2005 SAAB 9-2X Complaints

The contact owns a 2005 Saab 9-2X. The contact received notifications of NHTSA Campaign Numbers: 11V464000 (Suspension) and 15V323000 (Air Bags); however, the parts to do the recall repairs were not yet available. The local dealer and Chevrolet 112 (631) 317-2348) were contacted but referred the contact to Subaru for recall repair assistance. The Subaru manufacturer and GM manufacturer were notified of the issue, but no assistance was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

Does recall supposed to be done under the general motors they’re refusing to do this recall. And it’s the law they have to do this recall not my fault. It’s a sob that was made by Subaru, but it’s GM’s product 05-06.

The contact owns a 2005 Saab 9-2x. The contact stated while attempting to park the vehicle, the control arm fractured. There was no warning light illuminated. The vehicle was taken to a local dealer and was told rubber bushings and rubber control arm links could be worn. The control could just break apart from rust. The vehicle was not repaired. The contact stated that the vehicle was repaired in 2012 under NHTSA campaign number: 11V464000 (Suspension) however, the failure still occurred. The manufacturer had been informed of the failure but offered no additional assistance. The failure mileage was approximately 90,000. The consumer is still waiting to have the vehicle repaired. The consumer stated after arguing with GM, the appoint was set for July 16, 2021.The consumer stated it was determined to be damage a broken control arm, broken sway bar link, broken sway bar and axle being pulled from the differential. There was a temporary control arm replaced in order for the vehicle to move, but the repairs have not been made for this vehicle. The vehicle will need an alignment and parts replaced upon inspection to see if there is more damage. than initial inspection showed.

IT IS A KNOWN ISSUE IN THE SAAB 9-2X COMMUNITY THAT THE REAR STRUT TOWERS RUST OUT AND FALL APART. THIS IS AN ISSUE THAT SHOULD BE ADDRESSED AS IT IS SO COMMON WHETHER IN A RUST PRONE STATE OR NOT.

METAL PLATE REAR STRUT TOWERS RUSTING OUT. CONSTANTLY, PRESENTS POTENTIAL FOR SUSPENSION TO FAIL AND REAR RUNNING GEAR TO PUNCTURE THE BODY

BOTH REAR LEFT AND RIGHT STRUT TOWERS BEGAN RUSTING TO THE POINT THE REAR SUSPENSION ALIGNMENT WAS CONSTANTLY SHIFTING DUE TO THE LACK OF STRUCTURE REMAINING IN THE BODY

MY STRUT TOWERS HAVE BEGUN TO RUST, AND IF I DON'T REPAIR AND WELD IT SOON, MY REAR STRUTS MIGHT RIP THROUGH THE TOWERS. THE REAR STRUT TOWERS OF SAAB 92X RUST OUT OVER TIME DUE TO MOISTURE GETTING THROUGH THE TOWERS AND GETTING TRAPPED UNDER SOUND DEADENING MATERIAL. THIS CAUSES VIRTUALLY EVERY NON-FAIRWEATHER 92X TO UNDERGO A RUSTED STRUT TOWER ON THE FRAME. THIS IS SUCH A PROBLEM, THE FIRST RECOMMENDED STEP WHEN BUYING USED IS TO CHECK THESE FRAMES AS THE REAR STRUTS CAN RIP THROUGH WHEN THEY ARE RUSTED AND CAUSE A POTENTIALLY FATAL ACCIDENT. THE ONLY PROPER FIX IS WELDING.

THE FOUR BOLTS THAT THE REAR SEATS ATTACH TO HOLD MOISTURE WHICH THEN INFILTRATES THE STRUT TOWERS AND CAUSES THEM TO ROT OUT. WHAT WILL HAPPEN IS YOU CAN BE DRIVING AND WITHOUT NOTICE, A WHEEL WILL DISCONNECT FROM THE BODY OF THE CAR AND IMMEDIATELY BECOME A HAZARD THAT FORCES YOU TO WRECK THE CAR SINCE THE WHEEL IS NO LONGER ATTACHED. EVERY SAAB 9-2X HAS THIS ISSUE AND EVERY OWNER EITHER PARTS THE CAR OUT OR HAS TO HAVE IT REPAIRED WHICH I RECENTLY DID TO THE TUNE OF $1,075. JUST TO KEEP THE CAR SAFE TO DRIVE. THE FIX REQUIRES THE RUSTED AREA TO BE CUT OUT AND THEN NEW METAL WELDED IN SO IT CAN REGAIN STRUCTURAL RIGIDITY.

SEVERE STRUT TOWER RUST WITH MANY PEOPLES COLLAPSING. THIS IS DIRECTLY DUE TO SUBARU AND GMS MANUFACTURING OF THE CAR.

IT IS A WELL KNOWN ISSUE WITH 2005-2006 SAAB 9-2X'S, SUBARU WRX'S THAT THE REAR STRUT TOWERS ARE PRONE TO RUST THROUGH AND CAUSE A REAR STRUT TO COMPLETELY BREAK FREE FROM THE BODY OF THE VEHICLE. THIS IS A GENERAL MOTORS/SUBARU ISSUE, SINCE THE 9-2X IS ALL SUBARU PARTS WITH SAAB BADGING.