2004 SUBARU FORESTER Complaints

IN VERY COLD TEMPERATURES (BELOW FREEZING), THE FUEL LINE UNDER THE INTAKE ON THE PASSENGER SIDE WILL OCCASIONALLY LEAK AT THE CONNECTION BETWEEN THE RUBBER HOSE AND STEEL LINE. IT WILL DRIP FUEL ONTO THE ENGINE BLOCK UNTIL IT WARMS UP. THE SMELL OF GASOLINE CAN BE DETECTED INSIDE THE VEHICLE AND AROUND THE ENGINE AREA. THE FUEL DRIPS AT A RATE OF ABOUT 1 DRIP PER 1-3 SECONDS UNTIL THE HOSE WARMS UP AND SEALS AGAINST THE STEEL LINE. THE DEALER COULD NOT DUPLICATE THE PROBLEM, BUT THEY OFFERED TO TIGHTEN THE FUEL LINE FITTINGS. THE INTAKE MANIFOLD HAD TO BE LIFTED AND THE COST WAS ABOUT $150, BUT THEY COULDN'T GUARANTEE A FIX. IT WILL HAVE TO BE RECHECKED IN COLDER WEATHER. THIS 2004 FORESTER XT HAS 70,000 MILES ON IT. *TR

2004 SUBARU FORESTER 2.5XS. CONSUMER WRITES IN REGARDS TO A HEAD GASKET LEAKING ANTI-FREEZE. *TGW THE CONSUMER STATED THE HEAD GASKET HAD TO BE REPLACED TWICE. *JB

AIRBAG LIGHT COMES ON AND GOES OFF WHEN THE DRIVER'S SEAT IS ADJUSTED, ( THIS HAS BEEN HAPPENING SINCE THE CAR WAS NEW, & SOMETIMES STAYING ON FOR WEEKS AT A TIME). WHEN ASK ABOUT THIS PROBLEM AT THE DEALERS SERVICE DEPARTMENT, THEY WERE AWARE OF THE PROBLEM AND WANTED OVER $170 TO REPAIR THIS SAFETY ISSUE AS WHEN THE AIR BAG LIGHT IS ON,THE AIRBAGS ARE NOT WORKING ACCORDING TO THE DEALERS SERVICE DEPARTMENT IN AUBURN, WA. SINCE WE STILL OWN THIS CAR, WITH LESS THAN 60,000 MILES ON IT, WE THINK THAT SUBARU SHOULD BE RESPONSIBLE FOR THIS SAFETY PROBLEM.

GAS LINES LEAK ON 2004 SUBARU FORESTER XT WHEN AMBIENT TEMPERATURES FALL BELOW 20 DEGREES FAHRENHEIT. SIGNIFICANT AMOUNTS OF FUEL LEAK INTO THE ENGINE AREA, AND STRONG FUMES ENTER THE PASSENGER AREA. NHTSA HAS ALREADY ISSUED A TSB ON THE SUBARU WXT REGARDING THE SAME PROBLEM. CONCERNED ABOUT FIRE HAZARD AND INHALATION OF GASOLINE VAPORS. *TR

HAD TIMING BELT REPLACED ON 2004 FORESTER TURBO AS RECOMMENDED ON MAINTENANCE,SCHEDULE, NEXT DAY ON HIGHWAY, LOUD SCREECHING NOISE AND LOSE OF POWER. STOPPED DRIVING TOWED TO MECHANIC. SAID IT WAS BLOWN TURBO. NEVER NOTIFIED OF BANJO BOLT ISSUE, SUBARU SHOULD RECALL OR REMEDY SITUATION AT THEIR COST. *TR

1ST ISSUE WITH 2004 FXT 4AT . COLD START EMITTING RAW FUEL SMELL BOTH IN AND OUTSIDE OF CAR. LOCAL SHOP DIAGNOSED AS WEAK CONNECTIONS ON FUEL FILTER. FILTER NEEDED REPLACEMENT IN 5,000 MILES, SO OPTED TO SWAP OUT TO A NEW OEM FILTER. NEXT DAY SMELL STILL PRESENT. TEMPS BELOW FREEZING FOR PAST 6 WEEKS (MICHIGAN), BUT PROBLEM ONLY STARTED 1 WEEK AGO. SINCE PROBLEM PERSISTS, DOING MORE RESEARCH, AND WILL CONTACT SOA AND LOCAL SUB DEALER FOR ASSISTANCE AND PLAN. NO OTHER FUEL COMPLAINTS (KNOCK, STALL, ROUGH IDLE, ECONOMY ISSUES). CURRENT MILEAGE 109,000. *TR

