1997 SUBARU LEGACY Complaints

CAR WAS SOMETIMES DIFFICULT TO START, OTHER TIMES IT WOULD STALL/HESITATE WHEN IN MOTION ON CITY STREET. DISCOVERED TO BE CAUSED BY AGED/WORN FUEL PUMP CAUSING OVERCURRENT DRAW THAT FAILS TO BLOW FUSE CAUSING MELTDOWN IN WIRING HARNESS CONNECTOR WHERE PIGTAIL FROM PUMP CONNECTS TO THE CHASSIS SIDE OF THE WIRING HARNESS. HEAT/SPARK POTENTIAL IS CREATED IN CLOSE PROXIMITY TO FUEL TANK THAT HAS MANY REPORTED CASES OF FUEL FILLER NECK RUSTING OFF AND LEAKING FUEL. A QUICK GOOGLE SEARCH REVEALS THAT A NUMBER OF PEOPLE, WITH PHOTOS, HAVE EXPERIENCED THIS FAILURE. PHOTO PROVIDED IS FROM INTERNET BUT THE RESULT IS THE SAME.

1997 SUBARU LEGACY OUTBACK. CAME OUT TO MY PARKED VEHICLE WITH THE RIGHT FRONT TIRE FLAT DUE TO PART OF THE SUSPENSION SPRING BEING SNAPPED AND STICKING INTO INSIDE OF THE TIRE. SPRING WAS INTACT WHEN I PARKED IT. FRIGHTENING TO THINK IF THAT HAD HAPPENED WHILE DRIVING ON THE HIGHWAY OF WHICH I WAS THE DAY BEFORE THIS HAPPENED.

1997 SUBARU LEGACY GT 2.5L ENGINE, APPROX. 92K MILES, ENGINE STARTED OVERHEATING. CAR WAS TAKEN TO TWO DIFFERENT REPAIR FACILITIES AND DIAGNOSED AS BLOWN HEAD GASKET AFTER PRESSURE TEST, BLOCK TEST, NO SIGNS OF LEAKING. CAR HAD BEEN SERVICED FAITHFULLY BY ORIGINAL OWNER AT SUBARU DEALERSHIPS SINCE PURCHASE. I FOUND OUT THIS IS A COMMON PROBLEM FROM REPAIR FACILITIES WITH THIS MODEL AND ENGINE BUT WHEN QUESTIONED SUBARU DEALERSHIP THEY SAID IT COULDN'T HAVE HAPPENED AS HEAD GASKET AND COOLING SYSTEM ARE NOT RELATED (?) AND PROBLEM WAS A CRACKED BLOCK OR CYLINDER. ESTIMATED COST TO REPLACE HEAD GASKET $2450-. ESTIMATED COST TO REPLACE ENGINE $5700-. I HAD ALSO HAD A PROBLEM WHERE THE FUEL FILLER TUBE THAT CONNECTS TO THE GAS TANK FROM WHERE YOU PUR THE GASOLINE IN FROM THE PUMP HAD RUSTED AWAY AND LEAKED FUEL ONTO THE GROUND. I HAD THAT REPLACED AT APPROX. COST OF $400-. AGAIN SUBARU DENIED THERE WAS A PROBLEM WHEN I CALLED THE DEALERSHIP. THESE PROBLEMS OCCURRED WITH IN SIX MONTHS OF EACH OTHER. *TR

TL* THE CONTACT OWNS A 1997 SUBARU LEGACY. THE CONTACT STATED THAT THE VEHICLE BECAME STUCK IN PARK. THE FAILURE WAS RECURRING. THE VEHICLE HAD BEEN TAKEN TO AN AUTHORIZED DEALER, WHO LUBRICATED THE AUTOMATIC TRANSMISSION SHIFTER BUT TO NO AVAIL. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN BACK FOR FURTHER DIAGNOSIS AND IT WAS ADVISED THAT THE PART REQUIRED FOR THE REPAIR WAS NO LONGER AVAILABLE. THE AUTHORIZED DEALER ADVISED THE CONTACT TO PURCHASE THE SHIFT LOCK MODULE AND AN AUTHORIZED DEALER WOULD REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 75000. UPDATED 06/10/14 MA THE CONSUMER WAS INFORMED, THE PART WAS NO LONGER AVAILABLE. UPDATED 07/23/14

