2022 RAM 1500 Complaints

Im driving vehicle and randomly the vehicle will shut off when making turns. It is random every so many months. But it has done in major intersections. It will immediately start back up so that’s good. But there are no engine lights. And dealership Does not seam like they can do a whole lot with engine no lights on. But it seems common when doing research online The vehicle is a 2022 Ram 1500 with 55,000 miles

I am reporting a serious and ongoing safety issue with my Ram 1500. The vehicle has experienced multiple incidents of complete power loss while driving, including at highway speeds. During these events, the vehicle abruptly shuts down without warning. The dashboard lights illuminate (including the battery and check engine lights), followed by total electrical failure. The engine turns off, the radio and displays go dark, and I lose power steering and braking assist, then the emergency brake engages, making the vehicle extremely difficult to control. These incidents have occurred more than once and are unpredictable. In at least one instance, I was forced to pull over on the highway after the vehicle lost all power while in motion. The loss of steering and braking assistance created a dangerous situation, especially as I have had my children in the vehicle. After one incident, the vehicle was jump-started and the battery was replaced; however, the issue recurred. A mechanic previously reported that no diagnostic codes were found and no problem could be identified, despite the severity of the failure. The vehicle is currently at the dealership for further evaluation. This issue appears consistent with other reports of Ram 1500 vehicles experiencing sudden loss of motive power and electrical failure. The intermittent nature of the defect and lack of diagnostic codes make it difficult to detect, increasing the safety risk. I do not feel safe operating this vehicle, as it can shut down without warning while driving. I am requesting further investigation into this issue due to the significant risk of crash or injury.

-The wiring harness to the right of the rearview mirror combusted, causing a fire that lead to insurance totaling the vehicle. -Being that this issue occurred with the vehicle off, and no one present this could be a serious issue if not for neighbors seeing the fire and putting it out. -No, due to this being a fire, it can not be reproduced or confirmed. -Police, fire and insurance investigators all have inspected the vehicle fire. Both fire and insurance have agreed the fire started at the same point. -There were no warnings of any kind prior to the fire.

We have experienced failure of both sun visors. They fall out of the ceiling I had the passenger side repaired last year while driving today the driver side fell out this drops down and blocks view and impairs steering. I had to hold it up and exit the roadway almost striking the vehicle in front and also on my right. This completely fell out of the ceiling on both without warning

While driving on the 60 East highway (approximately 65-68 mph), the vehicle did not accelarate and became completely non-responsive. Each time I pressed on the gas pedal, the RPM needle started trembling between 600-1100, which is much lower than where it should be while the vehicle was in Drive and traveling at this speed. This was an extremely dangerous situation as I had my wife and 5 month old daughter in the vehicle, and other vehicles were traveling significantly faster than me. I noticed some engine vibrations, and the digital gauge cluster screen presented information on the screen as if the vehicle was "off." It instructed me to push the gear lever into Park. It then instructed me to press the brake pedal and push the iginition button. All of this occurred as the vehicle was still coasting (likely around 40 mph). I pulled over on to the shoulder to see what occurred. After coming to a complete stop the engine cut out. I was able to restart the vehicle and drove approximately 10 minutes before it occurred again on the surface streets. At that point the ignition did not catch and it sounded very much like the engine was not able to turn on at all. The check engine light turned on at this point. I called AAA for tow services shortly thereafter, and the vehicle was dropped off at the dealership. I have not received any followup from the dearlership yet.

The contact owns a 2022 Ram 1500. The contact stated that while making a left turn out of the driveway, there was a clunking sound coming from the front passenger’s side of the vehicle, and the vehicle failed to steer or turn properly. The vehicle was towed to a dealer but was not yet diagnosed; however, the tow truck driver stated that the ball joint of the upper control arm on the passenger’s side had fractured completely. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 45,000.

UNKNOWN exact component, but it is a critical failure within the electrical/charging system or the 48V eTorque system. The dealership previously suspected the eTorque system and replaced the belt tensioner, but the failure continues. The vehicle is currently available for inspection and has been sitting at an authorized Ram dealership for the last three weeks. The vehicle suffers a complete and sudden loss of motive power while driving. When it stalls, the truck automatically engages "auto park" and applies the parking brake. This has happened repeatedly while pulling into active traffic and while passing through busy intersections (most recently in downtown Chicago). This sudden, uncontrollable stop in the middle of an intersection creates an extreme and immediate risk of a severe rear-end or T-bone collision for myself, my passengers, and surrounding motorists. Yes, the dealership was able to successfully replicate the stall while their technicians were driving it. But I don't think they had any type of computer hooked up to it. However, the attempt at repair during the second service visit involved replacing the eTorque belt tensioner based on my description of the failure, acknowledging that a slip could cause the issue. They have not been able to replicate during this last visit. Despite putting over 400 test miles on the truck during the current (third) visit, they cannot get the intermittent failure to occur while hooked up to their diagnostic equipment. Yes, the vehicle has been inspected multiple times by an authorized Ram dealership. It has been in their possession for over six weeks in total across three separate service visits.

This is in regards to well known issue with the E-Torque MGU generator equipped on this vehicle. The internal bearing is failing causing a whining and grinding sound and results in a loss of electrical power that causes the vehicle to stall and not restart when the auto start/stop feature is engaged, which has happened to me once. I have had a dealer confirm this component failure and the vehicle is now unsafe to drive and is parked for an undetermined amount of time because the part is on national backorder per Stellantis.

SMELL OF COOLANT THROUGHOUT THE CAB OF THE TRUCK. TOOK THE VEHICLE TO THE SHOP WHERE A PRESSURE TEST WAST CONDUCTED. IT WAS DETERMINED TO BE A BAD HEATER CORE. APPARENTLY THIS IS A KNOWN ISSUE FOR THE RAM TRUCK. THIS WAS AMENDED FROM A EARLIER REPORT. SENT THE WRONG DOCUMENT FROM THE SHOP.

SMELL OF COOLANT THROUGH OUT THE CAB OF THE TRUCK. TOOK THE VEHICLE TO THE REPAIR SHOP AND AFTER A PRESSURE TEST WAS CONDUCTED, IT WAS FOUND TO BE A BAD HEATER CORE. APPARENTLY THIS IS A KNOWN ISSUE AND HAS BEEN WIDELY REPORTED. THE TRUCK ONLY HAS 40,000 MILES AND HAS BEEN WELL MAINTAINED.