SAAB Complaints

TRANSMISSION "CLUNK" OCCURRED WITH SHIFTING FROM REVERSE TO DRIVE. DEALER DIAGNOSED VALVE BODY AND RECOMMENDED TRANSMISSION REBUILD. AAMCO DIAGNOSED SAME ISSUE RESULTING FROM METAL SHAVINGS BEING RELEASED FROM TORQUE CONVERTER INTO TRANSMISSION. ENTIRE TRANSMISSION INCLUDING TORQUE COVERTER NEEDED TO BE REPLACED AT 74,000 MILES.*JB

TL*THE CONTACT OWNS A 2000 SAAB 9-5. ON APRIL 20,2006, THE VEHICLE WAS REPAIRED DUE TO NHTSA RECALL NUMBER 05V399000 (ELECTRICAL SYSTEM:IGNITION:MODULE). ON JULY 10, 2007, THE ENGINE LIGHT BEGAN ILLUMINATING INTERMITTENTLY. THE VEHICLE WAS PLACED ON A DIAGNOSTIC MACHINE AND DISPLAYED A READING OF P1312. SAAB STATED THAT THERE WAS NO LONGER ANY WARRANTY ON THE IDM. THE FAILURE MILEAGE WAS 62,458 AND CURRENT MILEAGE WAS 69,000. THE DEALER STATED BROKEN WINDOW. UPDATED 09/19/07 *TR

TL*THE CONTACT OWNS A 2007 SAAB 9-5. WHILE DRIVING 50 MPH AND ATTEMPTING TO ACCELERATE, THE VEHICLE STALLED. THE FAILURE OCCURS INTERMITTENTLY. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OR DUPLICATE THE FAILURE ON TWO OCCASIONS. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE CURRENT AND FAILURE MILEAGES WERE 5,800. UPDATED 09/18/07 *TR

TL*THE CONTACT OWNS A 2007 SAAB AERO. THE BRAKES FAILED WHILE DRIVING 5 MPH IN REVERSE ON A HILL. THE CONTACT WAS ONLY ABLE TO STOP THE VEHICLE AFTER PLACING THE VEHICLE IN PARK. THE WEATHER CONDITIONS WERE NORMAL. NO WARNING LIGHTS APPEARED ON THE DASH BOARD. THIS WAS THE FIRST OCCURRENCE OF THIS TYPE OF FAILURE. THE CURRENT MILEAGE WAS 10,395 AND THE FAILURE MILEAGE WAS 10395.

TL*THE CONTACT OWNS A 2000 SAAB 9-3. AT 68,359 MILES, THE ENGINE WAS REBUILT DUE TO A BLOWN PISTON. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. FIFTEEN MONTHS LATER, THE ENTIRE ENGINE HAD TO BE REBUILT FOR THE SAME FAILURE. WHILE DRIVING 55 MPH, THE VEHICLE STALLED AND THE ENGINE SUDDENLY FAILED. THE VEHICLE WAS REPAIRED, BUT THE CONTACT BELIEVES THAT THE MANUFACTURER SHOULD CONSIDER THIS A RECALL BECAUSE OF THE FREQUENCY OF THE FAILURES. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 97,780.

TL*THE CONTACT OWNS A 2006 SAAB 9-3. THE VEHICLE HAS FOUR PIRELLI P6 (SIZE P215/55R16-97) SEASON TIRES. THE CONTACT'S WIFE WAS DRIVING APPROXIMATELY 70 MPH WHEN THE SIDEWALL ON THE PASSENGER SIDE FRONT TIRE SUDDENLY BURST. SHE WAS ABLE TO COME TO A COMPLETE STOP AND PLACED THE SPARE TIRE ON THE VEHICLE. THE TIRE HAS NOT BEEN INSPECTED, BUT THE CONTACT HAS DISCOVERED THAT SEVERAL OTHERS HAVE EXPERIENCED THE SAME FAILURE WITH THIS BRAND OF TIRE. THE CURRENT AND FAILURE MILEAGES WERE 16,400.

