1997 SUBARU LEGACY Complaints

I AM SURE YOU HAVE RECEIVED OTHER COMPLAINTS REGARDING THE 2.5L ENGINE IN 1997 SUBARU LEGACY GT'S. THE HEAD GASKETS ARE VERY WEAK, WHICH WHEN THEY BLOW, CAN CAUSE A LOSS OF POWER DUE TO A RUSH OF COOLANT FLOWING INTO THE SYSTEM, WHICH KILLS THE ENGINE. THIS PROBLEM IS VERY WIDESPREAD, AND SUBARU DOES NOT ADMIT ANYTHING. HOWEVER, IN CANADA, SUBARU WAS SUED FOR THIS SAME ISSUE. THERE ARE THOUSANDS OF PEOPLE OUT THERE THAT ARE EXPERIENCING ERRATIC FAILURE WITH THESE HEAD GASKETS, AND THERE ISN'T EVEN A TSB ON THEM. PLEASE, HELP US!

I WAS OUT DRIVING ON A SUNNY SUNDAY WITH A COUPLE OF FRIENDS TO SEE THE FALL COLOR, AND WITHOUT WARNING MY CAR OVERHEATED. I TOOK IT TO MY MECHANIC TO HAVE FIND OUT WHAT CAUSED THE PROBLEM AND HE SAID IT WAS A "BLOWN HEAD GASKET". I HAVE NOT HAD THE REPAIRS DONE YET BECAUSE I AM TRYING TO DECIDE WHETHER OR NOT TO PUT IN A NEW ENGINE OR JUST REPAIR THE OLD ONE. THE COST IS GOING TO BE IN EXCESS OF $1500 DOLLARS EITHER OPTION AND AFTER DOING A BIT OF RESEARCH I HAVE FOUND THAT THERE ARE MULTIPLE WEBSITES OUT THERE WITH PEOPLE WHO ARE SUFFERING THE SAME PROBLEMS. THIS PROBLEM ONLY SEEMS TO EFFECT A CERTAIN NUMBER OF YEAR MODELS AND I WOULD LIKE TO HAVE SUBARU DO SOMETHING TO HELP ALERT THOSE WHO WILL POTENTIALLY BE BUYING THESE VEHICLES WITH NO KNOWLEDGE OF WHAT THEY ARE BUYING INTO. *TR

AFTER A GAS FILL-UP, I NOTED A LARGE WET SPOT UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. BECAUSE IT SMELLS LIKE GAS, I TOOK IT TO MY AUTHORIZED SUBARU MECHANIC AND WAS ADVISED THAT THE FILLER NECK WAS LOOSE. IN ORDER TO FIX THE MANUFACTURER DEFLECTIVE, HE WOULD HAVE TO REMOVE THE REAR AXLE. SINCE THE CAR IS 11 YEARS OLD WITH OVER 83K MILES, THE CAR IS OF COURSE OUT OF WARRANTY. HOWEVER, IN MY OPTION, MY 1997 SUBARU LEGACY GT SEDAN IS NOW CONSIDERED UNSAFE TO DRIVE UNDER ANY SPEED. I RECOMMENDED THAT SUBARU TAKES THE INITIATE BY ISSUING A RECALL BEFORE SOMEONE DIES AS RESULT OF THIS MANUFACTURER DEFLECTIVE. *TR

TL*THE CONTACT OWNS A 1997 SUBARU LEGACY. THE VEHICLE IS LEAKING GASOLINE FROM THE FILLER TUBE. THE DEALER STATED THAT THE REPAIR WOULD BE THE CONTACT'S RESPONSIBILITY BECAUSE THERE WAS NO SAFETY RECALL. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 140,000 AND FAILURE MILEAGE WAS 136,000.

