUST MODIFY THE PROGRAM. SECOND THERE IS STILL AN ISSUE THAT WAS NOT FOUND BY THE DEALER BEFORE 120000 MILES AND I BELIEVE THIS SHOULD QUALIFY AS A WARRANT REPAIR. THANK YOU FOR YOUR CONSIDERATION OF THESE ISSUES.

A COUPLE OF MONTHS AFTER GETTING THIS USED VEHICLE, THE ENGINE LIGHT CAME ON WITH A MESSAGE SAYING TO CHECK THE FUEL CAP. JUST TO MAKE SURE THAT NOTHING ELSE WAS WRONG, WE GOT A DIAGNOSIS FROM O'RILEYS & AUTO ZONE; THE O2 SENSORS NEEDED TO BE REPLACED. SO WE DECIDED TO SWITCH OUT THE O2 SENSORS AND THE FUEL CAP. THEN AFTER A WEEK, THE ENGINE LIGHT CAME BACK ON AGAIN. SO WE GOT ANOTHER DIAGNOSIS TO FIGURE OUT THE PROBLEM, IT DETECTED AN EVAPORATIVE EMISSION SYSTEM LEAK (VERY SMALL LEAK). THEN THE FOLLOWING WEEKEND, WE TOOK THE VEHICLE BACK TO THE DEALERSHIP TO SEE IF THEY CAN FIX THE PROBLEM. THERE WAS NO MECHANIC ON DUTY AS THEIR AUTO DEPARTMENT WAS CLOSED. INSTEAD, WE TALKED TO THE DEALER WHO SOLD US THE VEHICLE AND HE STATED, 'YOU CAN DELETE THE MESSAGE.' HE WAS NO HELP AT ALL AND DIDN'T BOTHER TO HELP FIX THE PROBLEM WITH THIS VEHICLE. IN ADDITION, HE SAID THAT HE KNOWS A LITTLE ABOUT WORKING ON CARS, HOW TO USE THE HANDHELD DETECTOR MACHINE, AND DELETING THE CODE WOULD MAKE IT BETTER? WE WANTED THIS VEHICLE TO WORK PROPERLY NOT BY 'DELETING' (THE MESSAGE), BUT TO FIGURE OUT WHAT IS WRONG AND HOW TO GET IT FIXED. THERE IS A WAITLIST FOR AN AUTO SHOP NEARBY, DUE TO THIS PANDEMIC WE HAVE TO WAIT TO RECEIVE A CALLBACK FOR AN APPOINTMENT, AND NOW I RECEIVED A NOTIFICATION FROM CREDIT KARMA STATING TO CHECK ON THE RECALL FOR THIS USED TRUCK I OWN. CURRENTLY, THE CHECK FUEL CAP WILL NOT TURN OFF AND THE ENGINE LIGHT IS STILL ON.