2021 RAM 1500 Complaints

Exhaust manifold on passenger side has cracked leading to exhaust fumes in cabin, causing dizziness and headaches due to carbon monoxide ram has acknowledged this issue with a TSB but the fact that exhaust fumes come into the cabin on a vehicle that is five years old is concerning and in my opinion, a safety concern.

I am reporting a safety-related exhaust leak on my 2021 Ram 1500. The vehicle has a persistent exhaust leak which may allow fumes to enter the cabin and poses a health and safety hazard. Over the past 6–9 months, I attempted multiple times to have this issue repaired under my warranty at the authorized dealership (Jimmy Britt CDJR, now Joe Maus CDJR in Dublin, GA). However, the dealership refused to schedule a proper appointment and would only tell me to “drop it off” with no estimated timeframe and no loaner vehicle. Because I rely on the truck for work, I cannot leave it indefinitely. The dealership’s refusal has prevented me from obtaining repair of this safety defect, and I am forced to continue driving with a known hazard. This appears to be a safety-related defect involving the exhaust system, and the manufacturer and dealership have not provided an adequate means to repair it.

The contact owns a 2021 Ram 1500. The contact received notification of NHTSA Campaign Number: 24V653000 (Service Brakes, Hydraulic, Electronic Stability Control (ESC); however, the part to do the recall repair was not yet available. The contact stated that while reversing downhill and depressing the brake pedal, the brake pedal travelled down to the floorboard and became stiff, and the vehicle made an abnormally loud sound and failed to respond as needed. The contact stated that upon depressing the brake pedal several times, the brake pedal responded as intended, and the vehicle slowly decelerated; however, the braking distance was extended. A brake message was displayed. The vehicle was taken to the dealer, where the contact was informed that the part to do the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

The contact owns a 2021 RAM 1500. The contact stated that while driving at 47 MPH, towards a four-way intersection, the vehicle coming off the road on the left side of the vehicle ran a stop causing another vehicle to collide with his vehicle. The contact stated that no air bags deployed. The contact stated that he sustained whiplash and bruises to the head. Medical attention was required via hospital. The contact mentioned that the vehicle was towed to an auto body center. The contact stated that a police report was filed. The manufacturer was not notified of the failure. The approximate failure mileage was 49,000

I was suddenly unable to fill the fuel tank of my truck on the way back from a 4 hour road trip in freezing conditions. I was able to get just enough fuel into my vehicle to make it back due to it occurring during a fuel up on the last hour of the drive. However, if this had happened earlier in the drive, I could have been stranded with my family in freezing conditions. There were no warnings and it hadn't been happening prior, other than a half dozen times randomly over the past 2 years where the fuel station nozzle clicked off a few times prematurely. But never to the extent of not being able to fill the tank. It was brought to a dealership and is currently having the fuel tank replaced due to a bad valve inside of it.

The contact owns a 2021 Ram 1500. The contact received notification of NHTSA Campaign Number: 24V653000 (Service Brakes, Hydraulic, Electronic Stability Control (ESC); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving at an undisclosed speed, the message "Battery Low Voltage" was displayed and the vehicle experienced loss of power steering functionality and decelerated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the failure was related to the recall. Additionally, the contact was informed that the E-Torque generator also needed to be replaced but the part was on backorder. The vehicle was not repaired. The manufacturer was notified of the failures. The failure mileage was 110,000.

My driver sun visor support broke when I tried to pull down the sun visor. It is supported by a plastic piece. If it wasn’t supported on the left side it could have fell down completely blocking my visibility of the road. I looked up this issue online and there are many other videos with the same issue with these trucks. This issue is so persistent that some third party companies have already come out with plastic support pieces to screw in to fix this. I took the truck to the dealer but they said they won’t fix it since my truck is out of warranty. There was no warnings, messages, or symptoms of the problem prior to the failure.

All warning lights on dash came on including battery. Freedom Dodge assessed it on 11-10-2025 and said the vehicle generator has an internal short and is discharging the battery. If being operated could cause the vehicle to die while in motion. I am making $700 per month payments and Freedom indicated over 6000 of these units are on back order and cannot give me a date for replacement only saying "months"

Body Control Module failure. 2021 Ram 1500 Tradesman with 3.6L engine My first symptom was a message that appeared on the dash gauge cluster that said something like "problem with shift positioner". That message came up then went away. Next symptom was dash lights flashing for no reason. This was a few days after the other. These lights would flash one time for just a fraction of a second, and only when I hit a bump on the road. I thought that I had a loose wire so I checked wiring for loose connection but did not find any. I had no other problems for several days. Then I was on a trip far from home and that is when things got really bad. All of the gauges on my instrument cluster were going up and down for no reason. The windshield wipers came on by themselves. The dash lights started flashing, like before but this time that were on and off for longer periods of time and not caused by bumps on the road. The vehicle lost power while I was driving and I was forced to pull to the side of the road. The engine had died. I was not able to restart right away. While I was sitting there trying to figure out my next move (because I was in the middle of nowhere), the lights on the dash were still flashing even after I had turned the key off. I know that sometimes trouble codes can be cleared by disconnecting the battery, so that is what I did. After I put the battery cables back on, the controls seamed normal again. I was able to start the engine and drive into town. I went straight to an automotive repair shop that I had found by Google search. They put their code reader on and said that I had 59 fault codes. They had never seen that many on any vehicle before. They checked my battery to make sure it was fully charged. It was. They checked a few other things, but diagnosed the problem to a bad Body Control Module. After this incident, I did some research and found that this seems to be a come problem with the Ram Pickups. This should be a recall item.

The contact owns a 2021 Ram 1500. The contact stated that while driving approximately 50 MPH, while depressing the accelerator pedal, the vehicle began to vibrate. An independent mechanic was contacted. The vehicle was taken to an independent mechanic, and the contact was informed that the front axle half-shaft was worn and needed to be replaced. The contact also took the vehicle to a tire shop and was informed that new tires were needed. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact was referred by the manufacturer to report the failure. The failure mileage was 115,000.