TL*THE CONTACT OWNS A 1997 SUBARU LEGACY. THE CONTACT NOTICED THAT THE AIR BAG WARNING LIGHT CONSTANTLY ILLUMINATES ON THE INSTRUMENT PANEL, WHICH MEANS THAT SHE COULD EXPERIENCE SPORADIC AIR BAG DEPLOYMENT OR IMPROPER DEPLOYMENT IN THE EVENT OF A CRASH. THE CONTACT TOOK THE VEHICLE TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE WAS 84,000.

IN COLD WEATHER (ZERO OR BELOW), THE BRAKE PEDAL ON MY 1997 SUBARU LEGACY SEDAN BECOMES HARD, AND WHEN I PUT IT ANY GEAR, FORWARD OR REVERSE, THE IDLE SPEED WILL CAUSE THE CAR TO MOVE AND THE BRAKES WILL NOT STOP THE CAR-I HAVE TO SHIFT INTO NEUTRAL. I HAVE LEARNED THAT PUMPING THE BRAKE PEDAL WHILE THE CAR IS AT IDLE IN N OR P WILL USUALLY HELP, AT -20 DEGREES, I HAVE TO LET THE CAR IDLE FOR 5 TO 10 MINUTES AND THEN TRY IT. THE DEALER INDICATED THAT THIS IS NOT UNCOMMON, BUT THAT THERE IS NO EASY FIX FOR THIS. THIS HAS HAPPENED EVERY WINTER SINCE I BOUGHT THE CAR IN 2001. *TR

1997 SUBARU LEGACY OUTBACK WITH SUDDEN ACCELERATION PROBLEMS. CONSUMER STATES THAT THE VEHICLE MADE A LOUD NOISE AND THE BRAKE PEDAL WENT TO THE FLOOR AND VEHICLE SURGED WITHOUT WARNING AND HIT THE VEHICLE IN FRONT OF THE CONSUMER. *KB THE CONSUMER STATED BOTH VEHICLES HAD MINIMAL DAMAGE. THE DEALER REPLACED THE FAST IDLE AIR CONTROL VALVE. THE CONSUMER DOESN'T BELIEVE THAT THE SUDDEN ACCELERATION PROBLEM HAS BEEN RECTIFIED. THE CONSUMER DIDN'T STATE IF A POLICE REPORT WAS FILED. *JB

SUDDEN OVERHEATING OCCURRING MOSTLY ABOVE 60 KM/H SYMPTOMS INCLUDED LARGE POCKETS OF AIR IN COOLING SYSTEM AS WELL AS SMALL BUBBLES. FIRST THOUGHT BY MECHANIC WAS HEAD GASKET, HOWEVER TESTS ON COOLANT SHOWED OTHERWISE. SMALL LEAK FOUND IN WATER PUMP GASKET, REPLACED ENTIRE PUMP AND GASKET, AS WELL AS THERMOSTAT, BELTS, HOSES, ETC. CURRENT RESEARCH HAS PROVEN THAT YEARS 1997 THROUGH 2002 ALL DO THIS AS A RESULT OF A DESIGN FLAW THAT CAUSES THE HEAD GASKET TO FAIL. *JB

DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON A DRY HIGHWAY, THE HOOD LATCHE FAILED AND CRACKED THE WINDSHIELD. THE CONTACT WAS ABLE TO PULL OFF OF THE ROAD. THE VEHICLE WAS TOWED TO AN AUTO BODY SHOP. UPDATED 12/28/06. *JB

FUEL TANK FILLER PIPE ROTTED OUT. PLASTIC SHIELD OVER FILLER NECK TRAPS SAND. STEEL FILLER PIPE RUSTS WHERE WET SAND IS TRAPPED AGAINST IT. INTERMITTENT FUEL LEAK DEPENDING ON FUEL LEVEL WAS THE FIRST SYMPTOM OF PROBLEM (MARKS ON DRIVEWAY). ONLY FUEL IN FILLER PIPE LEAKS. DEALERSHIP STAFF SUGGESTED THIS IS A COMMON OCCURRENCE. *NM