THIS CAR HAS DIED 3 TIMES WHILE DRIVING AND REQUIRED A TOW. THE FIRST TIME THE IGNITION MODULE WAS REPLACED FOR FREE (RECALL). THE 2ND TIME THE CAR MYSTERIOUSLY RE-STARTED BEFORE THE TOW TRUCK ARRIVED. THE MOST RECENT INCIDENT RESULTED IN A TOW TO THE NEAREST DEALER AND THE (DEFECTIVE) THROTTLE BODY BEING REPLACED AT A COST OF $714. ALSO, THE CATALYTIC CONVERTERS HAD TO BE REPLACED (NON-WARRANTY) AFTER THE IGNITION MODULE (RECALL). AT APPROX. 118,000 MILES THE TRANSMISSION WAS REPLACED. *TR

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS SUMMARY: DRIVING ON HIGHWAY, PRESSURE LINE FROM FUEL TANK CAME LOOSE AND STARTED LEAKING MASSIVE AMOUNTS OF GAS ALL OVER THE UNDERSIDE OF THE VEHICLE AND STREET. STREAM OF FUEL ON HIGHWAY ALERTED DRIVER. LOST UNKNOWN AMOUNT OF GALLONS OF GAS QUICKLY . HAD TO PULL OVER AND CALL FOR TOW TRUCK TO TAKE TO NEAREST FACILITY. I EVACUATED THE CAR DUE TO LARGE AMOUNTS OF GAS UNDER VEHICLE AND STREAMS OF FUEL NEAR HOT EXHAUST PIPES. TECHNICIAN DISCOVERED FUEL LINE HAD COME LOOSE AFTER LOOKING INSIDE PORT FROM UNDER BACK SEAT. NO EVIDENCE OF ANY BREAKAGE OR OTHER ISSUES THE FIRST EVENT-- THE LINE SIMPLY CAME LOOSE AND WAS EASILY RE-ATTACHED. THE SECOND EVENT HAPPENED IN JUNE 2007 AND FUEL AGAIN WAS POURING OUT FROM THE UNDERSIDE IN A PARKING LOT. I CALLED THE SAME INDEPENDENT DEALER WHO IMMEDIATELY HAD THE CAR TOWED . THIS TIME THE REPAIR WAS DONE WITH METAL STRAPS TO PREVENT ANY FURTHER COMING APART. I THEN RECEIVED A RECALL LETTER FROM SAAB AFTER THIS OCCURRENCE TWO TIMES. I WAS TOLD BY SAAB USA TO SUBMIT REPAIR ORDERS FOR REIMBURSEMENT WHICH I DID. I RECEIVED A DENIAL LETTER UNTIL AN AUTHORIZED SAAB DEALER COULD CHECK THE WORK COMPLETED BY THE INDEPENDENT DEALER. I WAS CALLED BY THE AUTHORIZED DEALER IN MARIETTA, GA AND TOLD THAT I MAY NEED A COMPLETE FUEL ASSEMBLY FOR $1100 DUE TO THE INDEPENDENT DEALERS REPAIRS AFFECTING ELECTRICAL WIRING. THE CAR IS AT THE DEALER FOR INVESTIGATION AND HOPEFULLY A SAAB USA WILL STAND BEHIND THE NEEDED REPAIRS. CONSULTATION ON INTERNET CHAT ROOM SAABNET.COM FINDS THAT AT LEAST 4 OTHER OWNERS OF SIMILAR VINTAGE SAAB 9-5 VEHICLES HAVE EXPERIENCED THIS SAME PROBLEM. SAAB USA IS QUESTIONING MY REPAIRS AT THE INDEPENDENT DEALER. *TR

IN, APPROXIMATELY, THE LAST FOUR MONTHS, MY ENGINE WARNING LIGHT MY ENGINE WARNING LIGHT HAS GONE ON. IN CONTACTING THE DEALER, THE FIRST TIME, THE GAS CAP HAD NOT BEEN PROPERLY PUT BACK ON. THE TWO SUBSEQUENT TIMES, I AM CERTAIN THAT IT HAD BEEN. AFTER THE THIRD TIME, I TOOK THE VEHICLE TO THE DEALER, THINKING IT WAS EITHER THE O2 SENSOR, OR THE GAS CAP. I WAS TOLD, BY THE SERVICE ADVISOR, THAT THERE WAS (I BELIEVE HE SAID) A VAPOR LEAK. IT WOULD REQUIRE PUTTING ON A REDESIGNED GAS CAP. THE SERVICE WRITE-UP STATED IT WAS "REPLACED WITH AN UPDATED GAS CAP". *TR

ON 1/26/07 THE WATER PUMP OF MY CAR WAS REPLACED BECAUSE IT WAS LEAKING. I HAVE COME TO REALIZE THIS IS THE THIRD TIME THE WATER PUMP NEEDED TO BE CHANGES. IT WAS ALSO CHANGED BY THE MANUFACTURER/DEALER ON 11/10/04 & 2/25/03. HENCE THE CAR HAS GONE THROUGH THREE WATER PUMPS IN 44510 MILES. *JB