2004 SUBARU IMPREZA Complaints

I ARRIVED AT A GAS STATION WHERE I FILLED UP MY SUBARU IMPREZA RS 2.5L WITH 87 UNLEADED MID GRADE FUEL AND FROM THAT POINT ON STILL TILL TODAY MY VEHICLE HAS HAS THE CHECK ENGINE LIGHT ON, WHEN THE AIR CONDITIONER IS TURNED ON AND I'M GOING 55 MPH OR HIGHER GASOLINE CAN BE SMELLED WITHIN THE VEHICLE. WHEN REFUELING THE GAS PUMP CONTINOUSLY STOPS AS IF THE FUEL CHAMBER IS FULL. AFTER REFUELING THE VEHICLE FAILS TO TURN OVER OR STAGGERS WEAKLY TO START.

TL* THE CONTACT OWNS A 2004 SUBARU IMPREZA. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. ALSO, WHEN THE CONTACT FILLED UP THE FUEL TANK, THERE WAS A STRONG ODOR INSIDE THE VEHICLE. THE CONTACT ALSO LOCATED FUEL INSIDE THE VEHICLE ON THE REAR DRIVER'S SIDE. THE VEHICLE WAS TAKEN TO PAUL MILLER SUBARU (3469 US-46, PARSIPANNY, NJ) WHERE IT WAS DIAGNOSED THAT FUEL WAS LEAKING FROM ALL THE FUEL LINES UNDER THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000.

DRIVER SIDE FUEL LINE THAT IS CONNECTED TO THE FUEL RAIL UNDERNEATH THE TURBO INLET HOSE LEAKS GAS. THE SMELL IS VERY NOTICEABLE AND I'M PRETTY SURE IT'S DANGEROUS SINCE IT COULD CAUSE AN ENGINE FIRE.

DURING COLD WEATHER A STRONG SMELL OF FUEL CAN BE DETECTED COMING FROM THE ENGINE BAY WHILE BOTH MOVING AND STATIONARY. THIS PROBLEM ONLY OCCURS DURING COLDER WEATHER.

DURING THE PAST 8+ WINTERS, THERE IS A STRONG FUEL SMELL. I'VE CALLED SUBARU OF AMERICA AND THEY SAID THAT ONLY THE TWO PREVIOUS MODELS WERE RECALLED FOR THIS PROBLEM. ACCORDING TO MY RESARCH, IT SOUNDS LIKE THIS PROBLEM PERSISTS WITH MANY SUBARU MODELS. I'VE BEEN ABLE TO CLOSE THE AIR VENTS TO KEEP THE SMELL OUT IN PREVIOUS YEARS. TODAY, WHITE SMOKE STARTED TO COME OUT OF MY HOOD WHILE DRIVING AND STATIONARY. THE TEMPERATURE IS IN THE SINGLE NEGATIVE DIGITS.I BELIEVE THERE IS NOW ENOUGH FUEL LEAKAGE ONTO THE MANIFOLD THAT IT IS STARTING THE SMOKE.

IT RECENTLY BEEN COLD IN COLORADO AND NOW I HAVE THIS RAW FUEL SMELL IN CABIN DURING COLD WEATHER. FUEL LINE LEAKING COMING FROM THE RUBBER HOSE CONNECTOR LOCATED UNDER THE INTAKE MANIFOLD, BETWEEN TWO DIRECT FEED LINE TO THE INJECTOR.

UNDER COLD CONDITIONS (40F OR LESS) THE RUBBER FUEL RAILS WILL CONTRACT UNDER THE INTAKE MANIFOLD AND WILL SLOWLY LEAK GASOLINE CAUSING AN OVERWHELMING SMELL AND POSSIBILITY FOR A FIRE. THIS HAPPENS WHEN THE CAR IS BOTH STATIONARY AND UNDER MOTION. THIS PROBLEM WAS ACKNOWLEDGED IN THE YEAR 2009 FOR THE 2002-2003 YEAR MODELS FOR THE SUBARU IMPREZA WRX AND A RECALL WAS ENACTED. HOWEVER, THIS RECALL DID NOT INCLUDE THE 2004-2005 MODELS EVEN THOUGH THE SAME ENGINE WITH THE SAME FUEL RAILS WERE USED. THIS PROBLEM HAS BEEN CONSISTENT AND PREDICTABLE FOR THE 3 WINTERS THAT I HAVE OWNED THE CAR. I HAVE ALSO HEARD FROM OTHERS WITH THE SAME YEAR CAR THAT THEY ARE HAVING SIMILAR PROBLEMS. THE PICTURES I INCLUDED SHOW THE SCREW THAT CLAMPS THE RUBBER HOSES. THE GAS LEAKS AT THIS CONNECTING POINT BUT IT WAS HARD TO GET A PICTURE OF THE ACTUAL HOSES. I HAVE CONTACTED SUBARU OF AMERICA AND THEY DIRECTED ME TO BRING THIS UP WITH NHTSA. THANK YOU!

WHILE DRIVING AT ABOUT 30 MPH, THE CAR BEGAN TO SHAKE UNCONTROLLABLY. UPON INSPECTION OF THE FRONT END I SAW THAT THE LOWER SUSPENSION ARM HAD CRACKED.

DEALER CLAIMS TO HAVE PROPERLY PERFORMED A RECALL REPAIR, BUT THE PROBLEM PERSISTS I OWN A 2004 SUBARU IMPREZA. THERE IS A RECALL ON THE FRONT SUSPENSION FOR A SEVERE CORROSION ISSUE. I BROUGHT MY CAR IN TO HADDAD SUBARU FOR THE RECALL SERVICE IN 2011 I WAS RECENTLY INFORMED BY MY MECHANIC (NOT DEALER MECHANIC) THAT THE SUSPENSION IS DANGEROUSLY CORRODED AND IT "DOES NOT LOOK LIKE THE RECALL WAS PERFORMED ON THIS CAR." I HAD THIS OPINION CONFIRMED A SECOND MECHANIC. I RAISED THIS ISSUE WITH HADDAD SUBARU. THEY CONFIRM THE SUSPENSION IS DANGEROUSLY CORRODED, BUT WILL NOT REPLACE IT WITHOUT AUTHORIZATION FROM SUBARU I RAISED THIS ISSUE WITH SUBARU AMERICA AND THEY STATE THE RECALL WAS PERFORMED PREVIOUSLY BY HADAD SUBARU AND THEY HAVE NO FURTHER RESPONSIBILITY TO ADDRESS THE ISSUE. I AM DUBIOUS THE RECALL REPAIR WAS CORRECTLY PERFORMED BY HADAD SUBARU IN 2011 AND THAT IS WHY THERE IS A PROBLEM NOW. IT IS A SAFETY ISSUE, SO I HAVE FIXED IT MYSELF FOR NEARLY $1,000

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 SUBARU IMPREZA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V323000 (AIR BAGS); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.