2004 SUBARU FORESTER Complaints

The contact owns a 2004 Subaru Forester. The contact stated that while driving an undisclosed speed, the brake pedal was depressed and extended to the floor, causing the braking distance to be extended. The vehicle was towed to the local dealer who discovered that the brake hoses had failed due to rusting and corrosion of the brake lines. The contact was also informed that the entire subframe had sustained extensive rust and corrosion damage. The vehicle was not repaired. The failure mileage was 28,000.

My vehicle had a recall on the lower control arms that would rust and and break. That is exactly what happened while I was driving with my family. Control arm broke causing other parts to get destroyed. The fender breaks and other parts. The recall was performed before hand but it obviously wasn’t repaired correctly because it caused me to crash. Dave wright auto Subaru retailer in Iowa is refusing to repair my failed recall attempt. Consumer stated failed repair caused the consumer to crash and damaged more of my vehicle.

The contact owns a 2004 Subaru Forester. The contact stated that while having a routine safety check performed on the vehicle, she learned that the lower control was completely rusted. The contact learned that the repair was covered under a special coverage. The contact stated that because the vehicle was not registered in a stated listed for the special coverage, the vehicle was not eligible for the free repair. The manufacturer was made aware of the issue and opened a case. The manufacturer confirmed that the vehicle was not included in NHTSA Campaign Number: 11V464000 (SUSPENSION). The vehicle was not repaired. The approximate failure mileage was 145,000.

THERE IS A FUEL LEAK ON THE LOW AND HIGH PRESSURE FUEL RUBBER HOSES, AND THEY CAUSE FUEL ODOR TO ENTER THE CB VIA CLIMATE CONTROL. IT IS A VERY STRONG ODOR, THAT REQUIRES ME TO EITHER DRIVE WITH THE WINDOWS DOWN OR WAIT FOR THE CAR TO CLEAR OUT THE FUEL ODOR OUT OF THE CABIN. MOSTLY OCCURS DURING COLD WEATHER DAYS. ONCE ENGINE WARMS UP, ODOR FADES AWAY. MANY PEOPLE WITH SIMILAR CARS SAY IS A COMMON ISSUE WITH SUBARUS.

NEOPREEN HOSE TO THE RIGHT SIDE FUEL RAIL STARTED LEAKING. THIS HOSE IS NEAR THE TOP OF THE ENGINE AND THE LEAK CAUSED FUEL TO RUN ALL OVER ENGINE, WHICH WAS THEN DRAWN INTO THE CABIN VIA THE CLIMATE CONTROL SYSTEM. THIS OCCURRED WHILE DRIVING, AND RAW FUEL WAS DRIPPING FROM THE HIGH PRESSURE HOSE ONCE STOPPED.

TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED THAT THERE WAS A LEAK IN THE HEAD GASKET. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER HERB GORDON SUBARU (3161 AUTOMOBILE BLVD, SILVER SPRING, MD 20904, (866) 520-7894) WHERE IT WAS DIAGNOSED WITH THE HEAD COVER GASKET WITH NEEDING TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 04V473000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE REPAIRS WERE NOT COVERED UNDER WARRANTY AND THE COSTS FOR THE REPAIR WOULD BE OUT OF POCKET. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000.

CONTROL ARMS ROTTEN OUT WITH FRONT CRASH BARS... SHOULD BE A RECALL ON THEM AS THE CONTROL ARMS ARE ABOUT 200 EACH PLUS LABOR... AND TO FIND SOMEONE WHO HAS THE FRONT CRASH BARS CAUSE THEY ROT OUT DO TO THE AC LEAKING ON THEM AND ROTTEN THEM OUT.... *TR

CAR WAS SHIFTED FROM DRIVE INTO NEUTRAL FOR OPERATOR TO USE A PARKING LOT GATE MACHINE. THE ENGINE SURGED A LITTLE WHILE IN NEUTRAL BUT SETTLED BACK DOWN. WHEN PARKING GATE OPENED THE OPERATOR SHIFTED INTO DRIVE AND LIGHTLY PRESSED THE GAS PEDAL. THE ENGINE IMMEDIATELY SURGED TO FULL THROTTLE AND RAPIDLY ACCELERATED ACROSS THE DRIVEWAY FOR A FEW SECONDS BEFORE BEING STOPPED BY COLLISION WITH A GRANITE POST. OPERATOR COULD NOT BRAKE HARD ENOUGH TO STOP THE VEHICLE IN TIME. DRIVER INJURED IN CRASH.

TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED THAT AT START UP, THERE WAS AN ABNORMAL FUEL ODOR INSIDE OF THE VEHICLE. AFTER EXITING THE VEHICLE, THE CONTACT BECAME AWARE OF A FUEL LEAK UNDER THE FRONT OF THE VEHICLE. SCHLOSSMANN SUBARU CITY OF MILWAUKEE LOCATED AT 4640 S 27TH ST, MILWAUKEE, WI 53221, (414) 459-3677 WAS CONTACTED BY PHONE AND INFORMED OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 101,000.

TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. WHILE REVERSING THE VEHICLE IN THE DRIVEWAY, THE CONTACT HEARD AN ABNORMAL NOISE AND NOTICED THAT THE FRONT DRIVER'S SIDE TIRE WAS TURNED OUTWARD. THE CONTACT LOST CONTROL OF THE STEERING WHEEL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 11V464000 (SUSPENSION). THE CONTACT REPAIRED THE VEHICLE ON HIS OWN AND REPLACED THE GEARING ASSEMBLY (AXLE SHAFT, LOWER CONTROL ARM, AND BOLT JOINT). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 11V464000 (SUSPENSION) IN 2012. THE FAILURE MILEAGE WAS 211,000. *LN PICTURES OF CONTROL ARM. *JB