WE OWNED A 2004 SUBARU FORESTER FOR 6 YEARS. 2 YEARS AGO I EXPERIENCED AN INCIDENT WHERE STARTING OUT THE ACCELERATOR STUCK AT AN ADVANCED RATE OF SPEED. I WAS ABLE TO QUICKLY GAIN CONTROL AND BRAKE THE VEHICLE AND THOUGHT IT WAS AN ABERRATION. RECENTLY ON STARTING OUT FROM A FERRY BOAT THE ACCELERATOR AGAIN STUCK AT AN ADVANCED RATE OF SPEED. I AVOIDED PEOPLE AND MANY CARS BUT DID COLLIDE WITH A WALL AND 1 CAR, FINALLY STOPPING THE SUBARU BY DRIVING UP A HILL, OVER A CURB AND INTO A FENCE. I HAD MECHANICS CHECK THE ACCELERATOR SYSTEM. THEY SAID THEY COULD FIND NO DEFECT IN THE SYSTEM BUT THAT OTHER FACTORS COULD CONTRIBUTE TO "STICKING" SUCH AS FAULTY FLOOR MATS OR PLACEMENT OD BRAKE AND/OR ACCELERATOR PEDALS. I AM NOT AN EXPERT BUT MY EXAMINATION INDICATES (1) THERE IS APPROXIMATELY 2 INCH GAP BETWEEN THE FRONT OF THE ACCELERATOR PEDAL AND THE FLOOR (2)THAT T HE BRAKE AND ACCELERATOR PEDALS ARE QUITE CLOSE TOGETHER; AND THAT A FOOT COULD BECOME "HUNG UP" OR LODGED BECAUSE OF EITHER OR BOTH OF THESE THINGS. THIS POSSIBILITY COULD BE INCREASED BY LARGER FEET, ALTHOUGH I DO NOT CONSIDER MY SIZE 11 WIDTH EE SHOE SIZE TO BE OVERLY LARGE. MY NON-EXPERT OPINION IS THAT THESE PEDALS SHOULD BE RE-ENGINEERED SO THAT (1) THERE IS NO GAP OF THE ACCELERATOR TO THE FLOOR (2)THERE IS A CLEAR SEPARATION OF THE BRAKE AND ACCELERATOR PEDALS. *TR

STRONG SMELL OF GAS INSIDE THE CAR IN COLD WEATHER. REPLACED AND TIGHTENED FUEL CLAMPS, TO NO AVAIL. A RECALL WAS ISSUED FOR THE SAME SYSTEM ON THE WRX, WHY NOT THE FORESTER? *LN

STRONG ODOR OF RAW GASOLINE IN CABIN DURING COLD WEATHER WHEN VEHICLE IS STOPPED. SEEMS TO BE THE FUEL LEAK IN THE ENGINE COMPARTMENT THAT MANY OTHER SUBARU FORESTER XT OWNERS ARE EXPERIENCING. *LN

2004 SUBARU FORESTER LEAKS FUEL DIRECTLY ONTO MANIFOLD IN CONDITIONS OF COLD AMBIENT TEMPERATURE. RESEARCH REVEALS THE PROBLEM IS ENDEMIC TO VIRTUALLY ALL SUBARUS MODEL YEARS 2002 - 2004. IN 2009, SUBARU ISSUED A RECALL FOR 2002 IMPREZA WRX MODELS SOLD IN CERTAIN STATES, BUT THE ENGINE IS THE SAME DESIGN FOR THE OTHER MODELS. STRONG ODOR OF FUEL IN PASSENGER COMPARTMENT IS SYMPTOMATIC. STRONG RISK OF FIRE. ODOR ABATES WHEN ENGINE AND/OR AMBIENT TEMPERATURES RISE. *TR