2004 SUBARU FORESTER Complaints

IN VERY COLD WEATHER (LESS THAN 10 F) THE RUBBER GAS LINES LEAK VERY SIGNIFICANT AMOUNTS OF GAS ONTO THE ENGINE AND VERYNEAR THE HOT TURBOCHARGER. ANOTHER SUBARU JUST CAUGHT FIRE IN THE O'NEILL TUNNEL. HTTP://BOSTON.CBSLOCAL.COM/2014/01/27/CAR-FIRE-CAUSES-BACKUP-IN-ONEILL-TUNNEL/ *TR

IN COLD WEATHER (BELOW 20 DEGREES OR SO) THE FUEL LINES IN THE ENGINE COMPARTMENT COME LOOSE AND LEAK RAW GASOLINE ONTO THE HOT ENGINE. OBVIOUSLY THERE IS A GOOD CHANCE OF AN ENGINE FIRE WITH POSSIBLE LOSS OF LIFE. THIS HAS BEEN REPORTED IN SEVERAL FORUMS, THERE IS A TSB OUT ON THIS FOR THE WRX (SAME ENGINE, SAME PART NUMBERS), AND MOST DEALERS (IN COLD STATES) KNOW OF THIS PROBLEM. *TR

ON VERY COLD DAYS WHILE CAR IS WARMING UP, A STRONG SMELL OF FUEL IS COMING FROM UNDER THE INTAKE MANIFOLD. A CLOSER INSPECTION REVEALS A SMALL FUEL LEAK FROM THE FUEL SUPPLY LINES NEAR THE TURBO. A SUBARU IMPREZA ENTHUSIAST FORUM HAS A "RAW FUEL SMELL" LOG OF MORE THAN 131 PAGES AND 3,000 POSTS (HTTP://FORUMS.NASIOC.COM/FORUMS/SHOWTHREAD.PHP?T=131755). SUBARU ISSUED A TECHNICAL SERVICE BULLETIN (TSB) FOR CERTAIN SUBARU IMPREZAS, BUT THEY HAVE NOT INITIATED ANY TSBS FOR ANY OTHER CARS ALL USING THE SAME OR SIMILAR ENGINES. SEE TSB 01-170-09. AS LEAKING FUEL ONTO YOUR ENGINE IS A SAFETY HAZARD, I WOULD LIKE TO SEE SUBARU INITIATE SOME KIND OF TSB OR RECALL FOR ALL ENGINES EXPERIENCING THIS PROBLEM. I UNDERSTAND MANY SUBARU OWNERS HAVE COMPLAINED TO SUBARU AND NHTSA WITH NO RESULTS. *TR

FUEL AND EXHAUST LINE LEAKS IN COLD WEATHER. OVER THE INITIAL THREE DAY PERIOD - DAY ONE CHILDREN COMPLAINED OF HEADACHES, DAY TWO DRIVER EXPERIENCED SEVERE HEADACHE AND NAUSEA BUT DID NOT REALIZE IT WAS DUE TO FUEL LEAK. DAY THREE CABIN FILLED WITH OVERPOWERING FUMES COMING FROM HEATING VENT. HAD TO DRIVE WITH HEAT OFF AND ALL WINDOWS OPEN IN ORDER TO BRING CAR IN FOR SERVICE. HAVE HAD TO BRING CAR IN TWICE THIS MONTH TO REPAIR ALL OF THE LEAKS AND RENT A CAR IN ORDER TO GET TO WORK APPOINTMENTS. CERTIFIED SUBARU SPECIALIST REPORTED THAT HE HAS SEEN QUITE A FEW INCIDENCES OF SAME ISSUE RECENTLY DUE TO EXTREME COLD WEATHER. THIS IS A DANGEROUS SAFETY ISSUE AND IS NOT ACCEPTABLE. 2002-2003 IMPREZA RECALLED DEC 2009 FOR SAME ISSUE. *TR

THIS 2004 SUBARU FORESTER 2.5 XT AWD 4-SPD AUTOMATIC TRANSMISSION WITH MULTI-PURPOSE FUEL INJECTION TURBO (FEEDBACK FUEL SYSTEM) HAS BEEN PRODUCING A STRONG FUEL SMELL THAT FILLS THE ENTIRE VEHICLE CABIN. I'VE BEEN TOLD BY THE DEALER THAT THIS IS TO BE EXPECTED FROM THIS TYPE OF ENGINE AND THAT THERE IS NOTHING MUCH THAT THEY CAN DO ABOUT IT AND TO LEARN TO LIVE WITH IT. THE DEALER ALSO INDICATES THAT THIS PROBLEM IS BASICALLY CAUSED BY EXTREME COLD WEATHER AND/OR TEMPERATURE CHANGE. I HAVE RESEARCHED THIS ISSUE AND FOUND THAT THERE WAS A SIMILAR PROBLEM WITH THE SUBARU IMPREZA AND THAT SUBARU ISSUED A RECALL. NO VEHICLE, SUBARU OR OTHERWISE, SHOULD PRODUCE A PROBLEM LIKE THIS ONE THAT IS "UNFIXABLE." THE CONSUMER SHOULD BE PROTECTED FROM THIS POTENTIALLY HAZARDOUS SITUATION. THIS CONSUMER IS PUTTING SUBARU ON NOTICE. *TR

TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED WHEN THE TEMPERATURE DROPPED, FUEL FUMES WERE EMITTED IN AND AROUND THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 117,000. THE INTAKE MANIFOLD WAS REPLACED. UPDATED 03/12/14 UPDATED 3/12/14*CN THE FUEL LINES, CLAMPS AND UPPER INTAKE GASKETS WERE REPLACED. THE FUEL LINES WERE CRACKED. UPDATED 04/01/14

SMELL OF RAW GAS INSIDE OF VEHICLE WHILE DRIVING. IT DOESN'T HAPPEN ALL THE TIME ONLY ON EXTREMELY COLD DAYS. *TR

STRONG SMELL OF GASOLINE UPON STARTING THE CAR IN VERY COLD WEATHER. INSIDE AND OUTSIDE THE VEHICLE. ONLY HAPPENS WHEN IT IS COLD OUTSIDE. REALLY GIVES ME A HEADACHE AND MAKES ME NERVOUS ABOUT IGNITING. *TR

IMMEDIATELY UPON STARTING THE ENGINE A STRONG SMELL OF GASOLINE FILLED THE ENTIRE PASSENGER CABIN. COLD WEATHER TEMPERATURE WAS WELL BELOW FREEZING. HAS HAPPENED PREVIOUSLY, AND IS CORRECTED BY TIGHTENING THE FUEL LINE CONNECTIONS. *TR

I STARTED THE CAR AFTER IT HAD SAT IN 10-15 DEGREE WEATHER AND THERE WAS A STRONG SMELL OF UNUSED GASOLINE IN THE CABIN. IT HAS STARTED HAPPENING ON START-UP FREQUENTLY SINCE THEN. *TR