WHEN THE GAS TANK IS FILLED ABOVE HALF A TANK, FUEL LEAKS ONTO THE GROUND IN LARGE AMOUNTS NEAR THE REAR OF THE VEHICLE. THIS IS EXTREMELY DANGEROUS SINCE A SPARK OR CIGARETTE WOULD CAUSE AN EXPLOSION. *TR

I INSTALLED MEVOTECH STRUT MOUNTS (MP903987 & MP903986) ON OUR 1997 SUBARU LEGACY POSTAL WHEN INSTALLING NEW REAR SHOCK ABSORBER/STRUTS. THE RIGHT SIDE FAILED ON THE FIRST DAY AFTER AROUND 60 MILES. I REPLACED IT WITH THE ORIGINAL FACTORY PART THAT HAD LASTED 420,000 MILES. THE LEFT SIDE FAILED THE NEXT DAY AFTER BEING IN SERVICE FOR APPROXIMATELY 100 MILES TOTAL. I RETURNED THE OTHER ORIGINAL PART TO SERVICE. THE FAILURES ALLOWED THE STRUT TO PUSH THROUGH THE MOUNT AND HIT ON THE THIN RETAINING PLATE. IT ALLOWED THE REAR SUSPENSION TO BECOME EXTREMELY LOUD AND LOOSE. I REPORTED THIS TO THE MANUFACTURER AND RECEIVED NO RESPONSE. I REPORTED IT TO THE SELLER, ROCKAUTO, AND THEIR RESPONSE WAS THAT I SHOULD DO MORE RESEARCH ON PART QUALITY. I BELIEVE THERE IS A DIFFERENCE BETWEEN POOR QUALITY AND DANGEROUS DEFECT. I HAVE THE FAULTY MEVOTECH PARTS IN THEIR ORIGINAL BOXES. *TR

MY FUEL FILLER RUSTED OFF @ THE FUEL TANK CAUSING IT TO LEAK ON THE GROUND WHEN THE TANK IS NEARLY FULL.I HAVE READ OTHER COMPLAINTS ABOUT THIS PROBLEM.IT'S A BIG JOB FOR A DIY.YOU NEED TO DROP THE REAR DIFFERENTIAL , DRIVE SHAFT , MUFFLER , ETC..IS THIS SOMETHING SUBARU COVERS COST WISE? *TR

TL* THE CONTACT OWNS A 1997 SUBARU LEGACY. THE CONTACT ATTEMPTED TO START THE IGNITION AND THE ENGINE FAILED TO START. THE BATTERY WAS JUMP STARTED; HOWEVER THE FAILURE RECURRED WHILE DRIVING. THE BATTERY WAS RECHARGED FOR A SECOND TIME. THE CONTACT REPLACED THE BATTERY TERMINAL DUE TO SEVERE RUST AND CORROSION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. UPDATED 02/28/12 *BF THE CONSUMER STATED BATTERY CORROSION DESTROYED THE NEGATIVE TERMINAL. UPDATED 03/08/12

GASOLINE FILLER TUBE ON SUBARU LEGACY MODELS (1994 & 1997) RUST OUT AND CAUSE VERY SERIOUS DANGER FROM POSSIBLE FIRE/EXPLOSION DUE TO LEAKING FUEL. THIS APPEARS TO BE A VERY COMMON PROBLEM FOR SUBARU OWNERS AND COSTLY ($350+) TO REPAIR. THIS PART WAS REPLACED ON BOTH A 1994 AND A 1997 SUBARU LEGACY AND THE REPAIR SHOP INDICATED THAT THIS IS A COMMON PROBLEM THAT THEY HAVE DEALT WITH QUITE OFTEN. I FEEL THE PROBLEM IS VERY DANGEROUS AND SHOULD BE ADDRESSED BY THE MANUFACTURER. *TR

1997 SUBARU LEGACY 2.5 L ENGINE. 118,000 MILES. CHRONIC OVERHEATING. MANY DOLLARS SPENT ONLY TO FIND THAT THESE CARS ARE NOTORIOUS FOR BLOWING HEAD GASKETS. SURE ENOUGH, THAT'S THE TROUBLE. *TR